扇贝仿生密封腔室内超临界二氧化碳泄漏流湍动能耗散机理研究

张恩搏; 冯彦力; 吴一鸣; 沈明芋; 赵昆鹏; 白博峰

doi:10.7652/xjtuxb202607002

您当前的位置：

首页 >

文章列表页 >

扇贝仿生密封腔室内超临界二氧化碳泄漏流湍动能耗散机理研究

专题超临界流体前沿应用 | 更新时间：2026-07-09

- 扇贝仿生密封腔室内超临界二氧化碳泄漏流湍动能耗散机理研究
- Turbulent Kinetic Energy Dissipation Mechanism of Supercritical Carbon Dioxide Leakage Flow in a Scallop Bionic Seal Cavity
- 西安交通大学学报 2026年60卷第7期页码：13-23
- 作者机构：
  
  西安交通大学绿色氢电全国重点实验室，710049，西安
- 作者简介：
  
  作者简介：张恩搏（1992—），男，助理教授，硕士生导师；
  白博峰（通信作者），男，教授，博士生导师。
- 基金信息：
  
  国家自然科学基金资助项目(52506193);中国博士后创新人才支持计划资助项目(BX20240283);陕西省“三秦学者”创国家一流团队资助项目(2023STD03)
- DOI：10.7652/xjtuxb202607002
  中图分类号： TK05
- 收稿：2025-10-29，
  
  纸质出版：2026-07-10
- 稿件说明：
移动端阅览
张恩搏, 冯彦力, 吴一鸣, 等. 扇贝仿生密封腔室内超临界二氧化碳泄漏流湍动能耗散机理研究[J]. 西安交通大学学报, 2026,60(7):13-23.

ZHANG Enbo, FENG Yanli, WU Yiming, et al. Turbulent Kinetic Energy Dissipation Mechanism of Supercritical Carbon Dioxide Leakage Flow in a Scallop Bionic Seal Cavity[J]. Journal of Xi'an Jiaotong University, 2026, 60(7): 13-23.
张恩搏, 冯彦力, 吴一鸣, 等. 扇贝仿生密封腔室内超临界二氧化碳泄漏流湍动能耗散机理研究[J]. 西安交通大学学报, 2026,60(7):13-23. DOI： 10.7652/xjtuxb202607002.

ZHANG Enbo, FENG Yanli, WU Yiming, et al. Turbulent Kinetic Energy Dissipation Mechanism of Supercritical Carbon Dioxide Leakage Flow in a Scallop Bionic Seal Cavity[J]. Journal of Xi'an Jiaotong University, 2026, 60(7): 13-23. DOI： 10.7652/xjtuxb202607002.

摘要

为准确表征扇贝仿生密封腔室内超临界二氧化碳（sCO

）泄漏流的复杂流动过程，揭示泄漏流湍动能耗散机理，提出了旋转机械强变物性真实气体流动高精度数值模拟方法。该数值模拟方法采用单体迎风格式实现数值通量分裂，通过高阶迎风方案实现数值通量三阶重构。所用欧拉全隐时间步进迭代方法支持多线程共享存储并行计算；采用了真实气体状态方程与亥姆霍兹自由能热物性查询表耦合迭代计算方法，可准确捕捉CO

热物性非线性变化特征，计算偏差小于0.5%；通过分子示踪实验验证了数值模拟方法的准确性，并深入分析了扇贝仿生密封腔室内泄漏流涡旋空间分布及其对湍动能耗散率的影响机理。研究结果表明：sCO

泄漏流进入密封腔室后发生膨胀，动能转化为压力势能，泄漏流当地马赫数降低至0.1以下，泄漏速率随之降低，泄漏流在高速转子剪切作用下产生涡旋并发生迁移、分裂和分离行为；泄漏流正则化螺旋度呈现正负值交替特征，表明密封腔室内存在多组顺、逆时针反向涡旋；每组反向涡旋有助于增强泄漏流湍动能耗散，无量纲湍动能耗散率大于1.95×10

，可有效改善密封封严性能；反向涡旋外缘交界点即为湍动能耗散率极值点，涡旋转向改变同样会增大泄漏流的湍动能耗散率。

Abstract

To accurately characterize the complex flow process of supercritical carbon dioxide（sCO

）leakage flow in a scallop bionic seal cavity and to elucidate the mechanism of turbulent kinetic energy（TKE）dissipation，a high-order numerical simulation method for real gas flows with strongly variable physical properties in rotating machinery was proposed.In this method，the uni-particle upwind scheme was employed for numerical flux splitting，while third-order numerical flux reconstruction was achieved via the simple high-resolution upwind method.Euler's fully implicit time-stepping iterative method was implemented，supporting open multi-processing（OpenMP）shared-memory parallel computing.A coupled iterative calculation method，integrating a real gas equation of state（EOS）with Helmholtz free energy-based thermophysical property lookup table，was adopted to

accurately capture the nonlinear variations in CO

thermophysical properties，with calculation deviations below 0.5%.The accuracy of this numerical simulation method was validated through molecular tracing experiments.Furthermore，the spatial distribution of leakage flow vortices within the scallop bionic seal cavity and its impact on the TKE dissipation rate were analyzed in detail.The results indicate that as the sCO

leakage flow enters the seal cavity，expansion occurs，while the local Mach number remains below 0.1.Under the rapid shear of the rotor，the leakage flow generates vortices that exhibit migration，splitting，and separation behaviors.The normalized helicity of the leakage flow exhibits alternating positive and negative values，indicating the presence of multiple sets of counter-rotating（clockwise and counterclockwise）vortices within the seal cavity.Each set of counter-rotating vortices increases the dimensionless TKE dissipation rate to over 1.95 × 10

，thereby effectively improving sealing performance.Moreover，the extrema of the TKE dissipation rate were identified at the outer boundaries of these counter-rotating vortices，where changes in vortex rotation direction also increase the TKE dissipation rate of the leakage flow.

关键词

Keywords

references

何雅玲, 李梦杰, 郭嘉琪, 等.二氧化碳热力循环在新型能源系统应用中的研究现状与发展趋势[J].科学通报, 2025, 70(7):872-887.

He Yaling, Li Mengjie, Guo Jiaqi, et al.Advances and development trend of carbon dioxide thermodynamic cycles applied in novel energy systems [J].Chinese Science Bulletin, 2025, 70(7):872-887.

姜培学, 金红光.面向“双碳”目标的能源转化利用领域前沿交叉战略研究[J].科学通报, 2024, 69(34):5007-5015.

Jiang Peixue, Jin Hongguang.A strategic study of interdisciplinary frontier in the field of energy conversion and utilization for the “dual carbon”goals [J].Chinese Science Bulletin, 2024, 69(34):5007-5015.

Wang Rui, Wang Xuan, Bian Xingyan, et al.An optimal split ratio in design and control of a recompression supercritical CO 2 Brayton system [J ] .Energy, 2023, 277:127676.

Zheng Nan, Li Ziyang, Fang Jiabin, et al.Supercritical CO 2 mixture Brayton cycle with floating critical points for concentrating solar power application: concept and thermodynamic analysis [J ] .Energy Conversion and Management, 2023, 284:116989.

Lee W, Yoo S, Park D, et al.Design considerations of the supercritical carbon dioxide Brayton cycle of small modular molten salt reactor for ship propulsion [J]. Progress in Nuclear Energy, 2023, 163:104835.

Feng Jiaqi, Cui Hongbo, Zhang Enbo, et al.Variable load operation characteristics of CO 2 closed cycle system for unmanned underwater vehicle [J ] .Energy, 2025, 335:138371.

Ma Xiaofeng, Jiang Peixue, Zhu Yinhai.Dynamic simulation and analysis of transient characteristics of a thermalto-electrical conversion system based on supercritical CO 2 Brayton cycle in hypersonic vehicles [J ] .Applied Energy, 2024, 359:122686.

Li Yuzhe, Zhang Enbo, Feng Jiaqi, et al.Reduced-dimensional prediction method for the axial aerodynamic forces in the off-design operation of near-critical CO 2 centrifugal compressors [J ] .Energy, 2024, 302:131791.

胡乐豪, 邓清华, 刘洲洋, 等.超临界二氧化碳迷宫密封内摩擦损失数值研究及流动特性分析[J].西安交通大学学报, 2023, 57(3):68-78.

Hu Lehao, Deng Qinghua, Liu Zhouyang, et al.Numerical investigation for windage loss and flow characteristics analysis with supercritical CO 2 in labyrinth seal [J ] .Journal of Xi'an Jiaotong University, 2023, 57(3):68-78.

Zhang Xuan, Jiang Jinbo, Peng Xudong, et al.Leakage reduction by optimization of hole-pattern damping seal with inclined hole cavity [J].International Journal of Heat and Mass Transfer, 2021, 169:120924.

Wright S, Radel R, Vernon M, et al.Operation and analysis of a supercritical CO 2 Brayton cycle [EB/OL ] . [2025-05-17 ] .https://digital.library.unt.edu/ark:/67531/metadc1014473/m2/1/high_res_d/984129.pdf.

Wang Yize, Liu Zhenqing.A bionic design of oscillating wave surge energy converter based on scallops [J]. Energy, 2024, 304:132236.

Wang Yumo, Pang Shunxiang, Jin Hu, et al.Development of a biomimetic scallop robot capable of jet propulsion [J].Bioinspiration & Biomimetics, 2020, 15(3):036008.

Bushuk M, Holland D, Stanton T, et al.Ice scallops: a laboratory investigation of the ice-water interface [J]. Journal of Fluid Mechanics, 2019, 873:942-976.

Zhang Enbo, Watanebe T, Himeno T, et al.Leakage reduction mechanism of supercritical CO 2 scallop damper seal:vortex structure and turbulence dissipation [J ] .Physics of Fluids, 2023, 35(5):056108.

杨富方, 刘航滔, 杨震, 等.超临界二氧化碳循环工质热物性研究进展[J].热力发电, 2020, 49(10):21-29.

Yang Fufang, Liu Hangtao, Yang Zhen, et al.Thermophysical properties of working fluid of supercritical carbon dioxide cycle:research progress [J].Thermal Power Generation, 2020, 49(10):21-29.

Patankar S, Spalding D.A calculation procedure for heat, mass and momentum transfer in three-dimensional parabolic flows [J].International Journal of Heat and Mass Transfer, 1972, 15(10):1787-1806.

Van Doormaal J, Raithby G.Enhancement of the SIM-PLE method for predicting incompressible fluid flow [J]. Numerical Heat Transfer, 1984, 7(2):147-163.

Issa R.Solution of the implicitly discretised fluid flow equations by operator-splitting [J].Journal of Computational Physics, 1986, 62(1):40-65.

Toro E.Riemann solvers and numerical methods for fluid dynamics: a practical introduction [M].Berlin, Germany: Springer, 2009:265-282.

Gottleb S, Shu Chiwang.Total variation diminishing Runge-Kutta schemes [J].Mathematics of Computation, 1998, 67(221):73-85.

Obayashi S, Guruswamy G.Convergence acceleration of a Navier-Stokes solver for efficient static aeroelastic computations [J].AIAA Journal, 1995, 33(6):1134-1141.

Nan Xi, Himeno T, Watanabe T.Real gas effects on inlet boundary condition with supercritical CO 2 as the working fluid [C ] //Proceedings of the Asian Congress on Gas Turbines.Seoul, Korea: Seoul National University, 2014:1-6.

Yoon S, Jameson A.Lower-upper symmetric-Gauss-Seidel method for the Euler and Navier-Stokes equations [J].AIAA Journal, 1988, 26(9):1025-1026.

Blazek J.Computational fluid dynamics: principles and applications [M].3rd ed.Oxford, UK:Butterworth-Heinemann, 2015:29-59.

Peng Dingyu, Robinson D.A new two-constant equation of state [J].Industrial & Engineering Chemistry Fundamentals, 1976, 15(1):59-64.

Lemmon E, Bell I, Huber M, et al.NIST standard reference database23:reference fluid thermodynamic and transport properties-REFPROP, Version 10.0, standard reference data program [EB/OL].[2025-05-17].https://www.nist.gov/publications/nist-standard reference-database-23-reference-fluid-thermodynamic-and-transport.

张小昆, 张海滨, 张彪, 等.联乙酰分子磷光特性及示踪流场测速应用研究[J].工程热物理学报, 2023, 44(9):2486-2495.

Zhang Xiaokun, Zhang Haibin, Zhang Biao, et al. Study on the phosphorescence characteristics of diacetyl molecules and the application of molecular tagging velocimetry [J].Journal of Engineering Thermophysics, 2023, 44(9):2486-2495.

Wu Yiming, Zhang Enbo, Bai Bofeng.A novel optimization of blade angle distribution for supercritical CO 2 centrifugal compressor based on the artificial neural network [J ] .Energy Conversion and Management, 2025, 344:120305.

Xu Hongyi, Cai Xiaoshu, Liu Chaoqun.Liutex (vortex)core definition and automatic identification for turbulence vortex structures [J].Journal of Hydrodynamics, 2019, 31(5):857-863.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

超临界二氧化碳向心透平轮背间隙内风阻损失及流动特性研究

超临界二氧化碳开采干热岩热量过程中裂隙网络的热流固耦合分析

超临界二氧化碳向心透平流动损失分解及损失特性研究

工质与叶轮传热对超临界二氧化碳向心透平气动性能与流动特性的作用机制

语义区分和子图整合驱动的知识图谱表示学习方法