流热固影响下汽轮机叶片强度与振动特性研究

樊昕燕; 袁奇; 刘阳

doi:10.7652/xjtuxb202512013

您当前的位置：

首页 >

文章列表页 >

流热固影响下汽轮机叶片强度与振动特性研究

更新时间：2025-12-08

- 流热固影响下汽轮机叶片强度与振动特性研究
- Research on the Strength and Vibration Characteristics of Turbine Blades under Fluid-Thermal-Solid Conditions
- 西安交通大学学报 2025年59卷第12期页码：149-160
- 作者机构：
- 作者简介：
  
  作者简介：樊昕燕（2002—），女，硕士生；
  袁奇（通信作者），男，教授，博士生导师。
- 基金信息：
  
  国家自然科学基金资助项目(12372057);国家科技重大专项资助项目。(J2019-Ⅳ-0005-0072)
- DOI：10.7652/xjtuxb202512013
  中图分类号： TK262
- 收稿：2025-04-04，
  
  纸质出版：2025-12-10
- 稿件说明：
移动端阅览
樊昕燕, 袁奇, 刘阳. 流热固影响下汽轮机叶片强度与振动特性研究[J]. 西安交通大学学报, 2025,59(12):149-160.

FAN Xinyan, YUAN Qi, LIU Yang. Research on the Strength and Vibration Characteristics of Turbine Blades under Fluid-Thermal-Solid Conditions[J]. Journal of Xi'an Jiaotong University, 2025, 59(12): 149-160.
樊昕燕, 袁奇, 刘阳. 流热固影响下汽轮机叶片强度与振动特性研究[J]. 西安交通大学学报, 2025,59(12):149-160. DOI： 10.7652/xjtuxb202512013.

FAN Xinyan, YUAN Qi, LIU Yang. Research on the Strength and Vibration Characteristics of Turbine Blades under Fluid-Thermal-Solid Conditions[J]. Journal of Xi'an Jiaotong University, 2025, 59(12): 149-160. DOI： 10.7652/xjtuxb202512013.

摘要

为准确分析汽轮机叶片在多物理场下的失效问题，综合考虑了温度梯度、气动力、离心力等载荷对叶片强度和振动的影响。基于多重参考系与有限元联合仿真方法，在离心力、温度梯度和气动力单独及综合作用下，对某汽轮机第8级动、静叶片开展数值计算，进行强度和振动校核以及参数敏感性分析，获得了汽轮机叶片在流热固影响下的强度和振动特性。计算结果表明：静、动叶片的总变形分别为0.0791、1.0934 mm，最大等效应力分别为92.45、470.28 MPa，能够满足强度和振动要求；对动、静叶片进行强度计算时需考虑气动力和热应力的影响，模态分析时需考虑弹性模量随温度的变化以及离心力作用；随着转速、入口温度和入口压力的升高，动、静叶片的总变形和等效应力均增大；动叶片模态频率随着转速升高而增大，动、静叶片模态频率随着入口温度和入口压力的升高而下降。该研究可为汽轮机叶片流热固影响下强度和振动的计算校核及特性研究提供理论依据。

Abstract

When turbine blades fail in multi-physical fields

accurate analysis of the failure requires comprehensive consideration of how temperature gradient

aerodynamic force

centrifugal force and other loads affect the strength and vibration of the blades.For the purpose of this research

a joint simulation based on multiple reference systems and finite elements was implemented for numerical calculations

strength and vibration checks

and parameter sensitivity analyses regarding the 8th stage rotor and stator blades of a steam turbine under the separate and combined effects of centrifugal force

temperature gradient

and aerodynamic force to derive the strength and vibration characteristics of the turbine blades under the fluid-heat-solid conditions.According to the calculation results

the total deformation of the stator and rotor blades is 0.0791 mm and 1.0934 mm

respectively

and the maximum equivalent stress is 92.45 MPa and 470.28 MPa

respectively

which can meet the strength and vibration requirements.For strength calculation of the rotor and stator blades

the influence of aerodynamic force and thermal stress was considered. For modal analysis

the change in elastic modulus with temperature and the effect of centrifugal force was considered.An increase in the total deformation and equivalent stress of both rotor and stator blades was observed as the rotational speed

inlet temperature

and inlet pressure rose；the modal frequency of rotor blades increased with the rotational speed

while the modal frequency of both rotor and stator blades decreased as the inlet temperature and inlet pressure went up.This study may provide a theoretical basis for strength and vibration calculations

verification

and characteristic research of turbine blades under the influence of fluid-thermal-solid conditions.

关键词

Keywords

references

李宗全 , 牛夕莹 , 安仲玉 , 等 . 双层涡轮叶片应力计算与分析 [J ] . 热能动力工程 , 2024 , 39 ( 2 ): 11 - 18 .

LI Zongquan , NIU Xiying , AN Zhongyu , et al . Strength calculation and analysis of double-layer turbine blade [J ] . Journal of Engineering for Thermal Energy and Power , 2024 , 39 ( 2 ): 11 - 18 .

石清鑫 , 袁奇 . 某型燃气轮机透平转子的稳态温度场及应力场分析 [J ] . 振动与冲击 , 2010 , 29 ( S ): 110 - 113 .

SHI Qingxin , YUAN Qi . Steady-state temperature field and stress field analysis of a gas turbine rotor [J ] . Vibration and Shock , 2010 , 29 ( S ): 110 - 113 .

何玉灵 , 王烁 , 白洁 . 流固热耦合下汽轮机末级叶片破坏规律分析 [J ] . 电力科学与工程 , 2020 , 36 ( 10 ): 63 - 69 .

HE Yuling , WANG Shuo , BAI Jie . Damage regularity of last turbine stage blade under fluid-solid-thermal coupling action [J ] . Electric Power Science and Engineering , 2020 , 36 ( 10 ): 63 - 69 .

李大海 , 蒋勇 , 侯天强 , 等 . 基于流固耦合的液力变矩器涡轮叶片结构强度分析 [J ] . 机械工程师 , 2025 ( 2 ): 138 - 141 .

LI Dahai , JIANG Yong , HOU Tianqiang , et al . Structure strength analysis of torque converter turbine blade based on the fluid-structure interaction [J ] . Me chanical Engineer , 2025 ( 2 ): 138 - 141 .

HWANG S , SON C , SEO D , et al . Comparative study on steady and unsteady conjugate heat transfer analysis of a high pressure turbine blade [J ] . Applied Thermal Engineering , 2016 , 99 : 765 - 775 .

徐建新 , 许立敬 . 基于流热固耦合的航空发动机涡轮叶片仿真分析 [J ] . 航空科学技术 , 2023 , 34 ( 2 ): 26 - 33 .

XU Jianxin , XU Lijing . Simulation analysis on aeroengine turbine blades based on fluid-thermal-solid coupling [J ] . Aeronautical Science & Technology , 2023 , 34 ( 2 ): 26 - 33 .

徐健 , 霍施宇 , 孙鹏 . 基于多场耦合的涡轮叶片静强度计算分析 [J ] . 兵器装备工程学报 , 2023 , 44 ( 6 ): 148 - 153 .

XU Jian , HUO Shiyu , SUN Peng . Analysis on static strength of turbine blades based on multi-field coupling [J ] . Journal of Ordnance Equipment Engineering , 2023 , 44 ( 6 ): 148 - 153 .

周渝航 , 林枫 , 侯隆安 , 等 . 单晶涡轮叶片强度分析与结构优化设计 [J ] . 热能动力工程 , 2023 , 38 ( 11 ): 56 - 62 .

ZHOU Yuhang , LIN Feng , HOU Longan , et al . Strength analysis and structural optimization design of single crystal turbine blade [J ] . Journal of Engineering for Thermal Energy and Power , 2023 , 38 ( 11 ): 56 - 62 .

谢永慧 , 邓实 , 张荻 , 等 . 基于热流固耦合分析的重型燃气轮机透平高压叶片寿命研究 [J ] . 热力透平 , 2011 , 40 ( 3 ): 151 - 158 .

XIE Yonghui , DENG Shi , ZHANG Di , et al . Study on life prediction for HP turbine blade of heavy-duty gas turbine based on analysis of multi-factor coupling physical fields [J ] . Thermal Turbine , 2011 , 40 ( 3 ): 151 - 158 .

李立波 , 李帅 , 杜悦 , 等 . 630℃超超临界二次再热汽轮机末级长叶片振动特性分析 [J ] . 电站系统工程 , 2024 , 40 ( 6 ): 44 - 46 .

LI Libo , LI Shuai , DU Yue , et al . Analysis of vibration characteristics of 1450 mm last stage long blade of 630℃ultrasupercritical reheat steam turbine [J ] . Power System Engineering , 2024 , 40 ( 6 ): 44 - 46 .

付曦 , 刘云 , 张俊红 , 等 . 气流激励下压气机叶片动力学特性分析 [J ] . 机械设计与制造 , 2024 , 406 ( 12 ): 258 - 263 .

FU Xi , LIU Yun , ZHANG Junhong , et al . Dynamics analysis of compressor blade under aerodynamic excitation [J ] . Machinery Design & Manufacture , 2024 , 406 ( 12 ): 258 - 263 .

杜大华 , 黄道琼 , 黄金平 , 等 . 火箭发动机涡轮盘模态影响因素与振动安全性分析 [J ] . 火箭推进 , 2021 , 47 ( 1 ): 21 - 28 .

DU Dahua , HUANG Daoqiong , HUANG Jinping , et al . Analysis on modal influence factors and vibration safety of rocket engine turbine disk [J ] . Journal of Rocket Propulsion , 2021 , 47 ( 1 ): 21 - 28 .

RODRÍGUEZ J A , CASTRO L , TEJEDA A L , et al . Fatigue of steam turbine blades at resonance conditions [J ] . Engineering Failure Analysis , 2019 , 104 : 39 - 46 .

艾书民 , 王克明 , 缪辉 , 等 . 稳态温度场作用下涡轮叶片振动特性的研究 [J ] . 沈阳航空航天大学学报 , 2011 , 28 ( 4 ): 17 - 21 .

AI Shumin , WANG Keming , MIAO Hui , et al . Research on turbine blade vibration characteristic under steady state temperature field [J ] . Journal of Shenyang Aerospace University , 2011 , 28 ( 4 ): 17 - 21 .

孙芳锦 , 李传玺 , 张羽佟 , 等 . 基于流固耦合的风力机叶片强度与模态分析 [J ] . 兰州工业学院学报 , 2025 , 32 ( 1 ): 1 - 10 .

SUN Fangjin , LI Chuanxi , ZHANG Yutong , et al . Strength and modal analysis of wind turbine blades based on fluid-structure coupling [J ] . Journal of Lanzhou Institute of Technology , 2025 , 32 ( 1 ): 1 - 10 .

李春旺 , 李海云 , 王澈 , 等 . 航空发动机涡轮叶片振动模态影响因素研究 [J ] . 空军工程大学学报（自然科学版) , 2014 , 15 （ 1 ): 5 - 9 .

LI Chunwang , LI Haiyun , WANG Che , et al . A study of influencing factors on frequencies and mode shapes of aeroengine turbine blades [J ] . Journal of Air Force Engineering University（Natural Science Edition) , 2014 , 15 （ 1 ): 5 - 9 .

李春旺 , 王澈 , 李强 , 等 . 基于热固耦合预应力的发动机叶片模态分析方法 [J ] . 空军工程大学学报（自然科学版) , 2016 , 17 （ 2 ): 1 - 4 .

LI Chunwang , WANG Che , LI Qiang , et al . Modal analysis of aero-engine blade based on thermal-structure coupling pre-stressing force [J ] . Journal of Air Force Engineering University（Natural Science Edition) , 2016 , 17 （ 2 ): 1 - 4 .

姜金朋 , 石竟成 , 苏立超 , 等 . 叶型尺寸比例变化对预测涡轮气动性能和气动力的影响（英文) [J ] . 火箭推进 , 2018 , 44 （ 6 ): 29 - 38 .

JIANG Jinpeng , SHI Jingcheng , SU Lichao , et al . Effects of airfoil scaling on the predicted aerodynamic performance and forcing of turbine [J ] . Journal of Rocket Propulsion , 2018 , 44 （ 6 ): 29 - 38 .

宋丙新 , 侯朝山 . 某型航空发动机HPT转子叶片叶尖间隙对涡轮流场及性能的影响分析 [J ] . 航空维修与工程 , 2024 ( 2 ): 27 - 30 .

SONG Bingxin , HOU Zhaoshan . Analysis on the influence of clearance between HPT rotor blade tip and casing on flow field and performance for a certain aeroengine [J ] . Aviation Maintenance & Engineering , 2024 ( 2 ): 27 - 30 .

关鹏 , 艾延廷 , 王志 , 等 . 热冲击后气膜冷却叶片结构强度流固热耦合仿真 [J ] . 航空动力学报 , 2018 , 33 ( 8 ): 1811 - 1820 .

GUAN Peng , AI Yanting , WANG Zhi , et al . Structural strength simulation of film cooling vane after heat shock by thermal/flow/structure coupling [J ] . Journal of Aerospace Power , 2018 , 33 ( 8 ): 1811 - 1820 .

汪翔宇 , 高尚鸿 , 丰镇平 . 涡轮叶片的热流固耦合数值方法研究及应用 [J ] . 西安交通大学学报 , 2025 , 59 ( 3 ): 21 - 33 .

WANG Xiangyu , GAO Shanghong , FENG Zhenping . Study on numerical method of thermal-fluid-structure coupling for turbine blades and its application [J ] . Journal of Xi’an Jiaotong University , 2025 , 59 ( 3 ): 21 - 33 .

黄朝晖 , 袁奇 , 张弘斌 , 等 . 某型火箭发动机涡轮转子流热固耦合强度及疲劳寿命分析 [J ] . 西安交通大学学报 , 2022 , 56 ( 8 ): 73 - 84 .

HUANG Chaohui , YUAN Qi , ZHANG Hongbin , et al . Analysis of fluid-thermal-solid coupling strength and fatigue life of a certain rocket engine turbine rotor [J ] . Journal of Xi’an Jiaotong University , 2022 , 56 ( 8 ): 73 - 84 .

NAEEM M . Implications of day temperature for a high-pressure-turbine blade’s low-cycle-fatigue life consumption [J ] . Journal of Propulsion and Power , 2008 , 24 ( 3 ): 624 - 628 .

王瀚升 , 李育隆 , 徐诗杰 , 等 . 基于流热固耦合的航空发动机涡轮导叶流动换热研究 [J/OL ] . 航空动力学报. ( 2025-01-10 )[ 2025-03-31 ] . https://doi.org/10.13224/j.cnki.jasp.20240464 .

WANG Hansheng , LI Yulong , XU Shijie , et al . Research on flow and heat transfer of aeroengine turbine guide vanes based on fluid-thermal-solid coupling [J/OL ] . Journal of Aerospace Power .( 2025-01-10 )[ 2025-03-31 ] . https://doi.org/10.13224/j.cnki.jasp.20240464 .

吴厚钰 . 透平零件结构和强度计算 [M ] . 北京 : 机械工业出版社 , 1982 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

长叶片透平级多学科多目标优化设计

语义区分和子图整合驱动的知识图谱表示学习方法

超临界水异常区域热力学特性研究

超临界二氧化碳向心透平轮背间隙内风阻损失及流动特性研究

离子液体改性燃料的电流体动力学效应研究