水平通道制冷剂流型-阻力耦合特性与两相压降预测实验研究

王建伟; 刘艳涛; 周晨捷; 郜哲明; 晏刚; 褚雯霄; 王秋旺

doi:10.7652/xjtuxb202512010

您当前的位置：

首页 >

文章列表页 >

水平通道制冷剂流型-阻力耦合特性与两相压降预测实验研究

—————————————————————— | 更新时间：2025-12-08

- 水平通道制冷剂流型-阻力耦合特性与两相压降预测实验研究
- Experimental Study on Refrigerant Flow Pattern-Flow Resistance Coupling Characteristics and Two-Phase Pressure Drop Prediction for Horizontal Tube
- 西安交通大学学报 2025年59卷第12期页码：117-127
- 作者机构：
- 作者简介：
  
  作者简介：王建伟（2000—），男，博士生；
  王秋旺（通信作者），男，教授，博士生导师。
- 基金信息：
  
  国家自然科学基金资助项目(W2412082;52130609;52206113)
- DOI：10.7652/xjtuxb202512010
  中图分类号： TK124
- 收稿：2025-05-07，
  
  纸质出版：2025-12-10
- 稿件说明：
移动端阅览
王建伟, 刘艳涛, 周晨捷, 等. 水平通道制冷剂流型-阻力耦合特性与两相压降预测实验研究[J]. 西安交通大学学报, 2025,59(12):117-127.

WANG Jianwei, LIU Yantao, ZHOU Chenjie, et al. Experimental Study on Refrigerant Flow Pattern-Flow Resistance Coupling Characteristics and Two-Phase Pressure Drop Prediction for Horizontal Tube[J]. Journal of Xi'an Jiaotong University, 2025, 59(12): 117-127.
王建伟, 刘艳涛, 周晨捷, 等. 水平通道制冷剂流型-阻力耦合特性与两相压降预测实验研究[J]. 西安交通大学学报, 2025,59(12):117-127. DOI： 10.7652/xjtuxb202512010.

WANG Jianwei, LIU Yantao, ZHOU Chenjie, et al. Experimental Study on Refrigerant Flow Pattern-Flow Resistance Coupling Characteristics and Two-Phase Pressure Drop Prediction for Horizontal Tube[J]. Journal of Xi'an Jiaotong University, 2025, 59(12): 117-127. DOI： 10.7652/xjtuxb202512010.

摘要

针对低干度两相制冷剂在水平管内的流型演变与流动机理尚不明确，从而制约着高效空调系统优化设计的问题，提出了一种流型-阻力耦合的压降预测方法。首先，搭建两相可视化实验台，同步测量了质量流速为150～750 kg/（m

·s）、干度为0～0.2时，工质R134a与R32在内径为7mm水平管内的流型与压降特性；其次，基于OpenCV软件库提取空泡份额等图像特征，揭示了弹状流、波浪流和环状流的演化规律；最后，基于流型分区策略，建立了融合流型参数（

）与无量纲数（

、

）的压降预测新模型。研究结果表明：工质R32在低流量、小干度时以弹状流为主，而工质R134a在高流量、大干度时更易形成环状流，其截面含气率较工质R32平均提高了13%；全液相摩擦系数在质量流速为360 kg/（m

·s）时达到峰值，此时最大气液相速度比亦达到最大，且工质R134a的摩擦压力梯度较工质R32提高了25%～50%；新模型将平均绝对偏差从现有模型的30%～70%降至12.31%，且89%的数据点位于±20%误差带内。研究结果可为新型环保制冷剂系统的高效优化设计提供理论支撑。

Abstract

The flow pattern evolution and flow mechanisms of low-dryness R32 and R134a refrigerants are still not fully understood

which

constrains the optimal design of high-efficiency air-conditioning systems.To address this issue

a pressure drop prediction method based on flow pattern-flow resistance coupling is proposed in this study.For the purpose of the study

a visual experimental setup was established；the flow pattern distribution and pressure drop characteristics of R134a and R32 in a horizontal circular tube with 7 mm inner diameter were studied under the flowrate of 150 to 750 kg/（m

·s）and dryness of 0 to 0.2；then image features were extracted based on OpenCV software library to identify the evolution laws of three typical flow patterns：namely

slug flow

wave flow and annular flow；finally

a new pressure drop prediction model integrating flow pattern parameters（

）and dimensionless numbers（

）was established based on a flow pattern zoning strategy.The results show that R32 displayed a slug flow under the conditions of low flowrate and low dryness

while it was more likely for R134a to form an annular flow under the conditions of high flowrate with high dryness

with a 13% higher cross-sectional void fraction than R32 on average；the full liquid-phase friction coefficient reached the peak at a flowrate of 360 kg/（m

·s）

concurring with the maximum gas-liquid-phase velocity ratio；a 25% to 50% higher friction-pressure-drop gradient was observed for R134a than that for R32；with the new model

the mean absolute deviation was reduced from 30% to 70% to 12.31%

compared with existing models

with 89% of the data locating within ±20% error band.These results may provide robust theoretical support for optimized design of efficient new and environmentfriendly air-conditioning systems.

关键词

Keywords

references

中国建筑节能协会 , 重庆大学城乡建设与发展研究院 . 中国城乡建设领域碳排放研究报告（2024年) [J ] . 建筑 , 2025 （ 2 ): 56 - 63 .

China Association of Building Energy Efficiency , Institute of Urban-Rural Construction and Development , Chongqing University . Research report on carbon emission in urban and rural construction in China（2024) [J ] . Construction and Architecture , 2025 （ 2 ): 56 - 63 .

桑纯 , 庞召辉 , 孙建军 . 建筑暖通空调系统节能技术探讨 [J ] . 低碳世界 , 2020 , 10 ( 9 ): 9 - 10 .

SANG Chun , PANG Zhaohui , SUN Jianjun . Discussion on energy saving technology of building HVAC system [J ] . Low Carbon World , 2020 , 10 ( 9 ): 9 - 10 .

MOTA-BABILONI A , MAKHNATCH P , KHODA-BANDEH R . Recent investigations in HFCs substitution with lower GWP synthetic alternatives:focus on energetic performance and environmental impact [J ] . International Journal of Refrigeration , 2017 , 82 : 288 - 301 .

M M , KIM H J , TAYYAB M , et al . Flow maldistribution in plate heat exchangers:impact,analysis,and solutions [J ] . Renewable and Sustainable Energy Reviews , 2025 , 207 : 114905 .

XIONG Tong , LIU Guoqiang , HUANG Shenjie , et al . Two-phase flow distribution in parallel flow mini/micro-channel heat exchangers for refrigeration and heat pump systems:a comprehensive review [J ] . Applied Thermal Engineering , 2022 , 201 ( Part B ): 117820 .

刘璐 , 刘艳涛 , 詹飞龙 , 等 . 提高制冷剂分流均匀性的分配器连接管结构设计 [J ] . 制冷学报 , 2022 , 43 ( 1 ): 151 - 157 .

LIU Lu , LIU Yantao , ZHAN Feilong , et al . Structure optimization of connecting tubes of distributor for improving the distribution uniformity of refrigerant [J ] . Journal of Refrigeration , 2022 , 43 ( 1 ): 151 - 157 .

PARK N H , YEONG HA M . An experimental study on the effect of vertical header geometry on the twophase refrigerant distribution and performance of a microchannel heat exchanger [J ] . Applied Thermal Engineering , 2022 , 209 : 118287 .

LI Houpei , WANG Lizhi , JIANG Haobo , et al . Quantification of flow distribution and heat capacity potential of a microchannel evaporator [J ] . International Journal of Refrigeration , 2023 , 146 : 390 - 402 .

YUAN Chao , LIU Hequn , PENG Jinqing , et al . A method to calculate the two-phase distribution in a microchannel heat exchanger [J ] . International Journal of Refrigeration , 2024 , 168 : 673 - 687 .

CHENG Lixin , XIA Guodong . Flow patterns and flow pattern maps for adiabatic and diabatic gas liquid two phase flow in microchannels:fundamentals,mechanisms and applications [J ] . Experimental Thermal and Fluid Science , 2023 , 148 : 110988 .

QIAN Hongliang , HRNJAK P . Void fraction measurement and flow regimes visualization of R134a in horizontal and vertical ID 7 mm circular tubes [J ] . International Journal of Refrigeration , 2019 , 103 : 191 - 203 .

QIAN Hongliang , HRNJAK P . Characterization of R134a two-phase flow regimes in horizontal and vertical smooth tubes with capacitive sensors [J ] . International Journal of Refrigeration , 2021 , 125 : 90 - 103 .

张浩 , 刘璐 , 詹飞龙 , 等 . 空调器水平管路内R32流动过程的流型变化规律 [J ] . 制冷技术 , 2022 , 42 ( 2 ): 1 - 6 .

ZHANG Hao , LIU Lu , ZHAN Feilong , et al . Flow pattern change principle of R32 in horizontal tube of air conditioner [J ] . Chinese Journal of Refrigeration Technology , 2022 , 42 ( 2 ): 1 - 6 .

JIN Cheng , TAO Leren , GU Shengjie , et al . Experimental study on the flow pattern and local heat transfer characteristics of water flow boiling in a vertical upward narrow rectangular channel heated by steam [J ] . Applied Thermal Engineering , 2024 , 247 : 123091 .

RUZAIKIN V , LUKASHOV I , BREUS A , et al . Ammonia adiabatic two-phase flow patterns in the horizontal tube [J ] . International Journal of Heat and Mass Transfer , 2024 , 234 : 126133 .

YANG Peng , ZHANG Yuheng , WANG Xiaofei , et al . Heat transfer measurement and flow regime visualization of two-phase pulsating flow in an evaporator [J ] . International Journal of Heat and Mass Transfer , 2018 , 127 ( Part C ): 1014 - 1024 .

SOLANKI D K , NANDI K , MOHAN J , et al . Subcooled flow boiling in a horizontal circular pipe under high heat flux and high mass flux conditions [J ] . Annals of Nuclear Energy , 2025 , 212 : 111030 .

XU Yu , YAN Zihao , LI Ling . Flow boiling heat transfer,pressure drop and flow patterns of the environmentally friendly refrigerant R1234yf for cooling avionics [J ] . Applied Thermal Engineering , 2022 , 209 : 118301 .

YANG Zhiqiang , GONG Maoqiong , CHEN Gaofei , et al . Two-phase flow patterns,heat transfer and pressure drop characteristics of R600a during flow boiling inside a horizontal tube [J ] . Applied Thermal Engineering , 2017 , 120 : 654 - 671 .

李俊峰 , 玉鼎 , 张文锋 , 等 . Φ 5mm换热器在R32系统中压降特性研究 [J ] . 制冷与空调 , 2023 , 23 ( 5 ): 66 - 71 .

LI Junfeng , YU Ding , ZHANG Wenfeng , et al . Research on pressure drop characteristics of Φ 5 mm heat exchanger in R32 system [J ] . Refrigeration and Air-Conditioning , 2023 , 23 ( 5 ): 66 - 71 .

SUN Licheng , MISHIMA K . Evaluation analysis of prediction methods for two-phase flow pressure drop in mini-channels [C ] // 16th International Conference on Nuclear Engineering . New York, USA : ASME , 2008 : 649 - 658 .

ZHU Yu , WU Xiaomin , ZHAO Ran . R32 flow boiling in horizontal mini channels:part Ⅱ flow-pattern based prediction methods for heat transfer and pressure drop [J ] . International Journal of Heat and Mass Transfer , 2017 , 115 ( Part A ): 1233 - 1244 .

张浩 , 曹泽瀚 , 梅淏汉 , 等 . R32制冷剂在小管径水平管内的沸腾换热与阻力特性实验研究 [J ] . 西安交通大学学报 , 2023 , 57 ( 3 ): 58 - 67 .

ZHANG Hao , CAO Zehan , MEI Haohan , et al . Experimental study on the flow boiling heat transfer and pressure drop of refrigerant R32 in horizontally oriented small-diameter tubes [J ] . Journal of Xi’an Jiaotong University , 2023 , 57 ( 3 ): 58 - 67 .

CHU Wenxiao , BENNETT K , CHENG Jie , et al . Numerical study on a novel hyperbolic inlet header in straight-channel printed circuit heat exchanger [J ] . Applied Thermal Engineering , 2019 , 146 : 805 - 814 .

STEINER D , TABOREK J . Flow boiling heat transfer in vertical tubes correlated by an asymptotic model [J ] . Heat Transfer Engineering , 1992 , 13 ( 2 ): 43 - 69 .

谷波 , 杜仲星 , 曾炜杰 , 等 . R32管内流动沸腾传热系数关联式和摩擦压降关联式 [J ] . 上海交通大学学报 , 2023 , 57 ( 1 ): 45 - 54 .

GU Bo , DU Zhongxing , ZENG Weijie , et al . Flow boiling heat transfer coefficient and frictional pressure drop correlations forR32 [J ] . Journal of Shanghai Jiao Tong University , 2023 , 57 ( 1 ): 45 - 54 .

MÜLLER-STEINHAGEN H , HECK K . Asimple friction pressure drop correlation for two-phase flow in pipes [J ] . Chemical Engineering and Processing: Process Intensification , 1986 , 20 ( 6 ): 297 - 308 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

水平通道制冷剂流型-阻力耦合特性与两相压降预测实验研究

超临界CO2水平管内浮升力和热加速效应评判准则

不同板叠材料热声热机能量转换过程数值模拟研究

混合电解槽阵列协同的风光耦合制氢系统双层多目标优化

融合物理信息与深度算子网络的变压器绕组热-流场快速计算方法