采用全局健康因子和残差模型的锂离子电池健康状态估计

胡循泉; 耿莉敏; 舒俊豪; 张文博; 巫春玲; 尉小龙; 黄东; 陈昊

doi:10.7652/xjtuxb202504010

您当前的位置：

首页 >

文章列表页 >

采用全局健康因子和残差模型的锂离子电池健康状态估计

—————————————————————— | 更新时间：2026-01-06

- 采用全局健康因子和残差模型的锂离子电池健康状态估计
- Estimation of Lithium-Ion Battery State of Health Using Global Health Factor and Residual Model
- 西安交通大学学报 2025年59卷第4期页码：105-117
- 作者机构：
  
  1.长安大学陕西省交通新能源开发、应用与汽车节能重点实验室， 710064，西安
  2.长安大学西安市交通先进动力重点实验室， 710064，西安
  3.陕西重型汽车有限公司汽车工程研究院， 710200，西安
  4.核工业二○三研究所， 712099，陕西咸阳
- 作者简介：
  
  胡循泉（2000—），男，硕士生；
  耿莉敏（通信作者），女，教授，博士生导师。
- 基金信息：
  
  陕西省自然科学基础研究计划资助项目(2023-JC-QN-0417);西安市科技计划资助项目(24ZDCYJSGG0048);咸阳市重点研发计划资助项目(L2023-ZDYF-SF-077)
- DOI：10.7652/xjtuxb202504010
  中图分类号： TM912.8
- 收稿：2024-11-29，
  
  网络首发：2025-01-02，
  
  纸质出版：2025-04-10
- 稿件说明：
移动端阅览
胡循泉, 耿莉敏, 舒俊豪, 等. 采用全局健康因子和残差模型的锂离子电池健康状态估计[J]. 西安交通大学学报, 2025,59(4):105-117.

HU Xunquan, GENG Limin, SHU Junhao, et al. Estimation of Lithium-Ion Battery State of Health Using Global Health Factor and Residual Model[J]. Journal of Xi’an Jiaotong University, 2025, 59(4): 105-117.
胡循泉, 耿莉敏, 舒俊豪, 等. 采用全局健康因子和残差模型的锂离子电池健康状态估计[J]. 西安交通大学学报, 2025,59(4):105-117. DOI： 10.7652/xjtuxb202504010.

HU Xunquan, GENG Limin, SHU Junhao, et al. Estimation of Lithium-Ion Battery State of Health Using Global Health Factor and Residual Model[J]. Journal of Xi’an Jiaotong University, 2025, 59(4): 105-117. DOI： 10.7652/xjtuxb202504010.

摘要

为准确估计锂离子电池的健康状态（SOH），提出了一种卷积神经网络-残差网络-双向门控循环单元-注意力机制（CNN-Residual-BiGRU-Attention）模型和微调估计方法。首先，采用分段近似聚合算法对电池容量增量和恒流充电曲线进行降维，构建全局健康因子；接着，利用卷积神经网络提取全局健康因子时序特征，通过注意力机制突出强相关特征，并引入残差网络保持信息完整性；最后，通过改进人工蜂群算法对模型超参数寻优，提升模型SOH估计精度。采用美国国家航空航天局和牛津大学锂离子电池数据集进行精度验证，结果表明：利用提出的微调估计方法，即使精度较差的卷积神经-长短期记忆模型，SOH估计结果的平均绝对误差

MAE

、平均绝对百分比误差

MAPE

和均方根误差

RMSE

也均在2%以内；相较于卷积神经网络-双向门控循环单元-注意力机制模型，采用CNN-Residual-BiGRU-Attention模型对训练集比例为30%的同一电池SOH进行估计，得到的

MAE

、

MAPE

和

RMSE

分别降低了41.86%、44.35%、42.11%；对训练集比例为40%的同类电池SOH进行估计，得到的

MAE

、

MAPE

和

RMSE

分别降低了45.51%、45.93%、40.10%。该研究结果可为低比例训练集条件下准确估计锂离子电池的SOH提供理论参考。

Abstract

To accurately estimate the state of health (SOH) of lithium-ion batteries

a convolutional neural network-residual-BiGRU-attention (CNN-Residual-BiGRU-Attention) model and fine-tuning estimation method are proposed. Firstly

a piecewise approximate aggregation algorithm is used to reduce the dimensionality of battery capacity increment and constant current charging curves to construct a global health facto

r. Secondly

the CNN is used to extract the temporal features of the global health factor

highlighting strong correlations through an attention mechanism

and the residual network is introduced to maintain information integrity. Finally

by improving the artificial bee colony algorithm for model hyperparameter optimization

the accuracy of SOH estimation is enhanced. The accuracy is validated using lithium-ion battery datasets from NASA and the University of Oxford. The results show that

even with a less accurate convolutional neural network-long short-term memory model

the proposed fine-tuning estimation method keeps the mean absolute error

MAE

mean absolute percentage error

MAPE

and root mean square error

RMSE

of the SOH estimation results within 2%. Compared with the CNN-BiGRU-Attention model

when the CNN-Residual-BiGRU-Attention model is employed to estimate the SOH of the same battery with a training set ratio of 30%

the

MAE

、

MAPE

and

RMSE

of the estimated results are reduced by 41.86%

44.35% and 42.11%

respectively. For estimating the SOH of the same type of batteries with a training set ratio of 40%

the

MAE

、

MAPE

and

RMSE

of the estimated results are reduced by 45.51%

45.93%

and 40.10%

respectively. These research findings provide a theoretical reference for accurately estimating the SOH of lithium-ion batteries under low training set conditions.

关键词

Keywords

references

尹杰 , 刘博 , 孙国兵 , 等 . 基于迁移学习和降噪自编码器-长短时间记忆的锂离子电池剩余寿命预测 [J ] . 电工技术学报 , 2024 , 39 ( 1 ): 289 - 302 .

YIN Jie , LIU Bo , SUN Guobing , et al . Transfer learning denoising autoencoder-long short term memory for remaining useful life prediction of li-ion batteries [J ] . Transactions of China Electrotechnical Society , 2024 , 39 ( 1 ): 289 - 302 .

郭鹏旭 , 赵理 , 张丰硕 . 基于随机充电片段的锂电池健康状态估计方法 [J/OL ] . 电源学报 . ( 2024-08-19 ) [ 2024-10-20 ] . http://kns.cnki.net/kcms/detail/12.1420.tm.20240819.1312.002.html http://kns.cnki.net/kcms/detail/12.1420.tm.20240819.1312.002.html .

GUO Pengxu , ZHAO Li , ZHANG Fengshuo . A method for estimating the health state of lithium batteries based on random charging segments [J/OL ] . Journal of Power Supply . ( 2024-08-19 ) [ 2024-10-20 ] . http://kns.cnki.net/kcms/detail/12.1420.tm.20240819.1312.002.html http://kns.cnki.net/kcms/detail/12.1420.tm.20240819.1312.002.html .

李卓昊 , 石琼林 , 王康丽 , 等 . 锂离子电池健康状态估计方法研究现状与展望 [J ] . 电力系统自动化 , 2024 , 48 ( 20 ): 109 - 129 .

LI Zhuohao , SHI Qionglin , WANG Kangli , et al . Research status and prospects of state of health estimation methods for lithium-ion batteries [J ] . Automation of Electric Power Systems , 2024 , 48 ( 20 ): 109 - 129 .

廖列法 , 占玉敏 , 刘映宝 . 基于IViT的锂离子电池健康状态估计 [J ] . 电子测量技术 , 2024 , 47 ( 18 ): 63 - 70 .

LIAO Liefa , ZHAN Yumin , LIU Yingbao . Lithium-ion battery state of health estimation based on IViT [J ] . Electronic Measurement Technology , 2024 , 47 ( 18 ): 63 - 70 .

李鹏 , 葛儒哲 , 董存 , 等 . 基于转置Transformer模型的电化学储能自适应SOH估计方法 [J/OL ] . 高电压技术 . ( 2024-08-12 ) [ 2024-10-30 ] . https://doi.org/10.13336/j.1003-6520.hve.20240555 https://doi.org/10.13336/j.1003-6520.hve.20240555 .

LI Peng , GE Ruzhe , DONG Cun , et al . Adaptive SOH estimation method based on the transpose transformer model for electrochemical energy storage [J/OL ] . High Voltage Engineering . ( 2024-08-12 ) [ 2024-09-15 ] . https://doi.org/10.13336/j.1003-6520.hve.20240555 https://doi.org/10.13336/j.1003-6520.hve.20240555 .

李远茂 , 刘桂雄 . 动力锂离子电池关键参数估计方法研究进展 [J ] . 中国测试 , 2024 , 50 ( 6 ): 1 - 9 .

LI Yuanmao , LIU Guixiong . Research progress of key parameter estimation methods for power lithium-ion batteries [J ] . China Measurement & Test , 2024 , 50 ( 6 ): 1 - 9 .

TANG Aihua , HUANG Yukun , XU Yuchen , et al . Data-physics-driven estimation of battery state of charge and capacity [J ] . Energy , 2024 , 294 : 130776 .

赵月荷 , 庞宗强 . 基于无迹卡尔曼滤波的动力电池健康状态估计 [J ] . 国外电子测量技术 , 2022 , 41 ( 10 ): 136 - 141 .

ZHAO Yuehe , PANG Zongqiang . State of health estimation of power batteries based on unscented Kalman filter [J ] . Foreign Electronic Measurement Technology , 2022 , 41 ( 10 ): 136 - 141 .

CHEN Lu , WANG Shunli , CHEN Lei , et al . An improved grey wolf optimization-double adaptive extended Kalman filtering algorithm for co-estimation of state of charge and state of health for lithium-ion batteries based on temperature-dependent second-order RC model [J ] . Ionics , 2024 , 30 ( 8 ): 4631 - 4646 .

熊庆 , 邸振国 , 汲胜昌 . 锂离子电池健康状态估计及寿命预测研究进展综述 [J ] . 高电压技术 , 2024 , 50 ( 3 ): 1182 - 1195 .

XIONG Qing , DI Zhenguo , JI Shengchang . Review on health state estimation and life prediction of lithium-ion batteries [J ] . High Voltage Engineering , 2024 , 50 ( 3 ): 1182 - 1195 .

朱振宇 , 高德欣 . 基于混合网络的锂离子电池健康状态与剩余使用寿命联合估计方法 [J ] . 信息与控制 , 2024 , 53 ( 1 ): 120 - 128 .

ZHU Zhenyu , GAO Dexin . Joint estimation method of state of health and remaining useful life for lithium-ion batteries based on hybrid networks [J ] . Information and Control , 2024 , 53 ( 1 ): 120 - 128 .

ZHANG Mei , YIN Jun , CHEN Wanli . SOH estimation and RUL prediction of lithium batteries based on multidomain feature fusion and CatBoost model [J ] . Energy Science & Engineering , 2023 , 11 ( 9 ): 3082 - 3101 .

申江卫 , 马文赛 , 肖仁鑫 , 等 . 基于优化高斯过程回归算法的锂离子电池可用容量估算 [J ] . 中国公路学报 , 2022 , 35 ( 8 ): 31 - 43 .

SHEN Jiangwei , MA Wensai , XIAO Renxin , et al . Available capacity estimation of lithium-ion batteries based on optimized Gaussian process regression [J ] . China Journal of Highway and Transport , 2022 , 35 ( 8 ): 31 - 43 .

吴青峰 , 杨艺涛 , 刘立群 , 等 . 基于GA-SA-BP神经网络的锂电池健康状态估算方法 [J ] . 电力系统保护与控制 , 2024 , 52 ( 19 ): 74 - 84 .

WU Qingfeng , YANG Yitao , LIU Liqun , et al . Lithium battery state of health estimation method based on a GA-SA-BP neural network [J ] . Power System Protection and Control , 2024 , 52 ( 19 ): 74 - 84 .

方斯顿 , 刘龙真 , 孔赖强 , 等 . 基于双向长短期记忆网络含间接健康指标的锂电池SOH估计 [J ] . 电力系统自动化 , 2024 , 48 ( 4 ): 160 - 168 .

FANG Sidun , LIU Longzhen , KONG Laiqiang , et al . State-of-health estimation for lithium-ion batteries incorporating indirect health indicators based on bi-directional long short-term memory networks [J ] . Automation of Electric Power Systems , 2024 , 48 ( 4 ): 160 - 168 .

DING Can , GUO Qing , ZHANG Lulu , et al . A hybrid data-driven approach for state of health estimation in lithium-ion batteries [J ] . Energy Sources: Part A Recovery, Utilization, and Environmental Effects , 2024 , 46 ( 1 ): 67 - 83 .

司江宽 , 吐松江·卡日 , 范想 , 等 . 基于SO-PAA-GAF和AdaBoost集成学习的高压断路器故障诊断 [J ] . 电力系统保护与控制 , 2024 , 52 ( 3 ): 152 - 160 .

SI Jiangkuan , TUSONGJIANG Kari , FAN Xiang , et al . Fault diagnosis of high-voltage circuit breaker based on SO-PAA-GAF and AdaBoost ensemble learning [J ] . Power System Protection and Control , 2024 , 52 ( 3 ): 152 - 160 .

OSPINA AGUDELO B , ZAMBONI W , MONMASSON E . Application domain extension of incremental capacity-based battery SoH indicators [J ] . Energy , 2021 , 234 : 121224 .

XU Zhicheng , WANG Jun , LUND P D , et al . Estimation and prediction of state of health of electric vehicle batteries using discrete incremental capacity analysis based on real driving data [J ] . Energy , 2021 , 225 : 120160 .

钱伟 , 王亚丰 , 王晨 , 等 . 基于BP神经网络与H∞滤波的锂电池SoH-SoC联合估计研究 [J ] . 仪器仪表学报 , 2024 , 45 ( 6 ): 307 - 319 .

QIAN Wei , WANG Yafeng , WANG Chen , et al . Joint estimation of SoH-SoC for lithium battery based on BP neural network and H infinity filter [J ] . Chinese Journal of Scientific Instrument , 2024 , 45 ( 6 ): 307 - 319 .

李习龙 , 张涌 , 张伟 , 等 . 基于健康因子和CNN-BiLSTM的锂离子电池健康状态预测 [J/OL ] . 南京信息工程大学学报 . ( 2024-07-19 ) [ 2024-09-29 ] . https://doi.org/10.13878/j.cnki.jnuist.20240514002 https://doi.org/10.13878/j.cnki.jnuist.20240514002 .

LI Xilong , ZHANG Yong , ZHANG Wei , et al . Prediction of lithium-ion battery health status based on health factors and CNN-BiLSTM [J/OL ] . Journal of Nanjing University of Information Science & Technology . ( 2024-07-19 ) [ 2024-08-20 ] . https://doi.org/10.13878/j.cnki.jnuist.20240514002 https://doi.org/10.13878/j.cnki.jnuist.20240514002 .

黄杰明 , 黄小荣 , 张庆波 , 等 . 基于WPT与SSA优化的数据驱动电池健康状态估计 [J/OL ] . 电源学报 . ( 2024-05-24 ) [ 2024-07-12 ] . http://kns.cnki.net/kcms/detail/12.1420.TM.20240523.1722.002.html http://kns.cnki.net/kcms/detail/12.1420.TM.20240523.1722.002.html .

HUANG Jieming , HUANG Xiaorong , ZHANG Qingbo , et al . Data-driven battery health state estimation based on WPT and SSA optimization [J/OL ] . Journal of Power Supply . ( 2024-05-24 ) [ 2024-07-20 ] . http://kns.cnki.net/kcms/detail/12.1420.TM.20240523.1722.002.html http://kns.cnki.net/kcms/detail/12.1420.TM.20240523.1722.002.html .

钟耿钦 , 王学梅 , 康龙云 . 基于GRU-BP的锂电池部分充电数据SOH估计 [J/OL ] . 电源学报 . ( 2024-04-26 ) [ 2024-06-16 ] . http://kns.cnki.net/kcms/detail/12.1420.TM.20240426.1058.038.html http://kns.cnki.net/kcms/detail/12.1420.TM.20240426.1058.038.html .

ZHONG Gengqin , WANG Xuemei , KANG Longyun . SOH estimation of partial charging data for lithium batteries based on GRU-BP [J/OL ] . Journal of Power Supply . ( 2024-04-26 ) [ 2024-05-05 ] . http://kns.cnki.net/kcms/detail/12.1420.TM.20240426.1058.038.html http://kns.cnki.net/kcms/detail/12.1420.TM.20240426.1058.038.html .

董浩 , 毛玲 , 屈克庆 , 等 . 基于温度和SOC的锂离子电池特征提取及SOH估计 [J ] . 浙江大学学报(工学版) , 2023 , 57 ( 7 ): 1470 - 1478 .

DONG Hao , MAO Ling , QU Keqing , et al . Factor extraction and SOH estimation of lithium-ion battery based on temperature and SOC [J ] . Journal of Zhejiang University (Engineering Science) , 2023 , 57 ( 7 ): 1470 - 1478 .

GAO Renjing , ZHANG Yunfei , LYU Z . A SOH estimation method of lithium-ion batteries based on partial charging data [J ] . Journal of Energy Storage , 2024 , 103 ( Part A ): 114309 .

KARABOGA D , BASTURK B . A powerful and efficient algorithm for numerical function optimization: artificial bee colony (ABC) algorithm [J ] . Journal of Global Optimization , 2007 , 39 ( 3 ): 459 - 471 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

闪蒸焦耳加热技术在废旧锂离子电池回收与再生中的机制、应用与前景

采用似然比检测的电动车锂离子电池传感器故障检测方法

锂离子电池同心结构液冷板冷却性能分析及结构优化

采用似然比检测的电动车锂离子电池传感器故障检测方法

锂电池冷板新波形微流道传热特性研究及结构优化