非平衡闪蒸启始阶段气液换热过程的理论与实验研究

冯添黄瑞; 张寅; 李晓然; 吴伟烽

doi:10.7652/xjtuxb202508011

您当前的位置：

首页 >

文章列表页 >

非平衡闪蒸启始阶段气液换热过程的理论与实验研究

—————————————————————— | 更新时间：2025-07-30

- 非平衡闪蒸启始阶段气液换热过程的理论与实验研究
- Theoretical and Experimental Investigation of Gas-Liquid Heat Transfer During the Initial Stage of Non-Equilibrium Flash Evaporation
- 西安交通大学学报 2025年59卷第8期页码：112-121
- 作者机构：
  
  西安交通大学能源与动力工程学院， 710049，西安
- 作者简介：
  
  冯添黄瑞（2001—），男，硕士生
  吴伟烽，男，教授，博士生导师。
- 基金信息：
  
  国家自然科学基金资助项目(5207060477)
- DOI：10.7652/xjtuxb202508011
  中图分类号： TK219
- 收稿：2025-02-28，
  
  网络首发：2025-03-31，
  
  纸质出版：2025-08-10
- 稿件说明：
移动端阅览
冯添黄瑞, 张寅, 李晓然, 等. 非平衡闪蒸启始阶段气液换热过程的理论与实验研究[J]. 西安交通大学学报, 2025,59(8):112-121.

FENG Tianhuangrui, ZHANG Yin, LI Xiaoran, et al. Theoretical and Experimental Investigation of Gas-Liquid Heat Transfer During the Initial Stage of Non-Equilibrium Flash Evaporation[J]. Journal of Xi’an Jiaotong University, 2025, 59(8): 112-121.
冯添黄瑞, 张寅, 李晓然, 等. 非平衡闪蒸启始阶段气液换热过程的理论与实验研究[J]. 西安交通大学学报, 2025,59(8):112-121. DOI： 10.7652/xjtuxb202508011.

FENG Tianhuangrui, ZHANG Yin, LI Xiaoran, et al. Theoretical and Experimental Investigation of Gas-Liquid Heat Transfer During the Initial Stage of Non-Equilibrium Flash Evaporation[J]. Journal of Xi’an Jiaotong University, 2025, 59(8): 112-121. DOI： 10.7652/xjtuxb202508011.

摘要

为解决三角闪蒸循环系统中膨胀腔内工质热力参数难以测定的问题，研究了闪蒸启始阶段气液相间换热的过程。搭建等效膨胀实验台，模拟水工质两相膨胀机腔内的闪蒸过程，采用高速摄影技术观测闪蒸腔内的气液相变。基于无量纲参数归一化方法建立气液界面传热模型，并与相同工况下实验台的实测数据进行对比。研究结果表明：在闪蒸腔内蒸发与排气建立动态平衡的过程中，启始阶段腔内压力呈V型变化，分为压力骤降、压力回升、准稳态3个阶段；采用所构建模型得到的预测值与实验值的吻合度大于94%；液体初始温度上升导致过热度增大，闪蒸强度提高，液体初始温度每升高10 ℃，过热度极值增大约15%，闪蒸速率增加约20%～30%；随着阀门开度从25%增大至70%，闪蒸气体通流面积增加，平均压降速率从54.73 kPa/s增加至122.47 kPa/s，导致液体内部温度梯度增大、局部过热度上升，闪蒸速率也由0.38 kg/s非线性提升至0.56 kg/s。该研究可为三角闪蒸循环系统两相膨胀机的设计与运行优化提供参考。

Abstract

To address the challenge in determining thermodynamic parameters of working mediums within the expansion chamber of triangular flash cycle systems

the heat transfer process between vapor and liquid phases during initial flash evaporation is investigated. An equivalent expansion test rig is established to simulate the flash evaporation process in a two-phase expander chamber using water as the working medium

with high-speed photography employed to observe vapor-liquid phase transitions. A heat transfer model at the vapor-liquid interface is developed based on dimensionless parameter normalization and validated against experimental data under identical operating conditions. The results demonstrate that during the establishment of dynamic equilibrium between evaporation and exhaust in the flash chamber

the initial chamber pressure exhibits a V-shaped variation pattern

comprising three distinct stages: rapid pressure drop

pressure recovery

and quasi-steady state; the proposed model achieves over 94% agreement with experimental measurements; increasing the initial liquid temperature enhances superheat degree and flash intensity: each 10 ℃ temperature rise leads to approximately 15% increase in maximum superheat and 20% to 30% improvement in flash rate; as the valve opening increases from 25% to 70%

the flow area for flash vapor expands

causing the average pressure drop rate to rise from 54.73 kPa/s to 122.47 kPa/s. This results in increased temperature gradients within the liquid

elevated local superheat

and a nonlinear enhancement of flash rate from 0.38 kg/s to 0.56 kg/s. This research provides valuable references for the design and operational optimization of two-phase expanders in triangular flash cycle systems.

关键词

Keywords

references

KANNO H , SHIKAZONO N . Experimental and modeling study on adiabatic two-phase expansion in a cylinder [J ] . International Journal of Heat and Mass Transfer , 2015 , 86 : 755 - 763 .

KANNO H , SHIKAZONO N . Experimental study on two-phase adiabatic expansion in a reciprocating expander with intake and exhaust processes [J ] . International Journal of Heat and Mass Transfer , 2016 , 102 : 1004 - 1011 .

BIANCHI G , KENNEDY S , ZAHER O , et al . Numerical modeling of a two-phase twin-screw expander for trilateral flash cycle applications [J ] . International Journal of Refrigeration , 2018 , 88 : 248 - 259 .

SMITH I K . Development of the trilateral flash cycle system: part 1 fundamental considerations [J ] . Proceedings of the Institution of Mechanical Engineers: Part A Journal of Power and Energy , 1993 , 207 ( 3 ): 179 - 194 .

SMITH I K , PITANGA MARQUES DA SILVA R . Development of the trilateral flash cycle system: part 2 increasing power output with working fluid mixtures [J ] . Proceedings of the Institution of Mechanical Engineers: Part A Journal of Power and Energy , 1994 , 208 ( 2 ): 135 - 144 .

SMITH I K , STOŠIC N , ALDIS C A . Development of the trilateral flash cycle system: part 3 the design of high-efficiency two-phase screw expanders [J ] . Proceedings of the Institution of Mechanical Engineers: Part A Journal of Power and Energy , 1996 , 210 ( 1 ): 75 - 93 .

LI Xiaoran , WU Weifeng , ZHANG Yin , et al . Characteristics study of non-equilibrium flash for two-phase expansion based on equivalent expansion experiments [J ] . Applied Energy , 2024 , 358 : 122551 .

WU Weifeng , WANG Qi , ZHANG Zhao , et al . Influence of evaporating rate on two-phase expansion in the piston expander with cyclone separator [J ] . Thermal Science , 2020 , 24 ( Part B ): 2077 - 2088 .

NIU Lu , HOU Yu , SUN Wan , et al . The measurement of thermodynamic performance in cryogenic two-phase turbo-expander [J ] . Cryogenics , 2015 , 70 : 76 - 84 .

VASUTHEVAN H , BRÜMMER A . Theoretical investigation of flash vaporisation in a screw expander [C ] // IOP Conference Series: Materials Science and Engineering . Bristol, United Kingdom : IOP Publishing , 2017 : 012077 .

MIYATAKE O , MURAKAMI K , KAWATA Y , et al . Fundamental experiments with flash evaporation [J ] . Heat Transfer-Japanese Research , 1973 , 2 ( 4 ): 89 - 100 .

GUO Y L , YAN J J , CHONG D T , et al . Experimental investigation on some key variables during pool water flash evaporation [J ] . AIP Conference Proceedings , 2010 , 1207 ( 1 ): 380 - 385 .

ZHANG Dan , CHONG Daotong , YAN Junjie , et al . Experimental study on static flash evaporation of aqueous NaCl solution at different flash speed: heat transfer characteristics [J ] . International Journal of Heat and Mass Transfer , 2013 , 65 : 584 - 591 .

GALOPPI G , SECCHI R , FERRARI L , et al . Radial piston expander as a throttling valve in a heat pump: focus on the 2-phase expansion [J ] . International Journal of Refrigeration , 2017 , 82 : 273 - 282 .

YANG Qingzhong , ZHAO Bingchao , ZHANG Dan , et al . Experimental study on heat transfer characteristics in static flash evaporation of aqueous NaCl solution [J ] . International Journal of Heat and Mass Transfer , 2016 , 102 : 1093 - 1099 .

YANG Qingzhong , ZHANG Dan , YAN Junjie , et al . Experimental study on energy conversion in static flash evaporation of aqueous NaCl solution [J ] . Desalination , 2018 , 430 : 56 - 63 .

YAN Junjie , ZHANG Dan , CHONG Daotong , et al . Experimental study on static/circulatory flash evaporation [J ] . International Journal of Heat and Mass Transfer , 2010 , 53 ( 23/24 ): 5528 - 5535 .

王超 , 陈学 , 胥蕊娜 , 等 . 低压加热条件下水膜蒸发特性 [J ] . 中国科学院大学学报 , 2018 , 35 ( 2 ): 188 - 192 .

WANG Chao , CHEN Xue , XU Ruina , et al . Water film heating evaporation under low pressure [J ] . Journal of University of Chinese Academy of Sciences , 2018 , 35 ( 2 ): 188 - 192 .

DEWANGAN K K , DAS P K . Numerical simulation of flash evaporation in the presence of secondary nucleation [J ] . International Journal of Multiphase Flow , 2021 , 142 : 103703 .

CHI Jun , SHEN Shengqiang , MU Xingsen . Experimental study on thermal characteristics of pure water flashing evaporation from thin-liquid film [J ] . Applied Thermal Engineering , 2023 , 233 : 121075 .

栾振博 . 管内水过冷流动沸腾传热系数关联式研究 [D ] . 合肥 : 中国科学技术大学 , 2020 : 10 - 18 .

陶文铨 . 传热学(第五版) [M ] . 北京 : 高等教育出版社 , 2019 .

PIORO I L , ROHSENOW W , DOERFFER S S . Nucleate pool-boiling heat transfer: Ⅰ review of parametric effects of boiling surface [J ] . International Journal of Heat and Mass Transfer , 2004 , 47 ( 23 ): 5033 - 5044 .

COLE R , PAPAZIAN J M , WILCOX W R . Bubble departure radii at solidification interfaces [J ] . International Journal of Heat and Mass Transfer , 1980 , 23 ( 2 ): 219 - 224 .

HAMZEKHANI S , MANIAVI FALAHIEH M , AKBARI A . Bubble departure diameter in nucleate pool boiling at saturation: pure liquids and binary mixtures [J ] . International Journal of Refrigeration , 2014 , 46 : 50 - 58 .

KIM J , KIM M H . On the departure behaviors of bubble at nucleate pool boiling [J ] . International Journal of Multiphase Flow , 2006 , 32 ( 10/11 ): 1269 - 1286 .

Moffat R J . Contributions to the theory of single-sample uncertainty analysis [J ] . Journal of Fluids Engineering , 1982 , 104 ( 2 ): 250 - 258 .

LEIDENFROSTJ G . De aquae communis nonnullis qualitatibus tractatus [M ] . Duisburg ad Rhenum : Ovenius , 1756 .

NUKIYAMA S . The maximum and minimum values of the heat Q transmitted from metal to boiling water under atmospheric pressure [J ] . International Journal of Heat and Mass Transfer , 1966 , 9 ( 12 ): 1419 - 1433 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

开式系统中水膜闪蒸换热特性的实验研究

封闭腔水膜闪蒸汽液界面瞬态传质系数的实验研究

水蒸气掺混对氨裂解气旋流燃烧与排放特性的影响研究

隧道内燃料电池汽车氢气泄漏扩散特性及影响因素

电子级超纯氮深冷空分流程节能优化研究