R1336mzz(Z)及其与多元醇酯类润滑油混合物表面张力实验测量

豆文博; 张钰婧; 王晓坡

doi:10.7652/xjtuxb202308009

您当前的位置：

首页 >

文章列表页 >

R1336mzz(Z)及其与多元醇酯类润滑油混合物表面张力实验测量

能源与动力 | 更新时间：2025-05-08

- R1336mzz(Z)及其与多元醇酯类润滑油混合物表面张力实验测量
- Experimental Measurement of Surface Tension of R1336mzz(Z)and Its Mixtures with Polyolester Lubricant
- 西安交通大学学报 2023年57卷第8期页码：86-91
- 作者机构：
  
  西安交通大学热流科学与工程教育部重点实验室,西安,710049
- 作者简介：
  
  : 2023-02-18。作者简介: 豆文博(1999—),男,硕士生
  王晓坡(通信作者),男,教授,博士生导师。基金项目: 国家自然科学基金重点资助项目(51936009)。
- 基金信息：
  
  : 2023-02-18。作者简介: 豆文博(1999—),男,硕士生;王晓坡(通信作者),男,教授,博士生导师。基金项目: 国家自然科学基金重点资助项目(51936009)。
- DOI：10.7652/xjtuxb202308009
  中图分类号： TK121
- 网络首发：2023-08-10，
  
  纸质出版：2023
- 稿件说明：
移动端阅览
豆文博, 张钰婧, 王晓坡. R1336mzz(Z)及其与多元醇酯类润滑油混合物表面张力实验测量[J]. 西安交通大学学报, 2023,57(8):86-91.

DOU Wenbo, ZHANG Yujing, WANG Xiaopo. Experimental Measurement of Surface Tension of R1336mzz(Z)and Its Mixtures with Polyolester Lubricant[J]. 2023, 57(8): 86-91.
豆文博, 张钰婧, 王晓坡. R1336mzz(Z)及其与多元醇酯类润滑油混合物表面张力实验测量[J]. 西安交通大学学报, 2023,57(8):86-91. DOI： 10.7652/xjtuxb202308009.

DOU Wenbo, ZHANG Yujing, WANG Xiaopo. Experimental Measurement of Surface Tension of R1336mzz(Z)and Its Mixtures with Polyolester Lubricant[J]. 2023, 57(8): 86-91. DOI： 10.7652/xjtuxb202308009.

摘要

为补充新型烯烃类环保制冷工质的表面张力实验数据

为其相变换热及两相流动计算提供可靠的基础物性数据

采用毛细管上升法测量了顺式-1

4-六氟-2-丁烯(R1336mzz(Z))纯质及其与POE润滑油(型号SL-32S)组成的混合物的表面张力。所研究的润滑油质量分数分别为0.130%、0.536%、1.040%

测量的温度范围为243～363 K

表面张力的测量标准不确定度小于0.16 mN·m

-1

。结果表明:润滑油含量越高

混合物表面张力越大; 与纯质表面张力相比

随着温度升高

混合物表面张力增幅逐渐减小。采用经验方程对实验数据进行拟合

结果发现

R1336mzz(Z)及R1336mzz(Z)/SL-32S混合物的表面张力计算值和实验数据的平均绝对偏差分别为0.07 mN·m

-1

和0.14 mN·m

-1

。所得结论可为R1336mzz(Z)应用于各类制冷/热泵系统提供基础的物性数据。

Abstract

To complement the experimental data of the surface tension of new environmentally-friendly olefin refrigerant

and to provide the reliable data for the calculation of phase change heat transfer and two-phase flow

the surface tension of cis-1

4-hexafluoro-2-butene(R1336mzz(Z))and the mixtures with POE lubricant(type: SL-32S)was measured using the differential capillary rise method. The mass fractions of the studied lubricant for the mixtures are 0.130%

0.536%

and 1.040%

respectively. The measuring temperature was from 243 K to

363 K

and the measurement standard uncertainty for the surface tension was less than 0.16 mN·m

-1

. Results show that the surface tension of the mixtures increases with the lubricant concentration. Moreover

the surface tension of the mixtures shows a reduced increase amplitude as the temperature rises

compared with that of pure R1336mzz(Z). The experimental surface tension was correlated as the empirical expression

and the average absolute deviations between the experimental data and the calculated values for the pure R1336mzz(Z)and R1336mzz(Z)/SL-32S mixtures were 0.07 mN·m

-1

and 0.14 mN·m

-1

respectively. The obtained results can provide the essential surface tension data for the further application of R1336mzz(Z)to various types of refrigeration/heat pump systems.

关键词

Keywords

references

MCLINDEN M O, SEETON C J, PEARSON A. New refrigerants and system configurations for vapor-compression refrigeration [J]. Science, 2020, 370(6518): 791-796.

NAIR V. HFO refrigerants: a review of present status and future prospects [J]. International Journal of Refrigeration, 2021, 122: 156-170.

杨梦, 张华, 孟照峰, 等. 新型环保高温工质HFO-1336mzz(Z)的研究进展 [J]. 制冷学报, 2019, 40(6): 46-52, 110.

YANG Meng, ZHANG Hua, MENG Zhaofeng, et al. Research progress of the new environmentally friendly high temperature refrigerant HFO-1336mzz(Z)[J]. Journal of Refrigeration, 2019, 40(6): 46-52, 110.

HUO Erguang, LIU Chao, XIN Liyong, et al. Thermal stability and decomposition mechanism of HFO-1336mzz(Z)as an environmental friendly working fluid: experimental and theoretical study [J]. International Journal of Energy Research, 2019, 43(9): 4630-4643.

黄洁, 张华, 杨梦. 环保工质HFO-1336mzz(Z)/HCFO-1224yd(Z)高温热泵的特性分析 [J]. 制冷技术, 2022, 42(5): 1-6.

HUANG Jie, ZHANG Hua, YANG Meng. Characteristic analysis on high temperature heat pump with environmental protection refrigerant of HFO-1336mzz(Z)/HCFO-1224yd(Z)[J]. Chinese Journal of Refrigeration Technology, 2022, 42(5): 1-6.

韩盼, 李征涛, 廖李平. HFO-1336mzz(Z)在有机朗肯循环系统中的研究进展 [J]. 真空与低温, 2021, 27(2): 171-177.

HAN Pan, LI Zhengtao, LIAO Liping. Research progress of HFO-1336mzz(Z)in organic Rankine cycle system [J]. Vacuum and Cryogenics, 2021, 27(2): 171-177.

WANG Shikuan, GUO Zhikai, HAN Xiaohong, et al. Experimental evaluation on low global warming potential HFO-1336mzz-Z as an alternative to HCFC-123 and HFC-245fa [J]. Journal of Thermal Science and Engineering Applications, 2019, 11(3): 031009.

吴建华, 雷博雯, 陈振华, 等. 丙烷旋转压缩机油池中矿物油和丙烷混合物的黏度测量与溶解度推算 [J]. 西安交通大学学报, 2018, 52(11): 81-85, 92.

WU Jianhua, LEI Bowen, CHEN Zhenhua, et al. Viscosity measurement and solubility calculation of mineral oil and propane(R290)mixture in oil sump of R290 rotary compressor [J]. Journal of Xi'an Jiaotong University, 2018, 52(11): 81-85, 92.

张兴群, 张小艳, 袁秀玲. 混合制冷剂R134a/R600a与矿物油互溶性的实验研究 [J]. 西安交通大学学报, 2009, 43(9): 5-8, 85.

ZHANG Xingqun, ZHANG Xiaoyan, YUAN Xiuling. Experimental study on miscibility of R134a/R600a refrigerant and mineral oil mixture [J]. Journal of Xi'an Jiaotong University, 2009, 43(9): 5-8, 85.

TANAKA K, AKASAKA R, SAKAUE E, et al. Measurements of the critical parameters for cis-1, 1, 1, 4, 4, 4-hexafluoro-2-butene [J]. Journal of Chemical Engineering Data, 2017, 62(3): 1135-1138.

LI Shuhao, XU Liu, LIU Hangtao, et al. Vapor pressure measurements and correlation for cis-1, 1, 1, 4, 4, 4-hexafluoro-2-butene(HFO-1336mzz(Z))[J]. Journal of Chemical Engineering Data, 2020, 65(9): 4223-4229.

TANAKA K, AKASAKA R, SAKAUE E, et al. Thermodynamic properties of cis-1, 1, 1, 4, 4, 4-hexafluoro-2-butene(HFO-1336mzz(Z)): measurements of the pρT property and determinations of vapor pressures, saturated liquid and vapor densities, and critical parameters [J]. Journal of Chemical Engineering Data, 2016, 61(7): 2467-2473.

MCLINDEN M O, AKASAKA R. Thermodynamic properties of cis-1, 1, 1, 4, 4, 4-hexafluorobutene [R-1336mzz(Z)]: vapor pressure,(p, ρ, T)behavior, and speed of sound measurements and equation of state [J]. Journal of Chemical Engineering Data, 2020, 65(9): 4201-4214.

SUN Yukun, LI Xiaojing, MENG Xianyang, et al. Measurement and correlation of the liquid density and viscosity of HFO-1336mzz(Z)(cis-1, 1, 1, 4, 4, 4-hexafluoro-2-butene)at high pressure [J]. Journal of Chemical Engineering Data, 2019, 64(2): 395-403.

ALAM M J, MIYARA A, KARIYA K, et al. Measurement of viscosity of cis-1, 1, 1, 4, 4, 4-hexafluoro-2-butene(R-1336mzz(Z))by tandem capillary tubes method [J]. Journal of Chemical Engineering Data, 2018, 63(5): 1706-1712.

PERKINS R A, HUBER M L. Measurement and correlation of the thermal conductivity of cis-1, 1, 1, 4, 4, 4-hexafluoro-2-butene [J]. International Journal of Thermophysics, 2020, 41(7): 103.

ALAM M J, ISLAM M A, KARIYA K, et al. Measurement of thermal conductivity of cis-1, 1, 1, 4, 4, 4-hexafluoro-2-butene(R-1336mzz(Z))by the transient hot-wire method [J]. International Journal of Re-frigeration, 2017, 84: 220-227.

BROCUS J, VALTZ A, COQUELET C, et al. Solubility measurements of refrigerants in polyolesters lubricants at temperature from 323 K to 383 K [J]. International Journal of Refrigeration, 2022, 134: 278-292.

林鸿, 段远源. 氢氟烃(HFC)二元混合物表面张力测量 [J]. 清华大学学报(自然科学版), 2003, 43(12): 1672-1675.

LIN Hong, DUAN Yuanyuan. Surface tension measurements of binary hydrofluorocarbon mixtures [J]. Journal of Tsinghua University(Science and Technology), 2003, 43(12): 1672-1675.

DUAN Wenhao, ZHAO Xiaoming, ZENG Xiaoyang, et al. Surface tension of HFC-161 and compressor oil mixtures [J]. International Journal of Refrigeration, 2018, 85: 191-199.

EMEL'IANOV V V, KRASNYKH E L, PORTNOVA S V, et al. Synthetic oils based on pentaerythritol esters: vapor pressure and enthalpy of vaporization [J]. Fuel, 2022, 312: 122908.

MERMOND Y, FEIDT M, MARVILLET C. Thermodynamic and physical properties of mixtures of refrigerants and oils [J]. International Journal of Refrigeration, 1999, 22(7): 569-579.

LOTTIN O, GUILLEMET P, LEBRETON J M. Effects of synthetic oil in a compression refrigeration system using R410A: Part I modelling of the whole system and analysis of its response to an increase in the amount of circulating oil [J]. International Journal of Refrigeration, 2003, 26(7): 772-782.

魏文建, 丁国良, 胡海涛, 等. R410A制冷剂和POE VG 68润滑油混合物热物性模型 [J]. 制冷学报, 2007, 28(1): 37-44.

WEI Wenjian, DING Guoliang, HU Haitao, et al. Models of thermodynamic and transport properties of POE VG68 and R410A/POE VG68 mixture [J]. Journal of Refrigeration, 2007, 28(1): 37-44.

LEMMON E W, BELL I H, HUBER M L, et al. NIST standard reference database 23: reference fluid thermodynamic and transport properties-REFPROP, version 10.0 [EB/OL]. [2023-01-01]. https://doi.org/10.18434/T4/1502528.

MIQUEU C, BROSETA D, SATHERLEY J, et al. An extended scaled equation for the temperature dependence of the surface tension of pure compounds inferred from an analysis of experimental data [J]. Fluid Phase Equilibria, 2000, 172(2): 169-182.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

相对浸润性对双元液滴碰撞影响的数值研究

含油制冷剂R134a饱和液相运动黏度及表面张力实验测量

甲基九氟丁醚的液相密度和表面张力的实验研究

表面自由能模型的改进及液滴浸润数值研究

HFE7000、HFE7200的表面张力和黏度实验研究