滑移区稀薄气体外掠圆柱体换热的数值分析

王鑫宝 1; 厉彦忠 1; 2; 谢福寿 1; 王娇娇 1; 王磊 1

doi:10.7652/xjtuxb201710015

您当前的位置：

首页 >

文章列表页 >

滑移区稀薄气体外掠圆柱体换热的数值分析

更新时间：2025-07-09

- 滑移区稀薄气体外掠圆柱体换热的数值分析
- Numerical Analysis for Forced Convection Heat Transfer of Rarefied Gas Across Circular Cylinder in Slip Flow Region
- 西安交通大学学报 2017年51卷第10期页码：88-93
- 作者机构：
  
  西安交通大学能源与动力工程学院,西安,710049
- 作者简介：
- 基金信息：
  
  : 2017-01-08。作者简介: 王鑫宝(1993—),男,硕士生;厉彦忠(通信作者),男,教授,博士生导师。基金项目: 国家自然科学基金资助项目(51376142);航天低温推进剂技术国家重点实验室开放课题资助项目(SKLTSCP1610)
- DOI：10.7652/xjtuxb201710015
  中图分类号： V511
- 网络首发：2017-10-10，
  
  纸质出版：2017
- 稿件说明：
移动端阅览
王鑫宝 1, 厉彦忠 1, 2, 等. 滑移区稀薄气体外掠圆柱体换热的数值分析[J]. 西安交通大学学报, 2017,51(10):88-93.

Numerical Analysis for Forced Convection Heat Transfer of Rarefied Gas Across Circular Cylinder in Slip Flow Region[J]. 2017, 51(10): 88-93.
王鑫宝 1, 厉彦忠 1, 2, 等. 滑移区稀薄气体外掠圆柱体换热的数值分析[J]. 西安交通大学学报, 2017,51(10):88-93. DOI： 10.7652/xjtuxb201710015.

Numerical Analysis for Forced Convection Heat Transfer of Rarefied Gas Across Circular Cylinder in Slip Flow Region[J]. 2017, 51(10): 88-93. DOI： 10.7652/xjtuxb201710015.

摘要

针对滑移流区稀薄气体横掠圆柱体的强制对流换热问题

采用气体分子动力学

对速度滑移与温度跳跃边界条件以热流密度项与壁面切应力项形式进行修正

并植入到Fluent软件中

实现滑移流区换热的数值模拟。对雷诺数Re范围为0.001～20、克努森数Kn范围为0.001～3的工况进行了数值计算

并与实验结果进行对比。结果表明:采用滑移边界修正的CFD模型

可实现对稀薄气体滑移流区流动换热的精确模拟; 当气体流态处于连续流状态(Kn≤0.01)时

边界条件的变化对数值结果影响不大; 当气体流态处于滑移流状态(Kn范围为0.01～0.1)时

采用提出的滑移边界修正模型将能得到更加准确的计算结果; 并且采用该模型可以对部分过渡流区(0.1<Kn<2)的换热进行数值预示。此方法可广泛应用于工程中滑移区流体的换热情况

为研究稀薄气体滑移流区流动换热问题提供一种有效的数值模拟方法。

Abstract

For lift-off of launch vehicles

the flow regimes of gas over the wall of the tank varies with altitude

which leads to changing characteristics of the heat transfer between the tank wall and atmosphere. To reveal the characteristics of convective heat transfer across a circular cylinder for rarefied gas

the boundary conditions for the velocity slip and temperature jump are presented. A modified method of Fluent model is developed to predict the heat transfer in slip flow region within the ranges of Reynolds number from 0.001 to 20 and Knudsen number from 0.001 to 3

and in these regions

the numerical simulation results are compared with the experimental data. The results show that in continuous flow region(Kn≤0.01)

different boundary conditions exert little influence on the results. However

for slip flow region(0.01<Kn≤0.1)

the predicted results with the modified boundary condition become more accurate

and this method with the modified boundary condition could extend to partial transition flow region(0.1<Kn<2)to predict heat exchange.

关键词

Keywords

references

TSIEN H S. Superaerodynamics, mechanics of rarefied gases [J]. Journal of the Aeronautical Sciences, 1946, 13(1): 653-664.

WETZEL W, ERTEL H. Monte Carlo simulations of hypersonic flows past blunt bodies [J]. Journal of Thermophysics and Heat Transfer, 1990, 4(2): 157-161.

DOGRA V K, MOSS J N, WILMOTH R G, et al. Hypersonic rarefied flow past spheres including wake structure [J]. Journal of Spacecraft and Rockets, 1994, 31(5): 713-718.

LIU H C F, BESKOK A, GATSONIS N, et al. Flow past a microsphere in a pipe: effects of rarefaction [C]∥ASME 1998 Dynamic System and Control Conference: Micro-Electro-Mechanical Systems. New York, USA: ASME, 1998: 445-452.

王娴, 王秋旺, 陶文铨. 稀薄气体二维外部柱体绕流特性研究 [C]∥2002年中国工程热物理学会传热传质学学术会议论文集. 北京: 工程热物理学会, 2002: 298-300.

BOYLAN D E. Laminar convective heat-transfer rates on a hemisphere cylinder in rarefied hypersonic flow [J]. AIAA Journal, 1971, 9(8): 1661-1663.

李志辉, 彭傲平, 吴俊林, 等. 稀薄气体自由分子流到连续流跨流域气动力热绕流统一算法研究 [J]. 载人航天, 2013, 19(2): 81-91.

LI Zhihui, PENG Aoping, WU Junlin. Gas-kinetic unified algorithm for aerothermodynamics from free-molecular flow to continuum regime [J]. Manned Spaceflight, 2013, 19(2): 81-91.

MAXWELL J C. On stresses in rarefied gases arising from inequalities of temperature [J]. Philosophical Transactions of the Royal Society of London, 1879, 170: 231-256.

YUN K Y, AGARWAL R K, BALAKRISHANA R. Hypersonic flow computations in the continuum-transition regime using the augmented Burnett and BGK-Burnett equations [C]∥Sixteenth International Conference on Numerical Methods in Fluid Dynamics. Berlin, Germany: Springer, 1998: 560-565.

RIJ J V, AMEEL T, HARMAN T. An evaluation of secondary effects on microchannel frictional and convective heat transfer characteristics [J]. International Journal of Heat and Mass Transfer, 2009, 52: 2792-2801.

LE N T P, ROOHI E. A new form of the second-order temperature jump boundary condition for the low-speed nanoscale and hypersonic rarefied gas flow simulations [J]. International Journal of Thermal Sciences, 2015, 98: 51-59.

陈熙. 动力论及其在传热与流动研究中的应用 [M]. 北京: 清华大学出版社, 1996: 187-236

朱恂. 速度滑移及温度跳跃区微尺度通道内的流动与换热[D]. 重庆: 重庆大学, 2002: 21-23

HILPERT R. Heat transfer from cylinders [J]. Forsch Geb Ingenieurwes, 1933, 4: 215-224.

KNUDSEN J D, KATZ D L. Fluid dynamics and heat transfer [M]. New York, USA: McGraw-Hill, 1958: 40-44.

XIE Fushou, LI Yanzhong, LIU Zhan, et al. A forced convection heat transfer correlation of rarefied gases cross-flowing over a circular cylinder [J]. Experimental Thermal and Fluid Science, 2016, 80: 327-336.

MORGAN V T. The overall convective heat transfer from smooth circular cylinders [J]. Advances in Heat Transfer, 1975, 11: 199-264.

FAND R M, KESWANI K K. A continuous correlation equation for heat transfer from cylinders to air in crossflow for Reynolds numbers from 10-2 to 2×105 [J]. International Journal of Heat and Mass Transfer, 1972, 15(3): 559-562.

KING L V. On the convection of heat from small cylinders in a stream of fluid: determination of the convection constant of small platinum wires with applications to hot-wire anemometry [J]. Philosophical Transactions of the Royal Society of London: Series A, 1914, 214: 373-432.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

太阳能烟囱发电系统内传热问题的数值分析

单圆弧等厚叶片前后缘多元耦合仿生设计及降噪机理研究

600 MW超临界W火焰锅炉流动不稳定性数值分析

超临界循环流化床锅炉水冷壁并联双通道内流动不稳定性数值分析

求解滑移流区外掠圆柱体气流流动与传热特性的数值模型