方管内混合对流与管壁导热耦合换热的数值模拟

张颖莉; 种道彤; 刘继平; 严俊杰

您当前的位置：

首页 >

文章列表页 >

方管内混合对流与管壁导热耦合换热的数值模拟

更新时间：2025-05-08

- 方管内混合对流与管壁导热耦合换热的数值模拟
- Numerical Investigation on Conjugated Heat Transfer of Conduction in Wall and Mixed Convection
- 西安交通大学学报 2012年46卷第5期页码：19-24+43
- 作者机构：
  
  西安交通大学能源与动力工程学院,西安,710049
- 作者简介：
- 基金信息：
  
  : 2011-11-22. 作者简介: 张颖莉(1984-),女,博士生;刘继平(通信作者),男,教授. 基金项目: 国家自然科学基金资助项目(51176147);国家科技支撑计划资助项目(2011BAA04B03)
- DOI：
  中图分类号： TK124
- 网络首发：2012-05-10，
  
  纸质出版：2012
- 稿件说明：
移动端阅览
张颖莉, 种道彤, 刘继平, 等. 方管内混合对流与管壁导热耦合换热的数值模拟[J]. 西安交通大学学报, 2012,46(5):19-24+43.

Numerical Investigation on Conjugated Heat Transfer of Conduction in Wall and Mixed Convection[J]. 2012, 46(5): 19-24+43.
张颖莉, 种道彤, 刘继平, 等. 方管内混合对流与管壁导热耦合换热的数值模拟[J]. 西安交通大学学报, 2012,46(5):19-24+43. DOI：

Numerical Investigation on Conjugated Heat Transfer of Conduction in Wall and Mixed Convection[J]. 2012, 46(5): 19-24+43. DOI：

摘要

针对方管内空气混合对流时的流固耦合换热问题

提出将壁面导热作为边界条件进行处理的壁面导热与流动耦合简化计算方法

推导了计算公式

并采用SIMPLER算法进行了数值模拟.算法忽略壁面沿厚度方向的导热

假设管壁温度沿轴向一维分布

采用热量平衡法建立边界单元的能量守恒方程

将固体区域的导热简化为流体区域的边界条件

以提高计算的精度和可靠性.计算结果表明

受二次流影响

沿通道周向热量从加热面同时沿顺时针和逆时针方向迅速向两边传递

各壁面最大温差小于0.5 ℃

在轴向归一化长度为2～4时壁面轴向导热热流密度出现最值.平均Nusselt数Nu

随Reynolds数Re及方管倾斜角度θ的增大而增大

最优倾角在-30°和0°之间变化

但当Re>1 500时

随θ的变化近似保持不变.计算结果与实验数据吻合良好

最大偏差小于±28.7%.

Abstract

The conjugated heat transfer of heat conduction in the wall and air mixed convection in tubes was numerically simulated with the SIMPLER algorithm and a new simplified method developed for dealing with conjugated problems. The results show that the circumferential conductive heat of the duct plate moves in both clockwise and anticlockwise directions

and the temperature difference of each plate is less than 0.5 ℃. In the axial direction

the maximum conductive heat flux occurs at the places where the axial non-dimensional length equals 2-4. The average Nusselt number increases with the Reynolds number and the inclination angle of the tube

and the optimum inclination angle is a variable value from -30° to 0°. However

the average Nusselt number is almost independent of the inclination angle when Re>1 500. The numerical results are in reasonably good agreement with the experimental data with the deviations within ±28.7%.

关键词

Keywords

references

METAIS B, ECKERT E. Forced, mixed and free convection regimes[J]. ASME J Heat Transfer, 1964, 86: 295-296.

JACKSON J D, COTTON M A, AXCELL B P. Studies of mixed convection in vertical tubes [J]. Int J Heat and Fluid Flow, 1989, 10(1): 2-15.

陶文铨. 数值传热学[M]. 2版. 西安:西安交通大学出版社,2000.

FAGHRI M, SPARROW E M. Simultaneous wall and fluid axial conduction in laminar pipe-flow heat transfer[J]. ASME J Heat Transfer, 1980, 102(1): 58-64.

YU W S, LIN H T, HWANG T Y. Conjugate heat transfer of conduction and forced convection along wedges and a rotating cone[J]. Int J Heat and Mass Transfer, 1991, 34(10): 2497-2507.

CHAR M I, CHANG C L. Effect of wall conduction on natural convection flow of micropolar fluids along a flat plate[J]. Int J Heat and Mass Transfer, 1997, 40(15): 3641-3652.

HEGGS P J, INGHAM D B, KEEN D J. The effects of heat conduction in the wall on the development of recirculating combined convection flows in vertical tubes[J]. Int J Heat and Mass Transfer, 1990, 33(3): 517-528.

BILGEN E. Conjugate heat transfer by conduction and natural convection on a heated vertical wall [J]. Applied Thermal Engineering, 2009, 29(2/3): 334-339.

NOUANEGUE H F, MUFTUOGLU A, BILGEN E. Heat transfer by natural convection, conduction and radiation in an inclined square enclosure bounded with a solid wall[J]. Int J Thermal Sciences, 2009, 48(5): 871-880.

KIM D C, CHOI Y D. Analysis of conduction-natural convection conjugate heat transfer in the gap between concentric cylinders under solar irradiation[J]. Int J Thermal Sciences, 2009, 48(6): 1247-1258.

ZHANG W, ZHANG C, XI G. Conjugate conduction-natural convection in an enclosure with time-periodic sidewall temperature and inclination [J]. Int J Heat and Fluid Flow, 2011, 32(1): 52-64.

苏波,钱若军,韩向科. 一种用于流固耦合分析的有限元网格简捷更新方法[J]. 西安交通大学学报,2011,45(3): 16-24.

SU Bo, QIAN Ruojun,HAN Xiangke. Improved finite element mesh update method for fluid structure interaction analysis[J]. Journal of Xi'an Jiaotong University, 2011, 45(3): 16-24.

种道彤,刘继平,严俊杰. 矩形通道内置加热板混合对流的实验研究[J]. 西安交通大学学报,2006,40(7): 753-756.

CHONG Daotong, LIU Jiping, YAN Junjie. Experimental investigation of mixed convection in rectangular channel with attached flat heated plate[J]. Journal of Xi'an Jiaotong University, 2006, 40(7): 753-756.

CHONG D, LIU J, YAN J, et al. Experimental investigation of mixed convection in a rectangular duct with a heated plate in the middle of cross section[J]. Heat and Mass Transfer, 2007, 43(12): 1283-1291.

CHONG D T, LIU J P, YAN J J. Effects of duct inclination angle on thermal entrance region of laminar and transition mixed convection[J]. Int J Heat and Mass Transfer, 2008, 51(15/16): 3953-3962.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

液氢管路输运中静电积聚机理与电流密度分布特征研究

X射线辐照下聚酰亚胺材料空间电荷分布特性的数值模拟

异质裂隙内超临界CO2地热提取特性数值模拟研究

工质与叶轮传热对超临界二氧化碳向心透平气动性能与流动特性的作用机制

机翼近场尾流流动特性的附着涡模型分析