半高叶片扩压器对离心压缩机流动性能影响的数值研究

张国路迢; 王江峰; 娄聚伟; 郭雨旻; 赵攀

doi:10.7652/xjtuxb202310009

您当前的位置：

首页 >

文章列表页 >

半高叶片扩压器对离心压缩机流动性能影响的数值研究

—————————————————————— | 更新时间：2025-05-08

- 半高叶片扩压器对离心压缩机流动性能影响的数值研究
- Numerical Study on the Impact of Half-Vaned Diffuser on Flow Performance of Centrifugal Compressor
- 西安交通大学学报 2023年57卷第10期页码：89-98
- 作者机构：
  
  西安交通大学能源与动力工程学院,西安,710049
- 作者简介：
  
  : 2023-02-26。作者简介: 张国路迢(1997—),男,硕士生
  王江峰(通信作者),男,教授,博士生导师。基金项目: 国家自然科学基金资助项目(51976147)。
- 基金信息：
  
  : 2023-02-26。作者简介: 张国路迢(1997—),男,硕士生;王江峰(通信作者),男,教授,博士生导师。基金项目: 国家自然科学基金资助项目(51976147)。
- DOI：10.7652/xjtuxb202310009
  中图分类号： TK123
- 网络首发：2023-10-10，
  
  纸质出版：2023
- 稿件说明：
移动端阅览
张国路迢, 王江峰, 娄聚伟, 等. 半高叶片扩压器对离心压缩机流动性能影响的数值研究[J]. 西安交通大学学报, 2023,57(10):89-98.

ZHANG Guolutiao, WANG Jiangfeng, LOU Juwei, et al. Numerical Study on the Impact of Half-Vaned Diffuser on Flow Performance of Centrifugal Compressor[J]. 2023, 57(10): 89-98.
张国路迢, 王江峰, 娄聚伟, 等. 半高叶片扩压器对离心压缩机流动性能影响的数值研究[J]. 西安交通大学学报, 2023,57(10):89-98. DOI： 10.7652/xjtuxb202310009.

ZHANG Guolutiao, WANG Jiangfeng, LOU Juwei, et al. Numerical Study on the Impact of Half-Vaned Diffuser on Flow Performance of Centrifugal Compressor[J]. 2023, 57(10): 89-98. DOI： 10.7652/xjtuxb202310009.

摘要

为了分析半高叶片扩压器内的流动机理

进一步提升半高叶片扩压器的工作性能

研究了离心压缩机中不同叶高、位置的半高叶片扩压器内的流动特性

提出了斜半高叶片扩压器

研究了斜半高叶片扩压器在发生旋转失速时流动特性。采用了三维计算流体动力学(CFD)方法对使用不同扩压器的离心压缩机在稳态和瞬态条件下进行了全周全工况数值模拟。研究结果表明:在设计工况下

斜半高叶片扩压器相较于半高叶片扩压器

当安装在轮盘侧时

总静压比提升了3.80%

总静等熵效率提升了2.74%

当安装在轮盖侧时

总静压比、总静等熵效率分别提升了0.82%、2.11%; 旋转失速时的研究表明

斜半高扩压器叶片叶顶间隙流动能够在发生旋转失速时耗散静压波动能量

将扩压器内静压波动从最大约50 kPa降低至了约10 kPa。所提斜半高叶片扩压器作为新型的扩压器类型

性能优于半高叶片扩压器

具备广阔的应用前景

对旋转失速时的流动研究结果能够扩压器叶片叶顶间隙流动研究提供重要参考。

Abstract

In order to analyz the flow mechanism in the half-vaned diffuser and further improve the working performance of the half-vaned diffuser

the research was conducted on the flow characteristics of the half-vaned diffuser in the centrifugal compressor at different blade heights and positions. Based on the research

the tilted half-vaned diffuser was proposed and its flow characteristics in rotating stall were studied. The three-dimensional computational fluid dynamics(CFD)method was used to simulate the whole operation of centrifugal compressors with different diffusers under steady and transient conditions. The results show that compared with the half-vaned diffuser under design conditions

when the tilted half-vaned diffuser is installed on the hub side

the total static pressure ratio and total static isentropic efficiency are increased by 3.80% and 2.74%

respectively

and when installed on the shroud side

the total static pressure ratio and total static isentropic efficiency are increased by 0.82% and 2.11%

respectively. The results show that the tip clearance flow of the tilted half-vaned diffuser can dissipate the energy of static pressure fluctuation in rotating stall

and the fluctuation amplitude of static pressure in diffuser passages can be reduced from about 50 kPa to about 10 kPa. As a new type of diffuser

the tilted half-vaned diffuser proposed in this paper has better performance than the half-vaned diffuser and has a good application prospect. The results in rotating stall conditions can provide an important reference to the flow character of tip clearance of diffuser blade in flow passage.

关键词

Keywords

references

YOSHINAGA Y, KANEKI T, KOBAYASHI H, et al. A study of performance improvement for high specific speed centrifugal compressors by using diffusers with half guide vanes [J]. Journal of Fluids Engineering, 1987, 109(4): 359-366.

陆华伟, 张永超, 康达, 等. 具有叶顶间隙扩压叶栅附面层抽吸研究 [J]. 工程热物理学报, 2016, 37(2): 277-284.

LU Huawei, ZHANG Yongchao, KANG Da, et al. Investigation of boundary layer suction on compressor cascade with tip clearance [J]. Journal of Engineering Thermophysics, 2016, 37(2): 277-284.

高丽敏, 刘思余, 李永增, 等. 扩压叶栅叶顶间隙流动结构研究 [J]. 工程热物理学报, 2020, 41(2): 329-334.

GAO Limin, LIU Siyu, LI Yongzeng, et al. Investigation of the structure of cascade tip clearance flowfield [J]. Journal of Engineering Thermophysics, 2020, 41(2): 329-334.

陆华伟, 杨益, 刘俊, 等. 叶顶间隙影响高负荷扩压叶栅气动性能实验研究 [J]. 工程热物理学报, 2017, 38(3): 509-514.

LU Huawei, YANG Yi, LIU Jun, et al. An experimental investigation on the aerodynamic performance of highly-loaded compressor cascade with different tip clearance [J]. Journal of Engineering Thermophysics, 2017, 38(3): 509-514.

陆华伟, 张永超, 康达, 等. 附面层抽吸对带有叶顶间隙扩压叶栅涡量场影响 [J]. 科学技术与工程, 2015, 15(6): 188-194.

LU Huawei, ZHANG Yongchao, KANG Da, et al. Effects of boundary layer suction on vorticity of compressor cascades with tip clearance [J]. Science Technology and Engineering, 2015, 15(6): 188-194.

ZHU Xiangyuan, LI Guojun, JIANG Wei, et al. Experimental and numerical investigation on application of half vane diffusers for centrifugal pump [J]. International Communications in Heat and Mass Transfer, 2016, 79: 114-127.

SAKAGUCHI D, FUJII T, UEKI H, et al. Control of secondary flow in a low solidity circular cascade diffuser [J]. Journal of Thermal Science, 2012, 21(4): 384-390.

SAKAGUCHI D, TUN M T, MIZOKOSHI K, et al. Flow range enhancement by secondary flow effect in low solidity circular cascade diffusers [J]. Journal of Thermal Science, 2014, 23(4): 391-400.

MA Chao, LI Wenjiao, ZHANG Jianjian. Study of hub slotting and low-solidity combined treatment of diffuser vanes on stability of a centrifugal compressor [J]. Journal of the Brazilian Society of Mechanical Sciences and Engineering, 2021, 43(7): 340.

UBBEN S, NIEHUIS R. Experimental investigation of the diffuser vane clearance effect in a centrifugal compressor stage with adjustable diffuser geometry: part Ⅰ compressor performance analysis [J]. Journal of Turbomachinery, 2015, 137(3): 031003.

UBBEN S, NIEHUIS R. Experimental investigation of the diffuser vane clearance effect in a centrifugal compressor stage with adjustable diffuser geometry: part Ⅱ detailed flow analysis [J]. Journal of Turbomachinery, 2015, 137(3): 031004.

SITARAM N, ISSAC J M. An experimental investigation of a centrifugal compressor with hub vane diffusers [J]. Proceedings of the Institution of Mechanical Engineers: Journal of Power and Energy, 1997, 211(5): 411-427.

LIU Ruitao, XU Zhong. Numerical investigation of a high-speed centrifugal compressor with hub vane diffusers [J]. Proceedings of the Institution of Mechanical Engineers: Journal of Power and Energy, 2004, 218(3): 155-169.

SHIBATA T, YAGI M, NISHIDA H, et al. Performance improvement of a centrifugal compressor stage by increasing degree of reaction and optimizing blade loading of a 3D impeller [J]. Journal of Turbomachinery, 2011, 133(2): 021004.

ANISH S, SITARAM N. Computational investigation of impeller: diffuser interaction in a centrifugal compressor with different types of diffusers [J]. Proceedings of the Institution of Mechanical Engineers: Part A Journal of Power and Energy, 2009, 223(2): 167-178.

ISSAC J M, SITARAM N, GOVARDHAN M. Effect of diffuser vane height and position on the performance of a centrifugal compressor [J]. Proceedings of the Institution of Mechanical Engineers: Journal of Power and Energy, 2004, 218(8): 647-654.

OHTA Y, FUJISAWA N. Unsteady behavior and control of vortices in centrifugal compressor [J]. Journal of Thermal Science, 2014, 23(5): 401-411.

ZOU Wangzhi, HE Xiao, ZHANG Wenchao, et al. Roles of vanes in diffuser on stability of centrifugal compressor [J]. Proceedings of the Institution of Mechanical Engineers: Journal of Aerospace Engineering, 2019, 233(14): 5380-5392.

GRAPOW F, OLASEK K, LIKIEWICZ G, et al. Experimental study of vaneless diffuser rotating stall development and cell-merging phenomena [J]. Journal of Turbomachinery, 2021, 143(5): 051008.

花严红, 李振, 刘兆平. R134a工质微小流量离心三元叶轮数值设计研究 [J]. 煤矿机械, 2015, 36(12): 13-16.

HUA Yanhong, LI Zhen, LIU Zhaoping. Study on numerical design of centrifugal three dimensional impeller of micro flow refrigerant R134a [J]. Coal Mine Machinery, 2015, 36(12): 13-16.[21] 贺晓希, 宫武旗, 邓俊杰, 等. 叶轮叶顶间隙对离心制冷压缩机性能的影响 [J]. 西安交通大学学报, 2019, 53(7): 30-37.

HE Xiaoxi, GONG Wuqi, DENG Junjie, et al. Influence of impeller tip clearance on the performance of centrifugal refrigeration compressor [J]. Journal of Xi'an Jiaotong University, 2019, 53(7): 30-37.

高峰, 潘晓燕, 朱德润. 机载离心式制冷压缩机叶轮级流动仿真研究 [J]. 机械科学与技术, 2019, 38(6): 963-969.

GAO Feng, PAN Xiaoyan, ZHU Derun. Simulating flow in pump impeller of airborne centrifugal refrigeration compressor [J]. Mechanical Science and Technology for Aerospace Engineering,2019, 38(6): 963-969.

SIN J K, KIM K H, KANG S H. The design and performance test of a centrifugal compressor for HFC-134a refrigerant [J]. Korean Journal of Air-Conditioning and Refrigeration Engineering, 2010, 22(3): 139-148.

HAUPT U, ABDELHAMID A N, KAEMMER N, et al. Excitation of blade vibration by flow instability in centrifugal compressors [C]//ASME 1986 International Gas Turbine Conference and Exhibit. New York, NY, USA: ASME, 1986: V001T01A115.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

离心压缩机性能预测中雷诺平均湍流模型的不确定度量化与分析

R1234ze（E）替代R134a对二级压缩循环离心压缩机及制冷性能的影响

液压圆柱滑阀K-K型节流槽流量面积参数模型

离心压缩机级间加气的出口流场特性

基于喘振频域特性的失稳预警技术研究