电动车CO<sub>2</sub>、R290热泵通用化系统构建及其性能影响特性

曹志简; 宗硕; 张翌晨; 管燕; 王知明; 殷翔; 曹锋

doi:10.7652/xjtuxb202601003

您当前的位置：

首页 >

文章列表页 >

电动车CO₂、R290热泵通用化系统构建及其性能影响特性

专题　新能源电动车辆热管理 | 更新时间：2026-01-15

- 电动车CO₂、R290热泵通用化系统构建及其性能影响特性
- Construction of Generalized CO₂and R290 Heat Pump Systems for Electric Vehicles and Their Performance Impact Characteristics
- 西安交通大学学报 2026年60卷第1期页码：22-30
- 作者机构：
  
  西安交通大学能源与动力工程学院，710049，西安
- 作者简介：
  
  作者简介：曹志简（2002—），男，硕士生；
  殷翔（通信作者），男，副教授。
- 基金信息：
  
  广东省重点研发计划资助项目(2023 B0909050005);陕西省自然科学基础研究计划资助项目(2025JC-YBMS-382)
- DOI：10.7652/xjtuxb202601003
  中图分类号： U463.85
- 收稿：2025-04-17，
  
  纸质出版：2026-01-10
- 稿件说明：
移动端阅览
曹志简, 宗硕, 张翌晨, 等. 电动车CO₂、R290热泵通用化系统构建及其性能影响特性[J]. 西安交通大学学报, 2026,60(1):22-30. DOI: 10.7652/xjtuxb202601003.

CAO Zhijian, ZONG Shuo, ZHANG Yichen, et al. Construction of Generalized CO₂and R290 Heat Pump Systems for Electric Vehicles and Their Performance Impact Characteristics[J]. Journal of Xi'an Jiaotong University, 2026, 60(1): 22-30. DOI: 10.7652/xjtuxb202601003.
曹志简, 宗硕, 张翌晨, 等. 电动车CO₂、R290热泵通用化系统构建及其性能影响特性[J]. 西安交通大学学报, 2026,60(1):22-30. DOI: 10.7652/xjtuxb202601003. DOI：

CAO Zhijian, ZONG Shuo, ZHANG Yichen, et al. Construction of Generalized CO₂and R290 Heat Pump Systems for Electric Vehicles and Their Performance Impact Characteristics[J]. Journal of Xi'an Jiaotong University, 2026, 60(1): 22-30. DOI: 10.7652/xjtuxb202601003. DOI：

摘要

针对汽车空调R134a制冷剂替代及电动车冬季续航衰减问题，以通用化载冷剂回路构建通用化的CO

及R290间接热泵系统。首先，建立了通用载冷剂系统的CO

、R290通用化热泵空调系统仿真模型并进行实验验证；然后，研究了换热器配置和水路流量对热泵空调性能的影响和通用化系统衰减特性；最后，提出了两种循环的通用设计和控制策略，评估了通用化系统对整车续航的影响。结果表明：调节水路流量能够有效解决通用化系统性能衰减问题；采用串联多个暖风芯体作为室内换热器的通用化方案并对水路流量加以调节，能够同时满足CO

间接系统及R290间接系统的换热需求，通用化系统造成R290系统性能衰减为2.46%，CO

系统性能最优。

Abstract

In response to the challenges of R134a refrigerant replacement in automotive air conditioning and winter range attenuation in electric vehicles，the generalized indirect heat pump systems for CO

and R290 were constructed by applying a generalized secondary-loop circuit. Firstly，a simulation model of the generalized CO

and R290 heat pump air conditioning systems with a secondary-loop were established and experimentally validated.Subsequently，the effects of heat exchanger configuration and water circuit flow rate on the performance of the heat pump system，as well as the performance attenuation characteristics of the generalized systems，were investigated.Finally，a generalized design and control strategy for both cycles were proposed，and the impac

t of the generalized system on vehicle range was also evaluated.The results indicate that adj usting the water circuit flow rate can effectively mitigate the performance degradation of the generalized systems.By employing a configuration with multiple serially connected heating cores as the indoor heat exchanger and regulating the water circuit flow rate，the heat transfer requirements of both the CO

indirect system and the R290 indirect system can be simultaneously met.The performance degradation of the R290 system due to generalization was 2.46%，while the CO

system achieved optimal performance.

关键词

Keywords

references

刘俊任,贾思敏,韦学优,等.电动汽车冬季续航里程缩减原因分析[J].汽车维护与修理,2022(7):73-75.

LIU Junren,JIA Simin,WEI Xueyou,et al.Analysis of reasons for the reduction of electric vehicle winter range[J].Auto Maintenance & Repair,2022(7):73-75.

ZHANG Ziqi,WANG Dandong,ZHANG Chengquan, et al.Electric vehicle range extension strategies based on improved AC system in cold climate:a review[J]. International Journal of Refrigeration,2018,88:141-150.

张凯,欧阳洪生,张董鑫,等.电动汽车热泵空调冷媒研究进展[J].浙江化工,2021 ,52(7):6-12.

ZHANG Kai,OUYANG Hongsheng,ZHANG Dongxin,et al.Research progress of heat pump air conditioning refrigerants for electric vehicles[J].Zhejiang Chemical Industry,2021,52(7):6-12.

邹慧明,唐坐航,杨天阳,等.电动汽车热管理技术研究进展[J].制冷学报,2022,43(3):15-27.

ZOU Huiming,TANG Zuohang,YANG Tianyang,et al.Review of research on thermal management technology for electric vehicles[J].Journal of Refrigeration, 2022,43(3):15-27.

王丹东,陈江平,俞彬彬,等.CO 2 车用热泵空调系统技术研发及性能提升[J ] .制冷学报,2018,39(5):47-52.

WANG Dandong,CHEN Jiangping,YU Binbin,et al.Technology development and performance improvement of CO 2 automobile heat pump air-conditioning system[J ] . Journal of Refrigeration,2018,39(5):47-52.

宗硕,肖迪,王海丹,等.电动车辆热管理系统中CO 2 工质替代方案对续航里程的影响[J ] .西安交通大学学报,2024,58(12):1-10.

ZONG Shuo,XIAO Di,WANG Haidan,et al.Impact of CO 2 refrigerant substitution scheme in the thermal management system of electric vehicles on driving range[J ] . Journal of Xi'an Jiaotong University,2024,58(12):1-10.

AUSTIN B T,SUMATHY K.Transcritical carbon dioxide heat pump systems:a review[J].Renewable and Sustainable Energy Reviews,2011,15(8):4013-4029.

李江峰,李帅旗,宋文吉,等.电动汽车CO 2 热泵空调系统优化及制冷性能分析[J ] .可再生能源,2024,42 (5):612-619.

LI Jiangfeng,LI Shuaiqi,SONG Wenji,et al.Optimization and cooling performance analysis of CO 2 heat pump air conditioning system for electric vehicle[J ] . Renewable Energy Resources,2024,42(5):612-619.

GULLO P,KÆRN M R.Experimental performance comparison of various expansion devices for small-capacity subcritical R744 vapour-compression refrigeration units[J].International Journal of Refrigeration, 2024,168:768-776.

SUN Dahan,FEI Teng,LIU Zekuan,et al.Performance analysis of a new transcritical R744 refrigeration cycle with expander-mechanical overheating[J].Applied Thermal Engineering,2023,218:119285.

张振宇,王丹东,陈江平,等.带喷射器的CO 2 汽车空调系统性能研究[J ] .制冷技术,2020,40(5):33-40.

ZHANG Zhenyu,WANG Dandong,CHEN Jiangping,et al.Experimental investigation on CO 2 automotive air-conditioning system with ejector[J ] .Chinese Journal of Refrigeration Technology,2020,40 (5):33-40.

JIA Fan,YIN Xiang,HE Shentong,et al.Steadystate and dynamic experimental study of an enhanced automotive thermal management system based on energy cascade utilization[J].Energy,2025,316:134542.

BANI ISSA A A,LIANG Changkuan,GROLL E A, et al.Residential heat pump and air conditioning systems with propane (R290)refrigerant:technology review and future perspectives[J].Applied Thermal Engineering,2025,266:125560.

WANG Haimin,JI Zhiyuan,WANG Chuanwei,et al. Experimental study of propane heat pump system with secondary loop and vapor injection for electric vehicle application in cold climate[J].Applied Thermal Engineering,2022,217:119196.

ZOU Lingeng,YU Jianlin.4E assessment of ejectorenhanced R290 heat pump cycle with a sub-cooler for cold region applications[J].Energy,2024,298:131369.

DHAMODHARAN P, SALMAN M, PRABAKARAN R,et al.Thermo-hydraulic behavior and flow boiling characteristics of R290 in plate heat exchangers for electric vehicle heat pump applications under cold climatic conditions[J].International Journal of Heat and Mass Transfer,2024,235:126165.

NING Qian,HE Guogeng,LI Baofeng,et al.Theoretical and simulation analysis for R290 leakage from split-type air conditioners[J].International Journal of Refrigeration,2024,166:139-148.

WANG Linlin,HE Yu,REN Jiabao,et al.Simulation of diffusion of combustible refrigerants R1234yf and R290 leakage in automotive air conditioning[J]. International Journal of Refrigeration,2024,168:326-333.

任兆龙,管燕,殷翔,等.新PFASs限制法案提案下汽车空调替代制冷剂的对比与展望[J].制冷学报, 2024,45(4):1-13.

REN Zhaolong,GUAN Yan,YIN Xiang,et al.Comparison and prospect of alternative refrigerants for MAC based on new PFASs restriction regulation proposal[J].Journal of Refrigeration,2024,45 (4):1-13.

GAO Enyuan,CUI Qi,JING Huaqian,et al.A review of application status and replacement progress of refrigerants in the Chinese cold chain industry[J].International Journal of Refrigeration, 2021, 128:104-117.

ZONG Shuo,YIN Xiang,MIAO Tongyu,et al.Experimental investigation on the cooling performance of direct and secondary loop CO 2 air conditioning systems for electric vehicles[J ] .International Journal of Refrigeration,2023,152:376-386.

WANG Kai,EISELE M,HWANG Y,et al.Review of secondary loop refrigeration systems[J].International Journal of Refrigeration,2010,33(2):212-234.

LI Wanyong,LIU Yusheng,LIU Rui,et al.Performance evaluation of secondary loop low-temperature heat pump system for frost prevention in electric vehicles[J]. Applied Thermal Engineering,2021,182:115615.

方健珉,王静,孙西峰,等.回热器对电动汽车跨临界CO 2 制冷系统影响的实验研究[J ] .西安交通大学学报,2020,54(6):155-160.

FANG Jianmin,WANG Jing,SUN Xifeng,et al. Effect of internal heat exchanger on transcritical CO 2 refrigeration system of electric vehicle[J ] .Journal of Xi'an Jiaotong University,2020,54(6):155-160.

吴靖,陈海涛,任亚超,等.电动汽车间接式热泵空调系统的制热性能实验研究[J].制冷技术,2022 ,42 (6):49-54.

WU Jing,CHEN Haitao,REN Yachao,et al.Experimental investigation on heating performance of indirect heat pump air conditioning system for electric vehicles[J]. Chinese Journal of Refrigeration Technology,2022,42 (6):49-54.

WANG Fengxian,WU Weidong,HUANG Yichen,et al.Experimental study on optimal heating cycle characteristics of CO 2 secondary throttling heat pump system for electric vehicles[J ] .Energy Conversion and Management,2023,295:117626.

WANG Haidan,CAO Feng,JIA Fan,et al.Potential assessment of transcritical CO 2 secondary loop heat pump for electric vehicles[J ] .Applied Thermal Engineering,2023,224:119921.

YIN Jianmin,BULLARD C W,HRNJAK P S.R-744 gas cooler model development and validation[J].International Journal of Refrigeration,2001,24 (7):692-701 .

YUN R,KIM Y,PARK C.Numerical analysis on a microchannel evaporator designed for CO 2 air-conditioning systems[J ] .Applied Thermal Engineering,2007,27(8/9):1320-1326.

黄悦.基于R290热泵空调的电动汽车热管理研究[D].上海:上海电机学院,2023.

WU Jing,ZHOU Guoliang,WANG Mingyu.A comprehensive assessment of refrigerants for cabin heating and cooling on electric vehicles[J].Applied Thermal Engineering,2020,174:115258.

BELLOCCHI S,LEO GUIZZI G,MANNO M,et al. Reversible heat pump HVAC system with regenerative heat exchanger for electric vehicles:analysis of its impact on driving range[J].Applied Thermal Engineering,2018,129:290-305.

王静,孙西峰,方健珉,等.跨临界CO 2 汽车空调多PID控制动态性能仿真研究[J ] .西安交通大学学报, 2020,54(8):168-176.

WANG Jing,SUN Xifeng,FANG Jianmin,et al.Dynamic simulation o f PID control in transcritical CO 2 automobile air conditioning system[J ] .Journal of Xi'an Jiaotong University,2020,54(8):168-176.

宋昱龙,唐学平,王守国,等.空气源跨临界CO 2 热泵最优排气压力的理论和实验[J ] .西安交通大学学报,2014,48(9):81-87.

SONG Yulong,TANG Xueping,WANG Shouguo,et al.Theoretical and experimental investigation for optimal discharge pressure of air-source trans-critical CO 2 heat pump[J ] .Journal of Xi'an Jiaotong University, 2014,48(9):81-87.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

电动车CO2、R290热泵系统通用化构建及其性能影响特性

电动车辆间接热系统快速除湿响应迟滞机理及优化控制策略

R41跨临界单级压缩带回热器热泵系统研究

语义区分和子图整合驱动的知识图谱表示学习方法

离子液体改性燃料的电流体动力学效应研究

电动车CO2、R290热泵通用化系统构建及其性能影响特性

Construction of Generalized CO2and R290 Heat Pump Systems for Electric Vehicles and Their Performance Impact Characteristics

DOI：10.7652/xjtuxb202601003

摘要

Abstract

关键词

Keywords

references

电动车CO₂、R290热泵通用化系统构建及其性能影响特性

Construction of Generalized CO₂and R290 Heat Pump Systems for Electric Vehicles and Their Performance Impact Characteristics