聚丙烯/聚烯烃弹性体复合材料空间电荷和电导特性

曹丹; 梁启璐; 展云鹏; 侯帅; 廖雁群; 曹安瑛; 何伟; 吴锴; 吕泽鹏

doi:10.7652/xjtuxb202504006

您当前的位置：

首页 >

文章列表页 >

聚丙烯/聚烯烃弹性体复合材料空间电荷和电导特性

—————————————————————— | 更新时间：2026-01-06

- 聚丙烯/聚烯烃弹性体复合材料空间电荷和电导特性
- Space Charge and Conductance Characteristics of Polypropylene/Polyolefin Elastomer Composites
- 西安交通大学学报 2025年59卷第4期页码：60-69
- 作者机构：
  
  1.西安交通大学电力设备电气绝缘国家重点实验室， 710049，西安
  2.南方电网科学研究院有限责任公司， 510080，广州
  3.广东电网有限责任公司珠海供电局， 519075，广东珠海
- 作者简介：
  
  曹丹（1988—），女，博士生；
  吕泽鹏（通信作者），男，教授，博士生导师。
- 基金信息：
  
  南方电网公司科技资助项目(GDKJXM20222136)
- DOI：10.7652/xjtuxb202504006
  中图分类号： TM215
- 收稿：2024-09-20，
  
  网络首发：2024-12-10，
  
  纸质出版：2025-04-10
- 稿件说明：
移动端阅览
曹丹, 梁启璐, 展云鹏, 等. 聚丙烯/聚烯烃弹性体复合材料空间电荷和电导特性[J]. 西安交通大学学报, 2025,59(4):60-69.

CAO Dan, LIANG Qilu, ZHAN Yunpeng, et al. Space Charge and Conductance Characteristics of Polypropylene/Polyolefin Elastomer Composites[J]. Journal of Xi’an Jiaotong University, 2025, 59(4): 60-69.
曹丹, 梁启璐, 展云鹏, 等. 聚丙烯/聚烯烃弹性体复合材料空间电荷和电导特性[J]. 西安交通大学学报, 2025,59(4):60-69. DOI： 10.7652/xjtuxb202504006.

CAO Dan, LIANG Qilu, ZHAN Yunpeng, et al. Space Charge and Conductance Characteristics of Polypropylene/Polyolefin Elastomer Composites[J]. Journal of Xi’an Jiaotong University, 2025, 59(4): 60-69. DOI： 10.7652/xjtuxb202504006.

摘要

针对聚丙烯（PP）经弹性体增韧后力学和电学性能发生变化，引入弹性体导致材料电学性能下降的问题，采用共混法在PP基体中添加不同质量分数的聚烯烃弹性体（POE）。结合复合材料力学及绝缘性能研究，提出力-电综合性能最优的POE配比，又进一步结合复合材料微观形貌、热转变特征及绝缘性能，分析高温下PP/POE复合材料的空间电荷积聚和电荷输运特性。研究发现，随着POE含量的增加，PP/POE复合材料的弹性模量降低，直流击穿场强随POE含量的增加下降，高电场下

POE

为40%复合材料的电导率是所有复合材料中最低的，约为PP电导率的3倍，其他复合材料电导率比PP大一个数量级，20 ℃下，

POE

分别为50%、60%复合材料的异极性电荷积累量较大。高温下，PP和

POE

为40%复合材料直流击穿场强随温度升高下降，PP空间电荷性能较稳定，

POE

为40%复合材料空间电荷积聚量随温度升高增加，尤其在60 ℃以上，内部空间电荷量剧增。研究揭示了PP/POE复合材料在高温下的空间电荷积聚和电导剧增，这是限制其绝缘性能的关键问题。

Abstract

In response to the changes in mechanical and electrical properties of polypropylene (PP) after toughening with an elastomer

which leads to a decrease in material's electrical performance due to the introduction of the elastomer

a blend method is employed to add different mass fractions of polyolefin elastomer (POE) into the PP matrix. Firstly

considering research on mechanical and insulation properties of composite materials

the optimal POE ratio for the best overall mechanical-electrical performance is proposed. Furthermore

the space charge accumulation and charge transport characteristics of PP/POE composites at high temperature are analyzed based on the microstructure

thermal transition characteristics and insulation properties of the composites. The r

esearch shows that with an increase in POE content

the elastic modulus of PP/POE composites decrease

and the direct current breakdown strength decreases with increasing POE content. Under high electric fields

the electrical conductivity of the composite with

POE

=40% is the lowest among all composites

approximately three times that of PP conductivity. Other composites exhibit electrical conductivities one order of magnitude higher than PP. At 20 ℃

composites with

POE

=50%

60% respectively show significant anisotropic charge accumulation. At high temperatures

the DC breakdown strength of PP and the composite with

POE

=40% decreases with increasing temperature. The spatial charge performance of PP is relatively stable

while the spatial charge accumulation in the composite with

POE

=40% increases with temperature

especially above 60 ℃

leading to a significant increase in internal space charge. This research reveals that the accumulation of space charge and the dramatic increase in electrical conductivity of PP/POE composites at high temperatures are key issues limiting their insulation performance.

关键词

Keywords

references

ZHOU Yao , HU Jun , HE Jinliang . Space charge behavior in polypropylene/polyolefin elastomer/MgO nanocomposites under temperature gradient [C ] // 2016 IEEE Conference on Electrical Insulation and Dielectric Phenomena . Piscataway, NJ, USA : IEEE , 2016 : 599 - 602 .

王亚 , 吕泽鹏 , 吴锴 , 等 . 高压直流XLPE电缆研究现状 [J ] . 绝缘材料 , 2014 , 47 ( 1 ): 22 - 25 .

WANG Ya , LÜ Zepeng , WU Kai , et al . Research status of HVDC XLPE cable [J ] . Insulating Materials , 2014 , 47 ( 1 ): 22 - 25 .

ZHOU Yao , HU Jun , DANG Bin , et al . Effect of different nanoparticles on tuning electrical properties of polypropylene nanocomposites [J ] . IEEE Transactions on Dielectrics and Electrical Insulation , 2017 , 24 ( 3 ): 1380 - 1389 .

HUANG Xingyi , ZHANG Jun , JIANG Pingkai , et al . Material progress toward recyclable insulation of power cables: part 1 polyethylene-based thermoplastic materials: dedicated to the 80th birthday of professor Toshikatsu Tanaka [J ] . IEEE Electrical Insulation Magazine , 2019 , 35 ( 5 ): 7 - 19 .

邵满智 , 万玉鑫 , 牛越 , 等 . 电压稳定剂接枝改善聚丙烯基绝缘材料性能研究 [J ] . 绝缘材料 , 2022 , 55 ( 5 ): 35 - 41 .

SHAO Manzhi , WAN Yuxin , NIU Yue , et al . Properties of polypropylene based insulating materials improved by grafting voltage stabilizer [J ] . Insulating Materials , 2022 , 55 ( 5 ): 35 - 41 .

闫伟涛 , 党智敏 , 徐海萍 . 聚丙烯/聚偏氟乙烯共混复合材料的介电性能的研究 [J ] . 绝缘材料 , 2007 , 40 ( 3 ): 45 - 47 .

YAN Weitao , DANG Zhimin , XU Haiping . Study on dielectric property of the PP/PVDF blending composites [J ] . Insulating Materials , 2007 , 40 ( 3 ): 45 - 47 .

彭倩 , 吴广宁 , 张星海 , 等 . 机械应力对聚丙烯薄膜局部放电性能的影响 [J ] . 高电压技术 , 2008 , 34 ( 6 ): 1261 - 1266 .

PENG Qian , WU Guangning , ZHANG Xinghai , et al . Influence of mechanical stress on polypropylene film partial discharge [J ] . High Voltage Engineering , 2008 , 34 ( 6 ): 1261 - 1266 .

ZHENG Changji , YANG Jiaming , ZHAO Hong , et al . AC performance, physical and mechanical properties of polypropylene/polyolefin elastomers blends [C ] // 2018 12th International Conference on the Properties and Applications of Dielectric Materials . Piscataway, NJ, USA : IEEE , 2018 : 910 - 913 .

HOSIER I L , VAUGHAN A S , SWINGLER S G . An investigation of the potential of polypropylene and its blends for use in recyclable high voltage cable insulation systems [J ] . Journal of Materials Science , 2011 , 46 ( 11 ): 4058 - 4070 .

CHI Xiaohong , CHENG Lu , LIU Wenfeng , et al . Characterization of polypropylene modified by blending elastomer and nano-silica [J ] . Materials , 2018 , 11 ( 8 ): 1321 .

杜伯学 , 侯兆豪 , 徐航 , 等 . 高压直流电缆绝缘用聚丙烯及其纳米复合材料的研究进展 [J ] . 高电压技术 , 2017 , 43 ( 9 ): 2769 - 2780 .

DU Boxue , HOU Zhaohao , XU Hang , et al . Research achievements in polypropylene and polypropylene/inorganic nanocomposites for HVDC cable insulation [J ] . High Voltage Engineering , 2017 , 43 ( 9 ): 2769 - 2780 .

王帆 , 刘小燕 , 周玲 , 等 . 抗冲共聚聚丙烯的结构与性能 [J ] . 合成树脂及塑料 , 2019 , 36 ( 1 ): 58 - 62 .

WANG Fan , LIU Xiaoyan , ZHOU Ling , et al . Structure and properties of IPC [J ] . China Synthetic Resin and Plastics , 2019 , 36 ( 1 ): 58 - 62 .

周彤辉 , 阮文红 , 王跃林 , 等 . 原位接枝改性纳米二氧化硅/聚丙烯复合材料：结构表征 [J ] . 复合材料学报 , 2006 , 23 ( 2 ): 71 - 76 .

ZHOU Tonghui , RUAN Wenhong , WANG Yuelin , et al . Polypropylene composites with nano-silica modified by in-situ grafting polymerization: structure characterization [J ] . Acta Materiae Compositae Sinica , 2006 , 23 ( 2 ): 71 - 76 .

王鉴 , 王绪文 , 李安莲 , 等 . 聚丙烯化学改性方法 [J ] . 现代塑料加工应用 , 2010 , 22 ( 6 ): 55 - 59 .

WANG Jian , WANG Xuwen , LI Anlian , et al . The way of chemical modification of polypropylene [J ] . Modern Plastics Processing and Applications , 2010 , 22 ( 6 ): 55 - 59 .

石璞 , 陈浪 , 钟苗苗 , 等 . 高组分纳米碳酸钙填充聚丙烯及增韧机理 [J ] . 高分子材料科学与工程 , 2015 , 31 ( 10 ): 69 - 74 .

SHI Pu , CHEN Lang , ZHONG Miaomiao , et al . Toughening mechanism of polypropylene with high components of nano-calcium carbonate [J ] . Polymer Materials Science & Engineering , 2015 , 31 ( 10 ): 69 - 74 .

DASARI A , YU Zhongzhen , MAI Y W . Effect of blending sequence on microstructure of ternary nanocomposites [J ] . Polymer , 2005 , 46 ( 16 ): 5986 - 5991 .

周梦思 . 不同弹性体增韧聚丙烯的研究 [D ] . 长春 : 长春工业大学 , 2013 .

欧阳本红 , 黄凯文 , 赵鹏 , 等 . 电力电缆聚丙烯材料的研究进展 [J ] . 绝缘材料 , 2022 , 55 ( 8 ): 6 - 15 .

OUYANG Benhong , HUANG Kaiwen , ZHAO Peng , et al . Research progress of polypropylene materials for power cables [J ] . Insulating Materials , 2022 , 55 ( 8 ): 6 - 15 .

高猛 . EPDM/PP热塑性弹性体的制备及性能研究 [D ] . 哈尔滨 : 哈尔滨工业大学 , 2010 .

HOSIER I L , REAUD S , VAUGHAN A S , et al . Morphology, thermal, mechanical and electrical properties of propylene-based materials for cable applications [C ] // Conference Record of the 2008 IEEE International Symposium on Electrical Insulation . Piscataway, NJ, USA : IEEE , 2008 : 502 - 505 .

HOSIER I L , COZZARINI L , VAUGHAN A S , et al . Propylene based systems for high voltage cable insulation applications [C ] // Journal of Physics: Conference Series . Bristol, UK : IOP Publishing , 2009 : 012015 .

YAN Zhimin , YAN Hongda , LI Wenpeng , et al . Effect of blending modification on the mechanical and dielectric properties of polypropylene for environment-friendly cable insulation [C ] // 2022 IEEE/IAS Industrial and Commercial Power System Asia . Piscataway, NJ, USA : IEEE , 2022 : 997 - 1001 .

GREEN C D , VAUGHAN A S , STEVENS G C , et al . Thermoplastic cable insulation comprising a blend of isotactic polypropylene and a propylene-ethylene copolymer [J ] . IEEE Transactions on Dielectrics and Electrical Insulation , 2015 , 22 ( 2 ): 639 - 648 .

ZHA Junwei , WANG Ying , LI Weikang , et al . Electrical properties of polypropylene/styrene-ethylene-butylene-styrene block copolymer/MgO nanocomposites [J ] . IEEE Transactions on Dielectrics and Electrical Insulation , 2017 , 24 ( 3 ): 1457 - 1464 .

GAO Y , LI J , LI Y , et al . Effect of elastomer type on electrical and mechanical properties of polypropylene/elastomer blends [C ] // 2017 International Symposium on Electrical Insulating Materials . Piscataway, NJ, USA : IEEE , 2017 : 574 - 577 .

ZHOU Yao , HE Jinliang , HU Jun , et al . Evaluation of polypropylene/polyolefin elastomer blends for potential recyclable HVDC cable insulation applications [J ] . IEEE Transactions on Dielectrics and Electrical Insulation , 2015 , 22 ( 2 ): 673 - 681 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

X射线辐照下聚酰亚胺材料空间电荷分布特性的数值模拟

两步烧结法对钛酸锶钡陶瓷调谐及击穿性能的影响

聚乙烯绝缘中温度梯度效应对直流电场的畸变特性

极性反转时间对聚乙烯中空间电荷及瞬态电场的影响

融合物理信息与深度算子网络的变压器绕组热-流场快速计算方法