废纸造纸废水特征污染物对流化床结晶反应器除钙的影响

李凡; 葛强; 周贤波; 汪雨佳; 朱丛韵; 刘和芳; 刘桂芳; 刘宽勇; 杨树成

doi:10.7652/xjtuxb202602013

您当前的位置：

首页 >

文章列表页 >

废纸造纸废水特征污染物对流化床结晶反应器除钙的影响

专题 “双碳”背景下的污染控制与资源化利用 | 更新时间：2026-02-09

- 废纸造纸废水特征污染物对流化床结晶反应器除钙的影响
- Impact of Characteristic Pollutants in Waste Paper Pulping Wastewater on Calcium Removal by Fluidized Bed Crystallization Reactor
- 西安交通大学学报 2026年60卷第2期页码：136-146
- 作者机构：
  
  西安交通大学能源与动力工程学院，710049，西安
  中国轻工业长沙工程有限公司，410114，长沙
  制浆造纸污水循环回用与超低排放技术湖南省工程研究中心，410114，长沙
  贵州鹏昇（集团）纸业有限责任公司，552401，贵州黔西南布依族苗族自治州
- 作者简介：
  
  作者简介：李凡（2002—），女，硕士生；
  杨树成（通信作者），男，副教授，博士生导师。
- 基金信息：
  
  云南省新能源材料创新联合体项目(202302AB080018)
- DOI：10.7652/xjtuxb202602013
  中图分类号： X703
- 收稿：2025-05-30，
  
  纸质出版：2026-02-10
- 稿件说明：
移动端阅览
李凡, 葛强, 周贤波, 等. 废纸造纸废水特征污染物对流化床结晶反应器除钙的影响[J]. 西安交通大学学报, 2026,60(2):136-146.

LI Fan, GE Qiang, ZHOU Xianbo, et al. Impact of Characteristic Pollutants in Waste Paper Pulping Wastewater on Calcium Removal by Fluidized Bed Crystallization Reactor[J]. Journal of Xi'an Jiaotong University, 2026, 60(2): 136-146.
李凡, 葛强, 周贤波, 等. 废纸造纸废水特征污染物对流化床结晶反应器除钙的影响[J]. 西安交通大学学报, 2026,60(2):136-146. DOI： 10.7652/xjtuxb202602013.

LI Fan, GE Qiang, ZHOU Xianbo, et al. Impact of Characteristic Pollutants in Waste Paper Pulping Wastewater on Calcium Removal by Fluidized Bed Crystallization Reactor[J]. Journal of Xi'an Jiaotong University, 2026, 60(2): 136-146. DOI： 10.7652/xjtuxb202602013.

摘要

针对废纸造纸复杂水质对Ca

去除的影响，系统研究了挥发性脂肪酸、纤维素、木质素3类特征污染物对流化床结晶反应器（FBCR）除钙性能的影响。通过pH-stat法测定污染物存在时碳酸钙的结晶速率，采用能谱仪、红外光谱和热质量分析对使用后晶种进行表征，探究其影响机制。结果表明：由于乙酸根离子在晶种表面的竞争性吸附及其与Ca

的配位作用，挥发性脂肪酸抑制Ca

的去除，当乙酸钠的浓度为20 mmol·L

-1

时，Ca

去除率由41.3%降至24.6%；微晶纤维素在不同质量浓度下与晶种表面的相互作用不同，所以对碳酸钙结晶的影响随质量浓度增加先促进后抑制，当微晶纤维素的质量浓度为100 mg·L

-1

时，Ca

去除率达到最大值56.8%；由于晶种表面活性位点的螯合以及溶液中游离Ca

的配位作用，木质素显著抑制碳酸钙在晶种表面的生长，当木质素质量浓度为240 mg·L

-1

时，Ca

去除率从38.0%下降到13.0%。该研究明晰了特征污染物对FBCR除钙过程的复杂机制，为实现更好的除钙效果，建议经预处理进入FBCR的废水中挥发性脂肪酸浓度小于2.5 mmol·L

-1

、纤维素质量浓度小于200 mg·L

-1

、木质素质量浓度小于15 mg·L

-1

。

Abstract

The influence of complex water quality in waste paper pulping on Ca

removal was systematically investigated，focusing on the effects of three characteristic pollutants—volatile fatty acids，cellulose，and lignin—on the calcium removal performance of a fluidized bed crystallization reactor（FBCR）.The crystallization rate of calcium carbonate in the presence of these pollutants was measured using the pH-stat method，and spent seed crystals were characterized by energy dispersive spectroscopy，infrared spectroscopy，and thermogravimetric analysis to explore the underlying mechanisms.The results show that volatile fatty acids inhibit Ca

removal due to competitive adsorption of acetate ions on the seed crystal surface and their complexation with Ca

.When sodium acetate concentration reached 20 mmol·L

-1

，the Ca

removal rate decreased from 41.3% to 24.6%.Microcrystalline cellulose interacted differently w

ith seed crystal surfaces at varying mass concentrations，leading to a concentration-dependent effect on calcium carbonate crystallization：promotion at lower levels and inhibition at higher levels.At a microcrystalline cellulose concentration of 100 mg·L

-1

，the Ca

removal rate reached a maximum of 56.8%.Lignin significantly inhibited calcium carbonate growth on seed crystals due to chelation of active surface sites and complexation with free Ca

in solution.At a lignin concentration of 240 mg·L

-1

，the Ca

removal rate dropped from 38.0% to 13.0%.This study clarifies the complex mechanisms by which characteristic pollutants influence the FBCR calcium removal process. To achieve improved calcium removal，it is recommended that pretreated wastewater entering the FBCR contain volatile fatty acids below 2.5 mmol·L

-1

，cellulose below 200 mg·L

-1

，and lignin below 15 mg·L

-1

关键词

Keywords

references

中国造纸协会.2023中国造纸工业年度报告[J].中华纸业, 2024, 45(5):15-24.

China Paper Association.2023 China paper industry annual report[J].China Pulp & Paper Industry, 2024, 45(5):15-24.

崔明启,张弛,陈逸帆,等.造纸废水曝气池中钙的去除及迁移转化规律研究[J].环境科学学报, 2020, 40(6):2128-2135.

CUI Mingqi, ZHANG Chi, CHEN Yifan, et al.Study on the removal, migration and transformation of calcium in the aeration tank of paper mill wastewater[J]. Acta Scientiae Circumstantiae, 2020, 40 (6 ):2128-2135.

NIE Xiaobao, WANG Zhengbo, WAN Junli, et al. Competition between homogeneous and heterogeneous crystallization of CaCO 3 during water softening[J ] . Water Research, 2024, 250:121061 .

GUI Lintao, YANG Haitao, HUANG Hui, et al. Liquid solid fluidized bed crystallization granulation technology: development, applications, properties, and prospects[J].Journal of Water Process Engineering, 2022, 45:102513.

赵党阳,郭徽,王耀,等.厌氧颗粒污泥钙化的研究进展[J].河南化工, 2021 , 38(10):8-10.

ZHAO Dangyang, GUO Hui, WANG Yao, et al.Research progress of anaerobic granular sludge calcification[J].Henan Chemical Industry, 2021, 38 (10):8-10.

RUIZ-AGUDO E, PUTNIS C V, RODRIGUEZ-NA-VARRO C, et al.Effect of pH on calcite growth at constant https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=100167142&type= https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=100167142&type=small https://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=100167142&type=middle ratio and supersaturation[J ] . Geochimica et Cosmochimica Acta, 2011, 75(1):284-296.

TAI C Y, CHANG M C, SHIEH R J, et al.Magnetic effects on crystal growth rate of calcite in a constant-composition environment[J]. Journal of Crystal Growth, 2008, 310(15):3690-3697.

SONG Qingsi, GE Qiang, ZHOU Xianbo, et al.Ca-CO 3 accumulation in the wastewater treatment system of a recycled paper mill with zero-liquid discharge[J ] . Water Environment Research, 2025 , 97(6):e70094.

中华人民共和国环境保护部.制浆造纸工业污染防治可行技术指南:HJ 2302—2018[S].北京:中国环境科学出版社, 2018.

胡瑞柱,黄廷林,刘泽男.碳酸钙诱导结晶动力学影响因素研究[J].中国环境科学, 2021, 41 (8 ):3584-3589.

HU Ruizhu, HUANG Tinglin, LIU Zenan.Influencing factors of induced crystallization kinetics of calci-um carbonate[J]. China Environmental Science, 2021 , 41(8):3584-3589.

HACHT B.Complex formation of acetic acid with Ca(Ⅱ)and Mg (Ⅱ)under physiological conditions[J]. Journal of Solution Chemistry, 2008, 37 (2 ):155-163.

陆洲,聂小保,余志,等.高硬水软化中Fe 3 O 4 诱导结晶对微晶形成的控制[J ] .环境工程学报, 2021, 15(2):563-571.

LU Zhou, NIE Xiaobao, YU Zhi, et al.Control of the microcrystal formation during high-hardness water softening with Fe 3 O 4 induced-crystallization[J ] .Chinese Journal of Environmental Engineering, 2021, 15 (2):563-571 .

孟浩江,张蕾,张祎,等.微晶纤维素基碳酸钙复合材料对Cd 2+ 和Pb 2+ 的捕集与回收研究[J ] .应用化工, 2024, 53(4):832-837.

MENG Haojiang, ZHANG Lei, ZHANG Yi, et al. Trapping and recovery of Pb 2+ and Cd 2+ by microcrys-talline cellulose-based calcium carbonate composites[J ] . Applied Chem ical Industry, 2024, 53(4):832-837.

ABUSHAMMALA H, MAO Jia.Impact of the surface properties of cellulose nanocrystals on the crystallization kinetics of poly(butylene succinate)[J].Crystals, 2020, 10(3):196.

BRODIN F W, GREGERSEN Ø W, SYVERUD K. Cellulose nanofibrils:challenges and possibilities as a paper additive or coating material:a review[J].Nordic Pulp & Paper Research Journal, 2014, 29 (1 ):156-166.

张桐荣,宋立新,李明昊,等.木质素-Ca 2+ 络合物微粒的制备及其改性聚乙烯醇薄膜的研究[J ] .塑料科技, 2024, 52(2):64-68.

ZHANG Tongrong, SONG Lixin, LI Minghao, et al. Preparation of lignin-Ca 2+ complex microparticles and study on their modification of polyvinyl alcohol films[J ] . Plastics Science and Technology, 2024, 52(2):64-68.

陈秋菊.磷石膏制备碳酸钙的工艺技术与反应过程研究[D].绵阳:西南科技大学, 2021.

赵瑾,李彦军,成国祥.羟丙基甲基纤维素凝胶模板合成碳酸钙晶体[J].科学通报, 2007, 52(4):394-398.

ZHAO Jin, LI Yanjun, CHENG Guoxiang.Synthesis of calcium carbonate crystal using hydroxypropyl methyl cellulose as template[J].Chinese Science Bulletin, 2007, 52(4):394-398.

SÁENZ EZQUERRO C, LASPALAS M, GARCÍA AZNAR J M, et al.Monitoring interactions through molecular dynamics simulations:effect of calcium carbonate on the mechanical properties of cellulose composites[J].Cellulose, 2023, 30(2):705-726.

ZHANG Yang, CUI Shiqiang, LIAO He, et al.Poly (butylene succinate )/cellulose composite monofilaments with microelastic response based on interfacial bonding[J].Carbohydrate Polymers, 2023, 302:120387.

LAVOINE N, DESLOGES I, DUFRESNE A, et al. Microfibrillated cellulose:its barrier properties and applications in cellulosic materials:a review[J].Carbohydrate Polymers, 2012, 90(2):735-764.

竹文坤,罗学刚,贺攀,等.木质素对碳酸钙结晶行为的影响[J].林产化学与工业, 2010, 30(6):7-12.

ZHU Wenkun, LUO Xuegang, HE Pan, et al.Effects of lignin on crystallization of calcium carbonate[J]. Chemistry and Industry of Forest Products, 2010, 30(6):7-12.

赵小红,陈家莉,梁小惠.不同类型木质素基表面活性剂为控制剂制备碳酸钙[J].无机盐工业, 2021, 53 (7):58-62.

ZHAO Xiaohong, CHEN Jiali, LIANG Xiaohui. Preparation of calcium carbonate using different type of lignin based surfactant as control agents[J].Inorganic Chemicals Industry, 2021, 53(7):58-62.

LIU Huijun, SUN Dayu, YANG Lei, et al.Pretreatment of enzymatic hydrolysis lignin based on deep eutectic solvent containing a reversibly-soluble base[J]. International Journal of Biological Macromolecules, 2025, 301 :140452.

PANG Tairan, WANG Guanhua, SUI Wenjie, et al. Lignin-based support for metal catalysts: synthetic strategies, performance boost, and application advances[J].Coordination Chemistry Reviews, 2025, 528:216426.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

废纸造纸废水特征污染物对流化床结晶反应器除钙的影响

扇贝仿生密封腔室内超临界二氧化碳泄漏流湍动能耗散机理研究

面向高海拔空冷发电机防晕性能演化规律的电热耦合研究

张角凹坑气膜孔对双层壁气膜冷却特性的影响

采用机器学习的大规模并行程序I/O性能建模与预测方法