甲烷/甲醇固体氧化物燃料电池输出电特性与内部多物理场分布模拟研究

李博涵; 刘畅; 王朝阳; 刘明; 严俊杰

doi:10.7652/xjtuxb202503002

您当前的位置：

首页 >

文章列表页 >

甲烷/甲醇固体氧化物燃料电池输出电特性与内部多物理场分布模拟研究

更新时间：2026-01-06

- 甲烷/甲醇固体氧化物燃料电池输出电特性与内部多物理场分布模拟研究
- Study on the Output Electrical Characteristics and Internal Multi-Physics Field Distribution Simulation of Methane/Methanol Solid Oxide Fuel Cells
- 西安交通大学学报 2025年59卷第3期页码：9-20
- 作者机构：
  
  西安交通大学动力工程多相流国家重点实验室， 710049，西安
- 作者简介：
  
  李博涵（1997—），男，博士生；
  王朝阳（通信作者），男，副教授，硕士生导师。
- 基金信息：
  
  国家自然科学基金资助项目(52106026)
- DOI：10.7652/xjtuxb202503002
  中图分类号： TM911.4
- 收稿：2024-07-10，
  
  网络首发：2024-10-28，
  
  纸质出版：2025-03-10
- 稿件说明：
移动端阅览
李博涵, 刘畅, 王朝阳, 等. 甲烷/甲醇固体氧化物燃料电池输出电特性与内部多物理场分布模拟研究[J]. 西安交通大学学报, 2025,59(3):9-20.

LI Bohan, LIU Chang, WANG Chaoyang, et al. Study on the Output Electrical Characteristics and Internal Multi-Physics Field Distribution Simulation of Methane/Methanol Solid Oxide Fuel Cells[J]. Journal of Xi’an Jiaotong University, 2025, 59(3): 9-20.
李博涵, 刘畅, 王朝阳, 等. 甲烷/甲醇固体氧化物燃料电池输出电特性与内部多物理场分布模拟研究[J]. 西安交通大学学报, 2025,59(3):9-20. DOI： 10.7652/xjtuxb202503002.

LI Bohan, LIU Chang, WANG Chaoyang, et al. Study on the Output Electrical Characteristics and Internal Multi-Physics Field Distribution Simulation of Methane/Methanol Solid Oxide Fuel Cells[J]. Journal of Xi’an Jiaotong University, 2025, 59(3): 9-20. DOI： 10.7652/xjtuxb202503002.

摘要

为揭示固体氧化物燃料电池（SOFC）在不同种类燃料供应时电池内部多物理场之间的相互作用规律，建立并验证了多场耦合的三维平板式SOFC单电池模型，对比研究了以氢气、甲烷、甲醇为燃料的SOFC稳态性能差异，获得了电池内部温度场、浓度场分布特性和碳氢燃料在电池中的积碳特性。研究结果表明：甲烷燃料的预重整能够有效提高电池放电能力，预重整度提高20%，电池最大输出功率提高8%。与甲烷相比，甲醇燃料的预重整对电池输出功率影响较小。采用甲烷燃料能够降低电池因温度梯度过大而损坏的风险，电池阳极-气体流道交界面的最大温度梯度为10 K/cm，相比于以氢气作为燃料时的22 K/cm有明显的下降。研究获得了不同电压下电池内部的积碳速率分布特性，运行电压

降低会增大电池内部的积碳速率，

=0.5 V时甲烷燃料的积碳速率约为

=0.9 V时积碳速率的2倍以上。相比于甲烷作为燃料，选取甲醇作为SOFC电池的燃料时，电池内部具有更低的积碳风险。

Abstract

To reveal the interplay of various internal multi-physics fields within solid oxide fuel cells (SOFCs) fueled by different types of fuels

a multi-field coupled three-dimensional planar SOFC single-cell model is established and validated. A comparative analysis is conducted to explore the variations in steady-state performance of SOFCs fueled by hydrogen

methane

and methanol. The distribution characteristics of temperature fields

concentration fields inside the cell

and the carbon deposition characteristics of hydrocarbon fuels in the cell are obtained. The results show that the pre-reforming of methane fuel can effectively improve the cell's discharge capacity

with a 20% increase in pre-reforming degree leading to an 8% increase in the cell's maximum output power. In comparison to methane

the impact of pre-reforming methanol fuel on the cell's output power is relatively small. The use of methane fuel can mitigate the risk of cell damage due to excessive temperature gradients

with the maximum temperature gradient at the anod

e-gas flow channel interface reduced to 10 K/cm

as opposed to 22 K/cm when using hydrogen as fuel. This paper also unveils the distribution characteristics of carbon deposition rates inside the cell at different voltages. Lowering the operating voltage increases the carbon deposition rate inside the cell

with the carbon deposition rate for methane fuel at

=0.5 V being more than double that at

=0.9 V. Selecting methanol as the fuel for SOFCs poses a lower risk of internal carbon deposition compared to methane as the fuel.

关键词

Keywords

references

舒印彪 , 张丽英 , 张运洲 , 等 . 我国电力碳达峰、碳中和路径研究 [J ] . 中国工程科学 , 2021 , 23 ( 6 ): 1 - 14 .

SHU Yinbiao , ZHANG Liying , ZHANG Yunzhou , et al . Carbon peak and carbon neutrality path for China's power industry [J ] . Strategic Study of CAE , 2021 , 23 ( 6 ): 1 - 14 .

肖先勇 , 郑子萱 . "双碳"目标下新能源为主体的新型电力系统：贡献、关键技术与挑战 [J ] . 工程科学与技术 , 2022 , 54 ( 1 ): 47 - 59 .

XIAO Xianyong , ZHENG Zixuan . New power systems dominated by renewable energy towards the goal of emission peak & carbon neutrality: contribution, key techniques, and challenges [J ] . Advanced Engineering Sciences , 2022 , 54 ( 1 ): 47 - 59 .

LI Jianglong , HO M S , XIE Chunping , et al . China's flexibility challenge in achieving carbon neutrality by 2060 [J ] . Renewable and Sustainable Energy Reviews , 2022 , 158 : 112112 .

胡亮 , 杨志宾 , 熊星宇 , 等 . 我国固体氧化物燃料电池产业发展战略研究 [J ] . 中国工程科学 , 2022 , 24 ( 3 ): 118 - 126 .

HU Liang , YANG Zhibin , XIONG Xingyu , et al . Development strategy for solid oxide fuel cell industry in China [J ] . Strategic Study of CAE , 2022 , 24 ( 3 ): 118 - 126 .

VENKATARAMAN V , PÉREZ-FORTES M , WANG Ligang , et al . Reversible solid oxide systems for energy and chemical applications-review & perspectives [J ] . Journal of Energy Storage , 2019 , 24 : 100782 .

滕梓源 , 张海明 , 吕泽伟 , 等 . 分布式固体氧化物燃料电池发电系统发展现状与展望 [J ] . 中国电机工程学报 , 2023 , 43 ( 20 ): 7959 - 7972 .

TENG Ziyuan , ZHANG Haiming , LÜ Zewei , et al . Development status and prospect of distributed solid oxide fuel cell power generation system [J ] . Proceedings of the CSEE , 2023 , 43 ( 20 ): 7959 - 7972 .

MALIK V , SRIVASTAVA S , BHATNAGAR M K , et al . Comparative study and analysis between solid oxide fuel cells (SOFC) and proton exchange membrane (PEM) fuel cell: a review [J ] . Materials Today: Proceedings , 2021 , 47 ( Part 10 ): 2270 - 2275 .

CORIGLIANO O , FRAGIACOMO P . Extensive analysis of SOFC fed by direct syngas at different anodic compositions by using two numerical approaches [J ] . Energy Conversion and Management , 2020 , 209 : 112664 .

ABEDINIA O , SHAKIBI H , SHOKRI A , et al . Optimization of a syngas-fueled SOFC-based multigeneration system: enhanced performance with biomass and gasification agent selection [J ] . Renewable and Sustainable Energy Reviews , 2024 , 199 : 114460 .

LIU Jianzi , YANG Mingyue , CHAUHAN B S , et al . A comparison of two schemes for pure hydrogen injection into a syngas-fueled SOFC: thermoeconomic and environmental-based investigations [J ] . Process Safety and Environmental Protection , 2023 , 175 : 783 - 795 .

YANG Peizhi , ZHANG Yongqian , YANG Chong , et al . Thermodynamic performance comparison of a SOFC system integrated with steam reforming and dry reforming by utilizing different fuels [J ] . Energy Conversion and Management , 2024 , 300 : 117981 .

VAN VELDHUIZEN B N , VAN BIERT L , AMLADI A , et al . The effects of fuel type and cathode off-gas recirculation on combined heat and power generation of marine SOFC systems [J ] . Energy Conversion and Management , 2023 , 276 : 116498 .

马万达 , 魏胜利 , 杜振华 , 等 . 零碳/低碳燃料固体氧化物燃料电池-发动机联合动力系统热力学分析 [J ] . 西安交通大学学报 , 2023 , 57 ( 1 ): 100 - 109 .

MA Wanda , WEI Shengli , DU Zhenhua , et al . Thermodynamic analysis for zero-carbon and low-carbon fuel on SOFC-engine hybrid power system [J ] . Journal of Xi'an Jiaotong University , 2023 , 57 ( 1 ): 100 - 109 .

肖瑶 , 刘志军 , 魏炜 , 等 . 甲烷固体氧化物燃料电池的多物理场耦合积碳模型 [J ] . 洁净煤技术 , 2024 , 30 ( 5 ): 144 - 154 .

XIAO Yao , LIU Zhijun , WEI Wei , et al . Numerical simulation of carbon deposition in direct methane solid oxide fuel cells [J ] . Clean Coal Technology , 2024 , 30 ( 5 ): 144 - 154 .

ZHU Pengfei , YAO Jing , WU Zhen , et al . Construction of a transient multi-physics model of solid oxide fuel cell fed by biomass syngas considering the carbon deposition and temperature effect [J ] . Chemical Engineering Journal , 2022 , 442 ( Part 2 ): 136159 .

NOURI F , MAGHSOUDY S , HABIBZADEH S . Dynamic insights of carbon management and performance enhancement approaches in biogas-fueled solid oxide fuel cells: a computational exploration [J ] . International Journal of Hydrogen Energy , 2024 , 50 ( Part C ): 1314 - 1328 .

LI Zheng , YANG Guogang , SHEN Qiuwan , et al . Transient multi-physics modeling and performance degradation evaluation of direct internal reforming solid oxide fuel cell focusing on carbon deposition effect [J ] . Energies , 2023 , 16 ( 1 ): 124 .

LEE S , KIM H , YOON K J , et al . The effect of fuel utilization on heat and mass transfer within solid oxide fuel cells examined by three-dimensional numerical simulations [J ] . International Journal of Heat and Mass Transfer , 2016 , 97 : 77 - 93 .

BAE Y , LEE S , YOON K J , et al . Three-dimensional dynamic modeling and transport analysis of solid oxide fuel cells under electrical load change [J ] . Energy Conversion and Management , 2018 , 165 : 405 - 418 .

FAHEEM H H , ABBAS S Z , TABISH A N , et al . A review on mathematical modelling of direct internal reforming-solid oxide fuel cells [J ] . Journal of Power Sources , 2022 , 520 : 230857 .

DAMM D L , FEDOROV A G . Radiation heat transfer in SOFC materials and components [J ] . Journal of Power Sources , 2005 , 143 ( 1/2 ): 158 - 165 .

HABERMAN B A , YOUNG J B . Three-dimensional simulation of chemically reacting gas flows in the porous support structure of an integrated-planar solid oxide fuel cell [J ] . International Journal of Heat and Mass Transfer , 2004 , 47 ( 17/18 ): 3617 - 3629 .

GOKON N , OSAWA Y , NAKAZAWA D , et al . Kinetics of CO 2 reforming of methane by catalytically activated metallic foam absorber for solar receiver-reactors [J ] . International Journal of Hydrogen Energy , 2009 , 34 ( 4 ): 1787 - 1800 .

NI Meng . Modeling and parametric simulations of solid oxide fuel cells with methane carbon dioxide reforming [J ] . Energy Conversion and Management , 2013 , 70 : 116 - 129 .

ZHU Pengfei , WU Zhen , YAO Jing , et al . Multi-physics field modeling of biomass gasification syngas fueled solid oxide fuel cell [J ] . Journal of Power Sources , 2021 , 512 : 230470 .

XU Qidong , XIA Lingchao , HE Qijiao , et al . Thermo-electrochemical modelling of high temperature methanol-fuelled solid oxide fuel cells [J ] . Applied Energy , 2021 , 291 : 116832 .

LI Bohan , WANG Chaoyang , LIU Ming , et al . Numerical investigation of the transient performance of a reversible solid oxide cell during the mode switching process [J ] . Energy Conversion and Management , 2022 , 268 : 116048 .

ZAVARUKHIN S G , KUVSHINOV G G . The kinetic model of formation of nanofibrous carbon from CH 4 -H 2 mixture over a high-loaded nickel catalyst with consideration for the catalyst deactivation [J ] . Applied Catalysis: A General , 2004 , 272 ( 1/2 ): 219 - 227 .

SNOECK J W , FROMENT G F , FOWLES M . Steam/CO 2 reforming of methane: Carbon filament formation by the Boudouard reaction and gasification by CO 2 , by H 2 , and by steam: kinetic study [J ] . Industrial & Engineering Chemistry Research , 2002 , 41 ( 17 ): 4252 - 4265 .

KUPECKI J , MOTYLINSKI K , ZURAWSKA A , et al . Numerical analysis of an SOFC stack under loss of oxidant related fault conditions using a dynamic non-adiabatic model [J ] . International Journal of Hydrogen Energy , 2019 , 44 ( 38 ): 21148 - 21161 .

KROMP A , LEONIDE A , TIMMERMANN H , et al . Internal reforming kinetics in SOFC-anodes [J ] . ECS Transactions , 2010 , 28 ( 11 ): 205 - 215 .

ZHANG Kai , WANG Shuai , LI Bowen , et al . Performance of solid oxide fuel cell with chemical looping gasification products as fuel [J ] . International Journal of Hydrogen Energy , 2021 , 46 ( 58 ): 30135 - 30144 .

ANDERSSON M , NAKAJIMA H , KITAHARA T , et al . Comparison of humidified hydrogen and partly pre-reformed natural gas as fuel for solid oxide fuel cells applying computational fluid dynamics [J ] . International Journal of Heat and Mass Transfer , 2014 , 77 : 1008 - 1022 .

ACHENBACH E . Annex II: modelling and evaluation of advanced solid oxide fuel cells: SOFC stack modelling (final report of activity A2) [M ] . Bonn, Germany : International Energy Agency , 1996 .

SAHIBZADA M , STEELE B C H , HELLGARDT K , et al . Intermediate temperature solid oxide fuel cells operated with methanol fuels [J ] . Chemical Engineering Science , 2000 , 55 ( 16 ): 3077 - 3083 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

天然气化学链和燃料电池耦合的氢电联产系统

喷孔直径对高压喷射喷嘴内甲醇流动及喷雾瞬态特性影响的可视化试验研究

喷射模式对高压缩比甲醇发动机爆震特性影响的试验研究

不同喷射策略对甲醇稀燃直喷发动机性能的影响

不同板叠材料热声热机能量转换过程数值模拟研究