蒸汽射流直接接触凝结的界面及声压特性

徐强; 洪奥越; 李翔宇; 蒋帅之; 郭烈锦

doi:10.7652/xjtuxb202409004

您当前的位置：

首页 >

文章列表页 >

蒸汽射流直接接触凝结的界面及声压特性

—————————————————————— | 更新时间：2025-07-28

- 蒸汽射流直接接触凝结的界面及声压特性
- Study on Interface and Sound Pressure Characteristics of Direct Contact Condensation of a Steam Jet
- 西安交通大学学报 2024年58卷第9期页码：30-37
- 作者机构：
  
  西安交通大学动力工程多相流国家重点实验室,西安,710049
- 作者简介：
  
  : 2024-02-07。作者简介: 徐强(1986—),男,副教授,博士生导师。基金项目: 国家自然科学基金资助项目(52076175)。
- 基金信息：
  
  : 2024-02-07。作者简介: 徐强(1986—),男,副教授,博士生导师。基金项目: 国家自然科学基金资助项目(52076175)。
- DOI：10.7652/xjtuxb202409004
  中图分类号： O359
- 网络首发：2024-09-10，
  
  纸质出版：2024
- 稿件说明：
移动端阅览
徐强, 洪奥越, 李翔宇, 等. 蒸汽射流直接接触凝结的界面及声压特性[J]. 西安交通大学学报, 2024,58(9):30-37.

XU Qiang, HONG Aoyue, LI Xiangyu, et al. Study on Interface and Sound Pressure Characteristics of Direct Contact Condensation of a Steam Jet[J]. 2024, 58(9): 30-37.
徐强, 洪奥越, 李翔宇, 等. 蒸汽射流直接接触凝结的界面及声压特性[J]. 西安交通大学学报, 2024,58(9):30-37. DOI： 10.7652/xjtuxb202409004.

XU Qiang, HONG Aoyue, LI Xiangyu, et al. Study on Interface and Sound Pressure Characteristics of Direct Contact Condensation of a Steam Jet[J]. 2024, 58(9): 30-37. DOI： 10.7652/xjtuxb202409004.

摘要

蒸汽射流在液体中的直接接触凝结引发的剧烈界面振荡及声压振荡

可能导致工业管道系统振动甚至失效

采用高速摄像机与高频水听器

捕捉了射流的界面演化行为及其诱导的声压。研究了3种典型凝结流型下射流界面的径向、轴向振荡与声压振荡特性

并阐明声压振荡产生机理。研究发现:声压波动的概率密度函数在间歇流型下呈左偏单峰分布

在界面振荡流型下呈双峰分布

而在稳定流型下呈对称单峰分布; 随蒸汽质量流速升高

无量纲径向、轴向界面振荡强度及声压振荡强度整体呈下降趋势

表现出极强的相关性。建立了基于声压参数的射流喷射长度预测模型

预测值与实验值的误差在±1%内。概率密度及相关性分析结果表明

蒸汽射流凝结的声压振荡是由其界面振荡引起的。

Abstract

Direct contact condensation of a steam jet in flowing water in the pipe will cause intense interface oscillations and sound pressure oscillations. In this paper

a high-speed camera and a high-frequency hydrophone is used to capture the evolution of the jet interface and the induced sound pressure. The radial and axial oscillations and sound pressure oscillations of the jet interface under three typical condensation regimes is studied. Probability density function of sound pressure fluctuation shows a left-skewed unimodal distribution under the Chugging regime

a bimodal distribution under the Oscil-Ⅰ condensation regime

and a symmetrical unimodal distribution under the Stable regime. The intensities of the interface oscillation and sound pressure oscillation decrease as the steam mass flux increases

indicating a strong correlation. A jet penetration length prediction model based on the sound pressure parameter is established

and the error between the predicted value and the experimental value is within ±1%. Probability density and correlation analysis provide quantitative confirmation that the sound pressure oscillation of steam jet condensation is caused by its interface oscillations.

关键词

Keywords

references

武心壮, 邱斌斌, 种道彤, 等. 单喷嘴蒸汽射流凝结引起的压力振荡研究 [J]. 西安交通大学学报, 2014, 48(1): 48-52.

WU Xinzhuang, QIU Binbin, CHONG Daotong, et al. Pressure oscillation induced by steam jet condensation in water through a nozzle [J]. Journal of Xi'an Jiaotong University, 2014, 48(1): 48-52.

刘光耀, 严俊杰, 潘冬冬, 等. 超音速蒸汽射流气羽形状及压力分布的实验研究 [J]. 工程热物理学报, 2010, 31(5): 781-784.

LIU Guangyao, YAN Junjie, PAN Dongdong, et al. Research on the steam plume shape and pressure fields of supersonic steam jet in subcooled water [J]. Journal of Engineering Thermophysics, 2010, 31(5): 781-784.

李海波, 田茂诚, 屈晓航. 不凝气体对蒸汽射流冷凝影响的数值研究 [J]. 化工学报, 2020, 71(S2): 135-141.

LI Haibo, TIAN Maocheng, QU Xiaohang. Numerical investigation of influence of non-condensable gas on steam jet condensation [J]. CIESC Journal, 2020, 71(S2): 135-141.

王方年, 秦欢, 陈薇, 等. 过冷水中超音速蒸汽射流形状特征及冷凝传热 [J]. 动力工程学报, 2017, 37(11): 918-924.

WANG Fangnian, QIN Huan, CHEN Wei, et al. Shape feature and condensation heat transfer of supersonic steam jet in subcooled water [J]. Journal of Chinese Society of Power Engineering, 2017, 37(11): 918-924.

CHAN C K, LEE C K B. A regime map for direct contact condensation [J]. International Journal of Multiphase Flow, 1982, 8(1): 11-20.

WEILAND C, VLACHOS P P. Round gas jets submerged in water [J]. International Journal of Multiphase Flow, 2013, 48: 46-57.

KHAN A, SANAULLAH K, TAKRIFF M S, et al. Pressure stresses generated due to supersonic steam jet induced hydrodynamic instabilities [J]. Chemical Engineering Science, 2016, 146: 44-63.

XU Qiang, YE Shuyan, CHEN Yanshuang, et al. Condensation regime diagram for supersonic and subsonic steam jet condensation in water flow in a vertical pipe [J]. Applied Thermal Engineering, 2018, 130: 62-73.

XU Qiang, GUO Liejin, CHANG Liang. Mechanisms of pressure oscillation in steam jet condensation in water flow in a vertical pipe [J]. International Journal of Heat and Mass Transfer, 2017, 110: 643-656.

CHO S, CHUN S Y, BAEK W P, et al. Effect of multiple holes on the performance of sparger during direct contact condensation of steam [J]. Experimental Thermal and Fluid Science, 2004, 28(6): 629-638.

HONG S J, PARK G C, CHO S, et al. Condensation dynamics of submerged steam jet in subcooled water [J]. International Journal of Multiphase Flow, 2012, 39: 66-77.

XU Qiang, LIU Weizhi, LI Wensheng, et al. Experimental investigation on interfacial behavior and its associated pressure oscillation in steam jet condensation in subcooled water flow [J]. International Journal of Heat and Mass Transfer, 2019, 145: 118779.

TANG Jiguo, YAN Changqi, SUN Licheng. Feature of acoustic sound signals involved in vapor bubble condensation and its application in identification of condensation regimes [J]. Chemical Engineering Science, 2015, 137: 384-397.

DEANE G, CZERSKI H. The acoustic excitation mechanism of bubbles released from a nozzle [J]. The Journal of the Acoustical Society of America, 2008, 123(S5): 3558.

CHICHARRO R, VAZQUEZ A. The acoustic signature of gas bubbles generated in a liquid cross-flow [J]. Experimental Thermal and Fluid Science, 2014, 55: 221-227.

MANASSEH R, RIBOUX G, RISSO F. Sound generation on bubble coalescence following detachment [J]. International Journal of Multiphase Flow, 2008, 34(10): 938-949.

FEUILLADE C. Acoustically coupled gas bubbles in fluids: time-domain phenomena [J]. The Journal of the Acoustical Society of America, 2001, 109(6): 2606-2615.

AJBAR A, AL-MASRY W, ALI E. Prediction of flow regimes transitions in bubble columns using passive acoustic measurements [J]. Chemical Engineering and Processing: Process Intensification, 2009, 48(1): 101-110.

AL-MASRY W A, ALI E M, AQEEL Y M. Effect of antifoam agents on bubble characteristics in bubble columns based on acoustic sound measurements [J]. Chemical Engineering Science, 2006, 61(11): 3610-3622.

AL-MASRY W A, ALI E M, AL-KALBANI M N. Prediction of regime transitions in bubble columns using acoustic and differential pressure signals [J]. Chemical Engineering Journal, 2007, 133(1/3): 139-149.

岳晓宇, 王禄涛, 种道彤, 等. 不稳定蒸汽射流凝结振荡实验研究 [J]. 动力工程学报, 2019, 39(11): 900-905.

YUE Xiaoyu, WANG Lutao, CHONG Daotong, et al. Experimental investigation on condensation oscillation characteristics of unstable steam jet [J]. Journal of Chinese Society of Power Engineering, 2019, 39(11): 900-905.

HONG Aoyue, XU Qiang, JIANG Shuaizhi, et al. Experimental study of interface behavior and sound pressure oscillation of direct contact condensation of a steam jet in flowing water [J]. Experimental Thermal and Fluid Science, 2024, 150: 111054.

CLERX N, VAN DEURZEN L G M, PECENKO A, et al. Temperature fields induced by direct contact condensation of steam in a cross-flow in a channel [J]. Heat and Mass Transfer, 2011, 47(8): 981-990.

ZHAO Quanbin, CHONG Daotong, CHEN Weixiong, et al. Review: steam cavity characteristics of steam submerged jet condensation at SC regime [J]. Progress in Nuclear Energy, 2020, 130: 103560.

邱斌斌, 赵全斌, 赵伟月, 等. 蒸汽射流压力振荡主频分析及强度特性 [J]. 化工学报, 2014, 65(S1): 39-43.

QIU Binbin, ZHAO Quanbin, ZHAO Weiyue, et al. Frequency analysis and amplitude characteristics of pressure oscillation for steam jet [J]. CIESC Journal, 2014, 65(S1): 39-43.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

张角凹坑气膜孔对双层壁气膜冷却特性的影响

语义区分和子图整合驱动的知识图谱表示学习方法

采用机器学习的大规模并行程序I/O性能建模与预测方法

面向高海拔空冷发电机防晕性能演化规律的电热耦合研究

融合物理信息与深度算子网络的变压器绕组热-流场快速计算方法