变参数篦齿-蜂窝密封泄漏特性的研究

王梓齐; 李文豪; 徐磊; 何坤; 晏鑫

doi:10.7652/xjtuxb202509020

您当前的位置：

首页 >

文章列表页 >

变参数篦齿-蜂窝密封泄漏特性的研究

—————————————————————— | 更新时间：2025-09-11

- 变参数篦齿-蜂窝密封泄漏特性的研究
- Study on Leakage Characteristics of Labyrinth-Honeycomb Seals under Variable Parameters
- 西安交通大学学报 2025年59卷第9期页码：209-219
- 作者机构：
  
  1.西安交通大学热流科学与工程教育部重点实验室， 710049，西安
  2.西安交通大学叶轮机械研究所， 710049，西安
- 作者简介：
  
  王梓齐（1998—），男，博士生
  何坤，女，副教授，博士生导师。
- 基金信息：
  
  国家科技重大专项资助项目(J2019-Ⅲ-0007-0050)
- DOI：10.7652/xjtuxb202509020
  中图分类号： TK263.2
- 收稿：2025-03-17，
  
  网络首发：2025-05-20，
  
  纸质出版：2025-09-10
- 稿件说明：
移动端阅览
王梓齐, 李文豪, 徐磊, 等. 变参数篦齿-蜂窝密封泄漏特性的研究[J]. 西安交通大学学报, 2025,59(9):209-219.

WANG Ziqi, LI Wenhao, XU Lei, et al. Study on Leakage Characteristics of Labyrinth-Honeycomb Seals under Variable Parameters[J]. Journal of Xi’an Jiaotong University, 2025, 59(9): 209-219.
王梓齐, 李文豪, 徐磊, 等. 变参数篦齿-蜂窝密封泄漏特性的研究[J]. 西安交通大学学报, 2025,59(9):209-219. DOI： 10.7652/xjtuxb202509020.

WANG Ziqi, LI Wenhao, XU Lei, et al. Study on Leakage Characteristics of Labyrinth-Honeycomb Seals under Variable Parameters[J]. Journal of Xi’an Jiaotong University, 2025, 59(9): 209-219. DOI： 10.7652/xjtuxb202509020.

摘要

为全面分析变参数下篦齿-蜂窝密封的泄漏特性，搭建了燃气轮机篦齿-蜂窝密封泄漏流动特性实验台，并开展了对应的数值分析，研究了6种压比、4种间隙、6种蜂窝深度、4种蜂窝直径、4种齿高、3种篦齿倾角、2种齿宽、2种篦齿节距下的篦齿-蜂窝密封封严性能。结果表明：篦齿-蜂窝密封流量系数、泄漏量分别随压比、间隙的增加线性增大，其中密封压比每增加10%，流量系数增加3.47%，封严间隙每增大1倍，泄漏量增加57.94%；篦齿-蜂窝密封泄漏量随蜂窝深度增加先减小后增大，在蜂窝深度为3.5 mm时封严效果最优，泄漏量较最小蜂窝深度减少9.81%；随着蜂窝直径增大，泄漏量先减小后增大，并在蜂窝直径为1.6 mm时实现最佳封严效果，其泄漏量相较于最大蜂窝直径时降低8.11%；随着齿高、倾角增加，泄漏量单调降低；篦齿节距对封严效果影响较大，而齿宽影响最小。

Abstract

To comprehensively analyze the leakage characteristics of labyrinth-honeycomb seals under variable parameters

an experimental platform for investigating the leakage flow characteristics of gas turbine labyrinth-honeycomb seals and conducts corresponding numerical simulations is established. The sealing performance is investigated under six pressure ratios

four clearance gaps

six honeycomb depths

four honeycomb diameters

four tooth heights

three labyrinth tooth inclination angles

two tooth widths

and two tooth pitches. The results indicate that the flow coefficient and leakage rate of labyrinth-honeycomb seals increase linearly with the pressure ratio and clearance gap. Specifically

for every 10% increase in the sealing pressure ratio

the flow coefficient increases by 3.47%

while doubling the clearance gap leads to a 57.94% increase in leakage. The leakage rate initially decreases and then increases with increasing honeycomb depth

achieving the optimal sealing effect at a honeycomb depth of 3.5 mm

where leakage is reduced by 9.81% compared to the minimum depth. Similarly

leakage first decreases and then increases with increasing honeycomb diameter

reaching the best sealing performance at a diameter of 1.6 mm

with an 8.11% reduction in leakage compared to the maximum diameter. Leakage decreases monotonically with increasing tooth height and inclination angle. The tooth pitch has a significant impact on sealing performance

while tooth width has the least influence.

关键词

Keywords

references

王新军 , 李亮 , 宋立明 , 等 . 汽轮机原理 [M ] . 西安 : 西安交通大学出版社 , 2014 .

CHUPP R E , GHASRIPOOR F , TURNQUIST N A , et al . Advanced seals for industrial turbine applications: dynamic seal development [J ] . Journal of Propulsion and Power , 2002 , 18 ( 6 ): 1260 - 1266 .

ZHANG Bo , DOU Yuanyuan , HONG Quan , et al . Experimental investigation of effect of tooth geometrical parameters to flow characteristics in slant labyrinth seals [J ] . Concurrency and Computation: Practice and Experience , 2018 , 30 ( 24 ): e4951 .

杨淋麟 , 张丽 , 朱惠人 . 篦齿结构对封严性能的影响 [J ] . 科学技术与工程 , 2013 , 13 ( 33 ): 10069 - 10073 .

YANG Linlin , ZHANG Li , ZHU Huiren . The effects of seal labyrinth characteristics on the sealing performance of straight labyrinth [J ] . Science Technology and Engineering , 2013 , 13 ( 33 ): 10069 - 10073 .

王锁芳 , 吕海峰 , 夏登勇 . 封严篦齿结构特性的数值分析和实验研究 [J ] . 南京航空航天大学学报 , 2004 , 36 ( 6 ): 732 - 735 .

WANG Suofang , LÜ Haifeng , XIA Dengyong . Numerical analyses and experimental investigations of seal labyrinth characteristics [J ] . Journal of Nanjing University of Aeronautics & Astronautics , 2004 , 36 ( 6 ): 732 - 735 .

周国宇 , 王旭东 , 林智荣 , 等 . 高低齿迷宫密封泄漏量实验及计算分析 [J ] . 工程热物理学报 , 2015 , 36 ( 9 ): 1889 - 1893 .

ZHOU Guoyu , WANG Xudong , LIN Zhirong , et al . Preliminary analysis to the leakage of the staggered labyrinth seal based on experiment and simulation [J ] . Journal of Engineering Thermophysics , 2015 , 36 ( 9 ): 1889 - 1893 .

王旭 , 张文平 , 马胜远 , 等 . 转子蜂窝密封封严特性的试验研究 [J ] . 热能动力工程 , 2004 , 19 ( 5 ): 521 - 525 .

WANG Xu , ZHANG Wenping , MA Shengyuan , et al . Experimental investigation of the sealing characteristics of a rotor honeycomb seal [J ] . Journal of Engineering for Thermal Energy and Power , 2004 , 19 ( 5 ): 521 - 525 .

ZHAO Huan , ZHANG Ran , SUN Dan , et al . Influence factors of honeycomb seal performance and stability analysis of rotor system [J ] . Journal of Aerospace Engineering , 2022 , 35 ( 4 ): 04022042 .

CHILDS D , ELROD D , HALE K . Annular honeycomb seals: test results for leakage and rotordynamic coefficients; comparisons to labyrinth and smooth configurations [J ] . Journal of Tribology , 1989 , 111 ( 2 ): 293 - 300 .

LI Zhigang , LI Jun , FENG Zhenping . Labyrinth seal rotordynamic characteristics: part Ⅱ geometrical parameter effects [J ] . Journal of Propulsion and Power , 2016 , 32 ( 5 ): 1281 - 1291 .

张尧 , 张万福 , 李春 , 等 . 变工况下高低齿迷宫密封泄漏特性及结构优化 [J ] . 热能动力工程 , 2018 , 33 ( 5 ): 33 - 39 .

ZHANG Yao , ZHANG Wanfu , LI Chun , et al . Leakage characteristics and structure optimization of staggered labyrinth seal at off-design condition [J ] . Journal of Engineering for Thermal Energy and Power , 2018 , 33 ( 5 ): 33 - 39 .

DOGU Y , SERTÇAKAN M C , BAHAR A S , et al . Computational fluid dynamics investigation of labyrinth seal leakage performance depending on mushroom-shaped tooth wear [J ] . Journal of Engineering for Gas Turbines and Power , 2016 , 138 ( 3 ): 032503 .

DOGU Y , SERTÇAKAN M C , GEZER K , et al . Leakage degradation of straight labyrinth seal due to wear of round tooth tip and acute trapezoidal rub-groove [J ] . Journal of Engineering for Gas Turbines and Power , 2017 , 139 ( 7 ): 072506 .

陈尧兴 , 李志刚 , 晏鑫 , 等 . 迷宫齿弯曲磨损时密封泄漏特性和转子动力特性系数研究 [J ] . 西安交通大学学报 , 2018 , 52 ( 6 ): 157 - 164 .

CHEN Yaoxing , LI Zhigang , YAN Xin , et al . Investigations on the leakage characteristics and rotordynamic coefficients of labyrinth seal with tooth bending damage [J ] . Journal of Xi'an Jiaotong University , 2018 , 52 ( 6 ): 157 - 164 .

YAN Xin , DAI Xinbo . Effects of labyrinth fin wear on aerodynamic performance of turbine stages: part I bending damages [C ] // ASME Turbo Expo 2019: Turbomachinery Technical Conference and Exposition . New York, USA : ASME , 2019 : V008T29A004 .

陈秀秀 , 晏鑫 , 李军 . 蜂窝叶顶密封对透平级气动性能的影响研究 [J ] . 西安交通大学学报 , 2016 , 50 ( 4 ): 14 - 20 .

CHEN Xiuxiu , YAN Xin , LI Jun . Effect of honeycomb shroud seals on aerodynamic performance of turbine stages [J ] . Journal of Xi'an Jiaotong University , 2016 , 50 ( 4 ): 14 - 20 .

LI Jun , KONG Shengru , YAN Xin , et al . Numerical investigations on leakage performance of the rotating labyrinth honeycomb seal [J ] . Journal of Engineering for Gas Turbines and Power , 2010 , 132 ( 6 ): 062501 .

YAN Xin , LI Jun , FENG Zhenping . Effects of inlet preswirl and cell diameter and depth on honeycomb seal characteristics [J ] . Journal of Engineering for Gas Turbines and Power , 2010 , 132 ( 12 ): 122506 .

ALIZADEH M , NIKKHAHI B , FARAHANI A S , et al . Numerical study on the effect of geometrical parameters on the labyrinth-honeycomb seal performance [J ] . Proceedings of the Institution of Mechanical Engineers: Part G Journal of Aerospace Engineering , 2018 , 232 ( 2 ): 362 - 373 .

ZENGIN I , ERDOGAN B . Numerical analysis of geometry and operating conditions in combined honeycomb and inclined labyrinth sealing elements [J ] . Progress in Computational Fluid Dynamics, an International Journal , 2023 , 23 ( 1 ): 1 - 12 .

杜发青 , 吉洪湖 , 帅海山 , 等 . 齿形几何参数对直通篦齿封严泄漏特性影响的正交实验 [J ] . 航空动力学报 , 2013 , 28 ( 4 ): 825 - 831 .

DU Faqing , JI Honghu , SHUAI Haishan , et al . Orthogonal experiment of effect of fin geometrical parameters on leakage of straight-through labyrinth seals [J ] . Journal of Aerospace Power , 2013 , 28 ( 4 ): 825 - 831 .

阎洪涛 , 杨健 , 赵铎 , 等 . 燃气机曲折型迷宫密封的泄漏特性 [J ] . 润滑与密封 , 2016 , 41 ( 7 ): 112 - 114 .

YAN Hongtao , YANG Jian , ZHAO Duo , et al . Leakage and flow characteristics of stagger labyrinth seals on gas turbine [J ] . Lubrication Engineering , 2016 , 41 ( 7 ): 112 - 114 .

孙丹 , 王猛飞 , 艾延廷 , 等 . 蜂窝密封泄漏特性理论与实验 [J ] . 航空学报 , 2017 , 38 ( 4 ): 277 - 286 .

SUN Dan , WANG Mengfei , AI Yanting , et al . Theoretical and experimental study of leakage characteristics of honeycomb seal [J ] . Acta Aeronautica et Astronautica Sinica , 2017 , 38 ( 4 ): 277 - 286 .

WITTIG S , JACOBSEN K , SCHELLING U , et al . Heat transfer in stepped labyrinth seals [J ] . Journal of Engineering for Gas Turbines and Power , 1988 , 110 ( 1 ): 63 - 69 .

代欣波 . 迷宫密封磨损机理及封严性能退化机制的研究 [D ] . 西安 : 西安交通大学 , 2022 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

整体式斯特林制冷机用于家用冰箱的性能研究

一种利用气泡泵效应重力辅助回路热管的实验研究

蜂窝叶顶密封对透平级气动性能的影响研究

钛合金螺旋扁管换热器流阻与传热性能实验研究

丙烷与POE润滑油气液相平衡的实验研究