考虑温度变化的新能源汽车动力电池荷电状态估计

孙君光; 杜睿; 陈立新; 李慧; 王斌; 赵雪茹; 董秀辉

doi:10.7652/xjtuxb202411004

您当前的位置：

首页 >

文章列表页 >

考虑温度变化的新能源汽车动力电池荷电状态估计

专题电动车辆先进电池管理 | 更新时间：2025-07-25

- 考虑温度变化的新能源汽车动力电池荷电状态估计
- State of Charge Estimation for Power Batteries in New Energy Vehicles Considering Temperature Fluctuations
- 西安交通大学学报 2024年58卷第11期页码：39-51
- 作者机构：
  
  1. 工业产品环境适应性全国重点实验室,广州,510663
  2. 中国电器科学研究院股份有限公司,广州,510663
  3. 西安交通大学机械工程学院,西安,710049
- 作者简介：
  
  : 2024-07-01。作者简介: 孙君光(1976—),男,教授级高级工程师
  王斌(通信作者),男,副研究员,硕士生导师。基金项目: 陕西省重点研发计划资助项目(2023-YBGY-376)
- 基金信息：
  
  : 2024-07-01。作者简介: 孙君光(1976—),男,教授级高级工程师;王斌(通信作者),男,副研究员,硕士生导师。基金项目: 陕西省重点研发计划资助项目(2023-YBGY-376);工业产品环境适应性全国重点实验室开放基金资助项目(2024EASKJ-006)。
- DOI：10.7652/xjtuxb202411004
  中图分类号： TM912
- 纸质出版：2024
- 稿件说明：
移动端阅览
孙君光, 杜睿, 陈立新, 等. 考虑温度变化的新能源汽车动力电池荷电状态估计[J]. 西安交通大学学报, 2024,58(11):39-51.

SUN Junguang, DU Rui, CHEN Lixin, et al. State of Charge Estimation for Power Batteries in New Energy Vehicles Considering Temperature Fluctuations[J]. 2024, 58(11): 39-51.
孙君光, 杜睿, 陈立新, 等. 考虑温度变化的新能源汽车动力电池荷电状态估计[J]. 西安交通大学学报, 2024,58(11):39-51. DOI： 10.7652/xjtuxb202411004.

SUN Junguang, DU Rui, CHEN Lixin, et al. State of Charge Estimation for Power Batteries in New Energy Vehicles Considering Temperature Fluctuations[J]. 2024, 58(11): 39-51. DOI： 10.7652/xjtuxb202411004.

摘要

针对温度变化应用场景下新能源汽车动力电池荷电状态(SOC)估计不精确问题

提出了一种基于神经网络和无迹卡尔曼滤波修正的电池SOC估计方法。首先

考虑温度变化影响建立动态参数的Thevenin等效电路模型。分析温度变化条件下的电池开路电压变化特性

确定电池SOC与开路电压之间的对应关系。同时

分析温度变化条件下的电池容量变化特性

采用神经网络训练电池容量随温度变化的神经网络温度因子。进一步

通过带遗忘因子的递推最小二乘法辨识模型动态参数。在此基础上

利用神经网络温度因子和无迹卡尔曼滤波实时修正以实现温度变化条件下的精确SOC估计。实验结果表明:相比于传统的电池SOC估计方法

考虑温度变化的电池SOC估计方法可以显著提高SOC估计精度

在-15 ℃低温环境下

所提方法使SOC估计精度提高了2.77%。

Abstract

To address the issue of inaccurate state of charge(SOC)estimation for power batteries in new energy vehicles in scenarios involving temperature variations

a modified battery SOC estimation method based on neural network and unscented Kalman filter(UKF)is proposed. Initially

a Thevenin equivalent circuit model with dynamic parameters is established

taking into account the effects of temperature fluctuations. The characteristics of changes in battery open-circuit voltage(OCV)under varying temperature conditions are examined to establish the relationship between battery SOC and OCV. Additionally

the alterations in battery capacity under temperature variations are analyzed. A neural network is employed to train the neural network temperature factor for battery capacity reduction corresponding to temperature changes. Furthermore

the dynamic model parameters are identified using the recursive least squares algorithm with a forgetting factor. Subsequently

the neural network temperature factor and the UKF are utilized for real-time adjustments to ensure precise SOC estimation under changing temperature conditions. The results demonstrate that the battery SOC estimation method considering temperature variations significantly enhances SOC estimation accuracy compared to traditional methods. In a low-temperature environment of -15 ℃

the proposed method enhances SOC estimation accuracy by 2.77%.

关键词

Keywords

references

ZHANG Fujing, OBEID E, BOU NADER W, et al. Well-to-wheel analysis of natural gas fuel for hybrid truck applications [J]. Energy Conversion and Management, 2021, 240: 114271.

WANG Qun, ZHANG Ruixin, LÜ Shuaikang, et al. Open-pit mine truck fuel consumption pattern and application based on multi-dimensional features and XGBoost [J]. Sustainable Energy Technologies and Assessments, 2021, 43: 100977.

续丹, 毛景禄, 王斌, 等. 分布式电池电源模块储能系统的荷电状态均衡控制 [J]. 西安交通大学学报, 2019, 53(10): 79-85.

XU Dan, MAO Jinglu, WANG Bin, et al. A balance control scheme of SOC for power module energy storage systems with distributed batteries [J]. Journal of Xi'an Jiaotong University, 2019, 53(10): 79-85.

WANG Yujie, ZHANG Xingchen, CHEN Zonghai. Low temperature preheating techniques for Lithium-ion batteries: recent advances and future challenges [J]. Applied Energy, 2022, 313: 118832.

周维, 刘鸿远, 徐彪, 等. 功率分流式混合动力矿用自卸车预测性等效燃油消耗最小控制策略研究 [J]. 机械工程学报, 2021, 57(2): 200-209.

ZHOU Wei, LIU Hongyuan, XU Biao, et al. Predictive equivalent consumption minimization strategy for power split hybrid electric mining truck [J]. Journal of Mechanical Engineering, 2021, 57(2): 200-209.

SUDARSHAN M, SEROV A, JONES C, et al. Data-driven autoencoder neural network for onboard BMS lithium-ion battery degradation prediction [J]. Journal of Energy Storage, 2024, 82: 110575.

CUI Zhenhua, KANG Le, LI Liwei, et al. A combined state-of-charge estimation method for lithium-ion battery using an improved BGRU network and UKF [J]. Energy, 2022, 259: 124933.

王子毅, 朱承治, 周杨林, 等. 基于动态可重构电池网络的OCV-SOC在线估计 [J]. 中国电机工程学报, 2022, 42(8): 2919-2928.

WANG Ziyi, ZHU Chengzhi, ZHOU Yanglin, et al. OCV-SOC estimation based on dynamic reconfigurable battery network [J]. Proceedings of the CSEE, 2022, 42(8): 2919-2928.

BIAN Xiaolei, WEI Zhongbao, LI Weihan, et al. State-of-health estimation of lithium-ion batteries by fusing an open circuit voltage model and incremental capacity analysis [J]. IEEE Transactions on Power Electronics, 2022, 37(2): 2226-2236.

XU Liqianun, WU Feng, CHEN Renjie, et al. Data-driven-aided strategies in battery lifecycle management: prediction, monitoring, and optimization [J]. Energy Storage Materials, 2023, 59: 102785.

贠祥, 张鑫, 王超, 等. 基于联合参数辨识的粒子群优化扩展粒子滤波的锂电池荷电状态估计 [J]. 电工技术学报, 2024, 39(2): 595-606.

YUN Xiang, ZHANG Xin, WANG Chao, et al. State of charge estimation of li-ion battery using particle swarm optimization extended Kalman particle filter based on joint parameter identification [J]. Transactions of China Electrotechnical Society, 2024, 39(2): 595-606.

AHMADZADEH O, WANG Yan, SOUDBAKHSH D. A data-driven framework for learning governing equations of li-ion batteries and co-estimating voltage and state-of-charge [J]. Journal of Energy Storage, 2024, 84(Part A): 110743.

SANTONI F, DE ANGELIS A, MOSCHITTA A, et al. A guide to equivalent circuit fitting for impedance analysis and battery state estimation [J]. Journal of Energy Storage, 2024, 82: 110389.

SAH B, KUMAR P. Charger integrated coestimation of parameters and states of battery [J]. IEEE Transactions on Power Electronics, 2023, 38(7): 7923-7932.

戈斌, 罗阳, 李家玮, 等. 风光互补式电动汽车充电站储能锂电池的实时状态估计 [J]. 西安交通大学学报, 2023, 57(1): 55-65.

GE Bin, LUO Yang, LI Jiawei, et al. Real-time state estimation of lithium batteries used for energy storage in electric vehicle charging stations with wind-solar complementary power system [J]. Journal of Xi'an Jiaotong University, 2023, 57(1): 55-65.

BELTRAN H, AYUSO P, VICENTE N, et al. Equivalent circuit definition and calendar aging analysis of commercial Li(NixMnyCoz)O2/graphite pouch cells [J]. Journal of Energy Storage, 2022, 52(Part A): 104747.

SAQLI K, BOUCHAREB H, M'SIRDI N K, et al. Lithium-ion battery electro-thermal modelling and internal states co-estimation for electric vehicles [J]. Journal of Energy Storage, 2023, 63: 107072.

XU Xiaodong, TANG Shengjin, REN Huahua, et al. Joint state estimation of lithium-ion batteries combining improved equivalent circuit model with electrochemical mechanism and diffusion process [J]. Journal of Energy Storage, 2022, 56(Part B): 106135.

孙金磊, 邹鑫, 顾浩天, 等. 基于FFRLS-EKF联合算法的锂离子电池荷电状态估计方法 [J]. 汽车工程, 2022, 44(4): 505-513.

SUN Jinlei, ZOU Xin, GU Haotian, et al. State of charge estimation for lithium-ion battery based on FFRLS-EKF joint algorithm [J]. Automotive Engineering, 2022, 44(4): 505-513.

YU Quanqing, NIE Yuwei, LIU Shizhuo, et al. State of health estimation method for lithium-ion batteries based on multiple dynamic operating conditions [J]. Journal of Power Sources, 2023, 582: 233541.

XIA Lili, WANG Shunli, YU Chunmei, et al. Joint estimation of the state-of-energy and state-of-charge of lithium-ion batteries under a wide temperature range based on the fusion modeling and online parameter prediction [J]. Journal of Energy Storage, 2022, 52(Part C): 105010.

余杰, 廖思阳, 徐箭, 等. 考虑环境温度的磷酸铁锂电池SOC实时修正及频率控制方法 [J]. 电工技术学报, 2023, 38(17): 4564-4573.

YU Jie, LIAO Siyang, XU Jian, et al. Real-time SOC correction and frequency control method for LFP batteries considering ambient temperature [J]. Transactions of China Electrotechnical Society, 2023, 38(17): 4564-4573.

ZHANG Nan, DENG Tao, ZHANG Shuoqing, et al. Critical review on low-temperature li-ion/metal batteries [J]. Advanced Materials, 2022, 34(15): 2107899.

ZHANG Wei, LI Yuqing, ZHENG Caigui, et al. Surface urban heat island effect and its driving factors for all the cities in China: based on a new batch processing method [J]. Ecological Indicators, 2023, 146: 109818.

LIANG Huiwen, YANG Yun, HUI S Y R. Improvement of lithium-ion battery charging from the state-of-the-art industrial JEITA guidelines to a hybrid temperature-regulated current control [J]. IEEE Transactions on Power Electronics, 2022, 37(6): 6412-6423.

申江卫, 高承志, 舒星, 等. 基于迁移模型的锂离子电池宽温度全寿命SOC与可用容量联合估计 [J]. 电工技术学报, 2023, 38(11): 3052-3063.

SHEN Jiangwei, GAO Chengzhi, SHU Xing, et al. Joint estimation of SOC and usable capacity of lithium-ion battery with wide temperature and full life based on migration model [J]. Transactions of China Electrotechnical Society, 2023, 38(11): 3052-3063.

FENG Fei, TENG Sangli, LIU Kailong, et al. Co-estimation of lithium-ion battery state of charge and state of temperature based on a hybrid electrochemical-thermal-neural-network model [J]. Journal of Power Sources, 2020, 455: 227935.

LIN Jiayuan, LIU Xinhua, LI Shen, et al. A review on recent progress, challenges and perspective of battery thermal management system [J]. International Journal of Heat and Mass Transfer, 2021, 167: 120834.

MOULIK B, DUBEY A K, ALI A M. A battery modeling technique based on fusion of hybrid and adaptive algorithms for real-time applications in pure EVs [J]. IEEE Transactions on Intelligent Transportation Systems, 2023, 24(3): 2760-2771.

ZHANG Feng, ZHI Hui, ZHOU Puzhe, et al. State of charge estimation of li-ion battery for underwater vehicles based on EKF-RELM under temperature-varying conditions [J]. Applied Ocean Research, 2021, 114: 102802.

YANG Haixu, HONG Jichao, LIANG Fengwei, et al. Machine learning-based state of health prediction for battery systems in real-world electric vehicles [J]. Journal of Energy Storage, 2023, 66: 107426.

陈泽宇, 熊瑞, 李世杰, 等. 电动载运工具锂离子电池低温极速加热方法研究 [J]. 机械工程学报, 2021, 57(4): 113-120.

CHEN Zeyu, XIONG Rui, LI Shijie, et al. Extremely fast heating method of the lithium-ion battery at cold climate for electric vehicle [J]. Journal of Mechanical Engineering, 2021, 57(4): 113-120.

ZHANG Chuanwei, HUANG Jing, SUN Weixin, et al. Research on liquid preheating performance for battery thermal management of electric vehicles at low temperature [J]. Journal of Energy Storage, 2022, 55(Part B): 105497.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

新能源汽车热管理系统协同优化策略

相变冷却换热器动态热响应降阶预测方法研究

采用动力学模态分解和长短期记忆网络的压缩空气储气装置流场动态预测方法

高超声速飞行器干扰补偿与解耦最优反步控制策略

隧道内燃料电池汽车氢气泄漏扩散特性及影响因素