乙醇液滴冲击过冷水平壁面的铺展行为实验研究

张泽; 杨松; 刘秀芳; 赖天伟; 侯予

doi:10.7652/xjtuxb202401011

您当前的位置：

首页 >

文章列表页 >

乙醇液滴冲击过冷水平壁面的铺展行为实验研究

更新时间：2025-05-13

- 乙醇液滴冲击过冷水平壁面的铺展行为实验研究
- Spreading Behavior of an Ethanol Droplet Impacts on a Supercooled Substrate
- 西安交通大学学报 2024年58卷第1期页码：119-125
- 作者机构：
  
  1. 西安交通大学能源与动力工程学院,西安,710049
  2. 西安交通大学深低温技术与装备教育部重点实验室,西安,710049
- 作者简介：
  
  : 2023-07-14。作者简介: 张泽(1989—),男,助理教授。基金项目: 国家科技重大专项资助项目(J2019-Ⅲ-0010-0054)
- 基金信息：
  
  : 2023-07-14。作者简介: 张泽(1989—),男,助理教授。基金项目: 国家科技重大专项资助项目(J2019-Ⅲ-0010-0054);国家自然科学基金资助项目(52076164);陕西高校青年创新团队资助项目。
- DOI：10.7652/xjtuxb202401011
  中图分类号： O353.4
- 网络首发：2024-01-10，
  
  纸质出版：2024
- 稿件说明：
移动端阅览
张泽, 杨松, 刘秀芳, 等. 乙醇液滴冲击过冷水平壁面的铺展行为实验研究[J]. 西安交通大学学报, 2024,58(1):119-125.

ZHANG Ze, YANG Song, LIU Xiufang, et al. Spreading Behavior of an Ethanol Droplet Impacts on a Supercooled Substrate[J]. 2024, 58(1): 119-125.
张泽, 杨松, 刘秀芳, 等. 乙醇液滴冲击过冷水平壁面的铺展行为实验研究[J]. 西安交通大学学报, 2024,58(1):119-125. DOI： 10.7652/xjtuxb202401011.

ZHANG Ze, YANG Song, LIU Xiufang, et al. Spreading Behavior of an Ethanol Droplet Impacts on a Supercooled Substrate[J]. 2024, 58(1): 119-125. DOI： 10.7652/xjtuxb202401011.

摘要

为探究表面张力对液滴冲击过冷水平壁面铺展动力学行为的影响

搭建了可视化实验系统

探究了乙醇液滴冲击过冷水平壁面的铺展动力学行为

分析了水平壁面过冷度对低表面张力液滴冲击铺展动力学行为的影响。实验中

采用亲水硅水平壁面及较小的冲击速度以观测乙醇液滴冲击过冷水平壁面的铺展动力学行为。此外

还比较了不同的最大铺展因子和最大铺展时间的典型模型对乙醇液滴冲击过冷水平壁面铺展动力学因子的适用性。结果表明:乙醇液滴冲击过冷亲水水平壁面的铺展动力学行为分为飞溅、铺展、稳定3个阶段; 最大铺展时间随水平壁面过冷度的增大而减小; 水平壁面过冷度对最大铺展因子的影响是非单调的

在水平壁面过冷度较低时

最大内部铺展因子减小起主要作用

在水平壁面过冷度较高时

由于瑞利-泰勒不稳定性的增强

无量纲手指状突起增大起主要作用

二者共同作用造成了非单调变化; 现有模型对于最大铺展时间的预测效果较好

相对平均偏差为6.05%

而对最大铺展因子的预测效果较差。

Abstract

This study aims to investigate the effect of surface tension on the spreading dynamics of a droplet impacting a supercooled substrate. To accomplish this

a visualization experimental system is established. The influence of substrate supercooling on the spreading dynamics of low surface tension droplet is analyzed. In the experiment

hydrophilic silicon substrate and a smaller impact velocity are used to observe the spreading dynamics of an ethanol droplet impacting the supercooled substrate. In addition

this study compares the applicability of typical models with different maximum spreading factor and maximum spreading time to the spreading dynamic factors of an ethanol droplet impacting supercooled substrate. The results demonstrate that the spreading dynamics of an ethanol droplet impacting the supercooled hydrophilic substrate can be divided into three stages: splash

spreading

and stability. The maximum spreading time decreases with an increase in substrate supercooling. Moreover

the influence of substrate supercooling on the maximum spreading factor is non-monotonic. At low substrate supercooling

the reduction of the maximum internal spreading factor plays a dominant role. Conversely

at high substrate supercooling levels

the enhancement of Rayleigh-Taylor instability leads to an increase in the “fingering-like” protrusion of the infinite chain plays a major role. The combined effect of the two causes non-monotonic changes. The existing models have good predictive performance for the maximum spreading time

with a relative mean error of 6.05%. However

their predictive accuracy for the maximum spreading factor is poor.

关键词

Keywords

references

YANG Song, HOU Yu, SHANG Yuheng, et al. BPNN and CNN-based AI modeling of spreading and icing pattern of a water droplet impact on a supercooled surface [J]. AIP Advances, 2022, 12(4): 045209.

YANG Song, HOU Yu, ZHOU Dongdong, et al. Non-monotonic effect of ethanol concentration on the spreading of an ethanol-water binary droplet impact on a supercooled surface [J]. International Journal of Thermal Sciences, 2023, 183: 107828.

ZHOU Dongdong, LIU Xiufang, YANG Song, et al. Collision dynamics of two liquid nitrogen droplets under a low-temperature condition [J]. Cryogenics, 2022, 124: 103478.

ZHOU Dongdong, LIU Xiufang, YANG Song, et al. Intense deformation and fragmentation of two droplet collision at high Weber numbers [J]. Colloids and Surfaces: A Physicochemical and Engineering Aspects, 2022, 655: 130171.

陆军军, 陈雪莉, 曹显奎, 等. 液滴撞击平板的铺展特征 [J]. 化学反应工程与工艺, 2007, 23(6): 505-511.

LU Junjun, CHEN Xueli, CAO Xiankui, et al. Characteristic phenomenon and analysis of a single liquid droplet impacting on dry surfaces [J]. Chemical Reaction Engineering and Technology, 2007, 23(6): 505-511.

SHANG Yuheng, LIU Xiufang, BAI Bofeng, et al. Central-pointy to central-concave icing transition of an impact droplet by increasing surface subcooling [J]. International Communications in Heat and Mass Transfer, 2019, 108: 104326.

SHAO Xiaoxiao, HOU Yu, ZHONG Xin. Modulation of evaporation-affected crystal motion in a drying droplet by saline and surfactant concentrations [J]. Colloids and Surfaces: A Physicochemical and Engineering Aspects, 2021, 623: 126701.

KULKARNI A P, MEGARITIS T, GANIPPA L C. Insights on the morphology of air-assisted breakup of urea-water-solution sprays for varying surface tension [J]. International Journal of Multiphase Flow, 2020, 133: 103448.

LIN Shiji, ZHAO Binyu, ZOU Song, et al. Impact of viscous droplets on different wettable surfaces: impact phenomena, the maximum spreading factor, spreading time and post-impact oscillation [J]. Journal of Colloid and Interface Science, 2018, 516: 86-97.

ZHAO Binyu, WANG Xiang, ZHANG Kai, et al. Impact of viscous droplets on superamphiphobic surfaces [J]. Langmuir, 2017, 33(1): 144-151.

DING Bin, WANG Hong, ZHU Xun, et al. How supercooled superhydrophobic surfaces affect dynamic behaviors of impacting water droplets? [J]. International Journal of Heat and Mass Transfer, 2018, 124: 1025-1032.

QIAN J, LAW C K. Regimes of coalescence and separation in droplet collision [J]. Journal of Fluid Mechanics, 1997, 331: 59-80.

CASTILLO J E, HUANG Yanbo, PAN Zhenhai, et al. Quantifying the pathways of latent heat dissipation during droplet freezing on cooled substrates [J]. International Journal of Heat and Mass Transfer, 2021, 164: 120608.

LIU Xin, MIN Jingchun, ZHANG Xuan. Dynamic behavior and maximum spreading of droplets impacting concave spheres [J]. Physics of Fluids, 2020, 32(9): 092109.

ZHANG Xuan, LIU Xin, WU Xiaomin, et al. Impacting-freezing dynamics of a supercooled water droplet on a cold surface: rebound and adhesion [J]. International Journal of Heat and Mass Transfer, 2020, 158: 119997.

YANG Song, HOU Yu, ZHOU Dongdong, et al. Effects of solution concentration and surface supercooling on the spreading characteristics of an impact binary droplet [J]. International Communications in Heat and Mass Transfer, 2023, 147: 106927.

SHANG Yuheng, BAI Bofeng, HOU Yu, et al. Alteration of freezing paradigms of an impact water droplet on different cold surfaces [J]. International Journal of Heat and Mass Transfer, 2022, 183(Part A): 122177.

姚一娜, 刘呈, 李聪, 等. 液滴撞击超疏水冷表面的反弹/黏附特性对比研究 [J]. 中国安全生产科学技术, 2021, 17(1): 31-35.

YAO Yina, LIU Cheng, LI Cong, et al. Comparative study on rebound/adhesion characteristics of droplets impacting superhydrophobic cold surface [J]. Journal of Safety Science and Technology, 2021, 17(1): 31-35.

朱程香, 王珑, 孙志国, 等. 风力机叶片翼型的结冰数值模拟研究 [J]. 空气动力学学报, 2011, 29(4): 522-528.

ZHU Chengxiang, WANG Long, SUN Zhiguo, et al. Numerical study of wind turbine blade airfoil ice accretion [J]. Acta Aerodynamica Sinica, 2011, 29(4): 522-528.

胡良权, 陈进格, 沈昕, 等. 结冰对风力机载荷的影响 [J]. 上海交通大学学报, 2018, 52(8): 904-909.

HU Liangquan, CHEN Jinge, SHEN Xin, et al. Load of wind turbine affected by icing [J]. Journal of Shanghai Jiaotong University, 2018, 52(8): 904-909.

赵亚鸽, 林世玑, 赵彬钰, 等. 微结构超疏水表面的制备及其对液滴撞击动力学的影响 [J]. 微纳电子技术, 2020, 57(8): 643-649.ZHAO Yage, LIN Shiji, ZHAO Binyu, et al. Preparation of the micro-structured superhydrophobic surface and influence on droplet impact dynamics [J]. Micronanoelectronic Technology, 2020, 57(8): 643-649.

尚宇恒, 白博峰, 侯予, 等. 液滴撞击过冷壁面的结冰特性实验研究 [J]. 西安交通大学学报, 2021, 55(10): 144-149.

SHANG Yuheng, BAI Bofeng, HOU Yu, et al. Experimental research for freezing characteristics of droplets impacting on supercooled surface [J]. Journal of Xi'an Jiaotong University, 2021, 55(10): 144-149.

强伟, 侯予, 薛绒, 等. 氮液滴碰撞不同浸润性壁面特性研究 [J]. 西安交通大学学报, 2021, 55(7): 151-157.

QIANG Wei, HOU Yu, XUE Rong, et al. Research on the behaviors of nitrogen droplets impacting surfaces with different wettabilities [J]. Journal of Xi'an Jiaotong University, 2021, 55(7): 151-157.

SHANG Yuheng, ZHANG Yuhui, HOU Yu, et al. Effects of surface subcooling on the spreading dynamics of an impact water droplet [J]. Physics of Fluids, 2020, 32(12): 123309.

BAYER I S, MEGARIDIS C M. Contact angle dynamics in droplets impacting on flat surfaces with different wetting characteristics [J]. Journal of Fluid Mechanics, 2006, 558: 415-449.

SEN S, VAIKUNTANATHAN V, SIVAKUMAR D. Experimental investigation of biofuel drop impact on stainless steel surface [J]. Experimental Thermal and Fluid Science, 2014, 54: 38-46.

ROISMAN I V. Inertia dominated drop collisions: Ⅱ an analytical solution of the Navier-Stokes equations for a spreading viscous film [J]. Physics of Fluids, 2009, 21(5): 052104.

WILDEMAN S, VISSER C W, SUN Chao, et al. On the spreading of impacting drops [J]. Journal of Fluid Mechanics, 2016, 805: 636-655.

HUANG Haimeng, CHEN Xiaopeng. Energetic analysis of drop's maximum spreading on solid surface with low impact speed [J]. Physics of Fluids, 2018, 30(2): 022106.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

相对浸润性对双元液滴碰撞影响的数值研究

含油制冷剂R134a饱和液相运动黏度及表面张力实验测量

甲基九氟丁醚的液相密度和表面张力的实验研究

表面自由能模型的改进及液滴浸润数值研究

HFE7000、HFE7200的表面张力和黏度实验研究