氢气/氮气添加对乙烯扩散火焰碳烟生成影响的模拟研究

闫治宇; 史聪灵; 熊新怡; 雷博涵; 李倩倩; 王金华; 黄佐华

doi:10.7652/xjtuxb202510013

您当前的位置：

首页 >

文章列表页 >

氢气/氮气添加对乙烯扩散火焰碳烟生成影响的模拟研究

更新时间：2025-09-28

- 氢气/氮气添加对乙烯扩散火焰碳烟生成影响的模拟研究
- Simulation Study on the Effect of Hydrogen/Nitrogen Addition on Soot Formation in Ethylene Diffusion Flames
- 西安交通大学学报 2025年59卷第10期页码：137-147
- 作者机构：
- 作者简介：
  
  作者简介：闫治宇（1994—），男，博士生；
  李倩倩（通信作者），女，副教授，博士生导师。
- 基金信息：
  
  国家自然科学基金联合基金重点资助项目(U2341282);航空发动机与燃气轮机基础科学中心重点资助项目。(P2022-B-Ⅱ-014-001)
- DOI：10.7652/xjtuxb202510013
  中图分类号： TK40
- 收稿：2025-02-05，
  
  纸质出版：2025-10-10
- 稿件说明：
移动端阅览
闫治宇, 史聪灵, 熊新怡, 等. 氢气/氮气添加对乙烯扩散火焰碳烟生成影响的模拟研究[J]. 西安交通大学学报, 2025,59(10):137-147.

YAN Zhiyu, SHI Congling, XIONG Xinyi, et al. Simulation Study on the Effect of Hydrogen/Nitrogen Addition on Soot Formation in Ethylene Diffusion Flames[J]. Journal of Xi'an Jiaotong University, 2025, 59(10): 137-147.
闫治宇, 史聪灵, 熊新怡, 等. 氢气/氮气添加对乙烯扩散火焰碳烟生成影响的模拟研究[J]. 西安交通大学学报, 2025,59(10):137-147. DOI： 10.7652/xjtuxb202510013.

YAN Zhiyu, SHI Congling, XIONG Xinyi, et al. Simulation Study on the Effect of Hydrogen/Nitrogen Addition on Soot Formation in Ethylene Diffusion Flames[J]. Journal of Xi'an Jiaotong University, 2025, 59(10): 137-147. DOI： 10.7652/xjtuxb202510013.

摘要

针对氢气添加对碳烟生成是化学促进还是抑制的问题，采用二维数值模拟对纯乙烯、添加氮气和添加氢气的同轴协流扩散火焰开展了系统研究。分析了添加30%体积分数的氢气、氮气后，其对火焰温度、碳烟体积分数、颗粒生长、成核、前驱物演变和氧化等过程的影响，获取了相关特征参数的变化规律，阐明了低比例氢气添加对碳烟生成的化学促进作用机制。模拟结果表明：相较于添加体积分数为30%的氧气火焰，添加体积分数为30%的氢气火焰能够在一定程度上促进碳烟形成，碳烟峰值体积分数从4.37×10

-6

增加至4.52×10

-6

，但掺氢引起的温度场变化对碳烟生成的影响作用较小；掺氢带来的化学促进作用主要通过加速多环芳香烃（PAHs）的生成和颗粒成核速率实现，进而在PAHs沉积作用而非脱氢加乙炔反应主导下促使颗粒质量增加；掺氢能够通过同时增加OH和O

的氧化速率促进颗粒氧化，但其带来的化学促进颗粒生长作用要大于氧化促进作用。该研究可为掺氢燃烧的碳烟颗粒控制提供理论依据。

Abstract

To address the question of whether hydrogen addition chemically promotes or inhibits soot formation

a two-dimensional numerical simulation is conducted to systematically investigate pure ethylene

nitrogen-added

and hydrogen-doped co-flow diffusion flames. The effects of adding 30% hydrogen/nitrogen by volume on flame temperature

soot volume fraction

particle grow

nucleation

precursor evolution

and oxidation processes are analyzed. The variations in key characteristic parameters are obtained

and the mechanism of the chemical promotion effect of low-proportion hydrogen addition on soot formation is elucidated. The simulation results show that compared to nitrogen-diluted flames

the addition of 30% hydrogen slightly promotes soot formation

with the peak soot volume fraction increasing from 4.37×10

-6

to 4.52×10

-6

while the influence of hydrogen-induced temperature field changes on soot formation is minor. The chemical promotion effect of hydrogen addition is primarily achieved by accelerating the formation of polycyclic aromatic hydrocarbons (PAHs) and particle nucleation rates

thereby enhancing particle mass growth through PAHs deposition rather than dehydrogenation-acetylene reactions. Although hydrogen addition promotes particle oxidation by simultaneously increasing OH and O

oxidation rates

its chemical promotion of particle growth outweighs the oxidation enhancement. This study provides theoretical insights for controlling soot particles in hydrogen-doped combustion.

关键词

Keywords

references

玄铁民 , 史智钊 , 商伟伟 , 等 . 正十二烷喷雾火焰中碳烟的瞬态生成特性 [J ] . 西安交通大学学报 , 2024 , 58 ( 3 ): 15 - 24 .

XUAN Tiemin , SHI Zhizhao , SHANG Weiwei , et al . A study on transient in-flame soot evolution of n-dodecane spray [J ] . Journal of Xi'an Jiaotong University , 2024 , 58 ( 3 ): 15 - 24 .

KHARE R , VLAVAKIS P , LANGENTHAL T V , et al . Experimental investigation of the effect of hydrogen addition on the sooting limit and structure of methane/air laminar counterflow diffusion flames [J ] . Fuel , 2022 , 324 ( Part B ): 124506 .

WANG Yang , GU Mingyan , ZHU Yuhan , et al . A review of the effects of hydrogen,carbon dioxide,and water vapor addition on soot formation in hydrocarbon flames [J ] . International Journal of Hydrogen Energy , 2021 , 46 ( 61 ): 31400 - 31427 .

GÜLDER Ö L , SNELLING D R , SAWCHUK R A . Influence of hydrogen addition to fuel on temperature field and soot formation in diffusion flames [J ] . Symposium (International)on Combustion , 1996 , 26 ( 2 ): 2351 - 2358 .

GUO Hongsheng , LIU Fengshan , SMALLWOOD G J , et al . Numerical study on the influence of hydrogen addition on soot formation in a laminar ethylene-air diffusion flame [J ] . Combustion and Flame , 2006 , 145 ( 1/2 ): 324 - 338 .

ZHAO Huayong , STONE R , WILLIAMS B . Investigation of the soot formation in ethylene laminar diffusion flames when diluted with helium or supplemented by hydrogen [J ] . Energy & Fuels , 2014 , 28 ( 3 ): 2144 - 2151 .

WANG Yang , GU Mingyan , GAO Yongpan , et al . An experimental and numerical study of soot formation of laminar coflow H 2 /C 2 H 4 diffusion flames in O 2 CO 2 atmosphere [J ] . Combustion and Flame , 2020 , 221 : 50 - 63 .

LIN Yuyu , ZHU Bencheng , CHEN Jinchao , et al . Study of soot functional groups and morphological characteristics in laminar coflow methane and ethylene diffusion flames with hydrogen addition [J ] . Fuel , 2020 , 279 : 118474 .

SUN Zhiwei , DALLY B , NATHAN G , et al . Effects of hydrogen and nitrogen on soot volume fraction,primary particle diameter and temperature in laminar ethylene/air diffusion flames [J ] . Combustion and Flame , 2017 , 175 : 270 - 282 .

KHANEHZAR A , CEPEDA F , DWORKIN S B . The influence of nitrogen and hydrogen addition/dilution on soot formation in coflow ethylene/air diffusion flames [J ] . Fuel , 2022 , 309 : 122244 .

SLAVINSKAYA N A , FRANK P . Amodelling study of aromatic soot precursors formation in laminar methane and ethene flames [J ] . Combustion and Flame , 2009 , 156 ( 9 ): 1705 - 1722 .

YANG S S , KARATAŞ A E , GÜLDER Ö L . Effect of hydrogen enrichment of laminar ethylene diffusion flames on thermal structure and soot yields at pressures up to 10 bar [J ] . Proceedings of the Combustion Institute , 2021 , 38 ( 2 ): 2507 - 2516 .

LIU Fengshan , MIGLIORINI F , CIGNOLI F , et al . Effects of hydrogen and helium addition to fuel on soot formation in axisymmetric coflow laminar methane-air diffusion flame [C ] // ASME/JSME 2007 Thermal Engineering Heat Transfer Summer Conference collocated with theASME 2007 InterPACK Conference . New York,USA : ASME , 2007 : 633 - 642 .

PANDEY P , PUNDIR B P , PANIGRAHI P K . Hydrogen addition to acetylene-air laminar diffusion flames:studies on soot formation under different flow arrangements [J ] . Combustion and Flame , 2007 , 148 ( 4 ): 249 - 262 .

SUN Mingshan , GAN Zhiwen . A numerical study on the influence of hydrogen addition on soot formation in a laminar aviation kerosene (jet A1)flame at elevated pressure [C ] // ASME Turbo Expo 2021:Turbomach inery Technical Conference and Exposition . New York,USA : ASME , 2021 : V03 AT04A045 .

YAN Zhiyu , YANG Yilan , LI Qianqian , et al . Study on effects of NH 3 and/or H 2 addition on the characteristics of soot formation and gas emissions in a laminar ethylene diffusion flame [J ] . Fuel Processing Technology , 2023 , 242 : 107633 .

EAVES N A , ZHANG Qingan , LIU Fengshan , et al . CoFlame:a refined and validated numerical algorithm for modeling sooting laminar coflow diffusion flames [J ] . Computer Physics Communications , 2016 , 207 : 464 - 477 .

CHERNOV V , THOMSON M J , DWORKIN S B , et al . Soot formation with C 1 and C 2 fuels using an improved chemical mechanism for PAH growth [J ] . Combustion and Flame , 2014 , 161 ( 2 ): 592 - 601 .

KHOLGHY M R , VESHKINI A , THOMSON M J . The core-shell internal nanostructure of soot:a criterion to model soot maturity [J ] . Carbon , 2016 , 100 : 508 - 536 .

CHU C , ZHANG Tongfeng , THOMSON M J . The chemical structure effects of alkylbenzenes on soot formation in a laminar co-flow flame [J ] . Combustion and Flame , 2019 , 204 : 237 - 249 .

EAVES N A , VESHKINI A , RIESE C , et al . A numerical study of high pressure,laminar,sooting,ethane-air coflow diffusion flames [J ] . Combustion and Flame , 2012 , 159 ( 10 ): 3179 - 3190 .

JEREZ A , CONSALVI J L , FUENTES A , et al . Soot production modeling in a laminar coflow ethylene diffusion flame at different oxygen indices using a PAH-based sectional model [J ] . Fuel , 2018 , 231 : 404 - 416 .

LIU Haifeng , CUI Yanqing , CHEN Beiling , et al . Effects of flame temperature on PAHs and soot evolution in partially premixed and diffusion flames of a diesel surrogate [J ] . Energy & Fuels , 2019 , 33 ( 11 ): 11821 - 11829 .

WANG Yang , LIU Xiaofang , GAO Yongpan , et al . Numerical simulations on effects of oxygen concentration on the structure and soot formation in a twodimensional axisymmetric laminarC 2 H 4 /(O 2 -CO 2 ) diffusion flame [J ] . Journal of Thermal Analysis and Calorimetry , 2019 , 137 ( 2 ): 689 - 702 .

WANG Yu , LIU Haifeng , FENG Lei , et al . Effects of oxygen enrichment on diesel spray flame soot formation in O 2 /Ar atmosphere [J ] . Combustion and Flame , 2024 , 260 : 113244 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

乙酸乙烯与乙烯混合物亥姆霍兹自由能状态方程及应用

生物质高温热解气、液、固三相产物及碳烟生成特性

热解温度与碱金属对生物质热解碳烟氧化活性的影响

张角凹坑气膜孔对双层壁气膜冷却特性的影响

隧道内燃料电池汽车氢气泄漏扩散特性及影响因素