富氧分级条件下高碱煤燃烧积灰与NO<sub>x</sub>生成规律实验研究

赵林; 王长安; 孙瑞金; 罗茂芸; 车得福

doi:10.7652/xjtuxb202308008

您当前的位置：

首页 >

文章列表页 >

富氧分级条件下高碱煤燃烧积灰与NO_x生成规律实验研究

能源与动力 | 更新时间：2025-05-08

- 富氧分级条件下高碱煤燃烧积灰与NO_x生成规律实验研究
- An Experimental Study on Ash Deposition and NO_x Generation of High-Alkali Coal under the Condition of Staged Oxy-Fuel Combustion
- 西安交通大学学报 2023年57卷第8期页码：76-85
- 作者机构：
  
  西安交通大学动力工程多相流国家重点实验室,西安,710049
- 作者简介：
  
  : 2023-02-04。作者简介: 赵林(1997—),男,博士生
  王长安(通信作者),男,教授,博士生导师。基金项目: 国家自然科学基金资助项目(52176129)。
- 基金信息：
  
  : 2023-02-04。作者简介: 赵林(1997—),男,博士生;王长安(通信作者),男,教授,博士生导师。基金项目: 国家自然科学基金资助项目(52176129)。
- DOI：10.7652/xjtuxb202308008
  中图分类号： TK16
- 网络首发：2023-08-10，
  
  纸质出版：2023
- 稿件说明：
移动端阅览
赵林, 王长安, 孙瑞金, 等. 富氧分级条件下高碱煤燃烧积灰与NO_x生成规律实验研究[J]. 西安交通大学学报, 2023,57(8):76-85. DOI: 10.7652/xjtuxb202308008.

ZHAO Lin, WANG Chang'an, SUN Ruijin, et al. An Experimental Study on Ash Deposition and NO_x Generation of High-Alkali Coal under the Condition of Staged Oxy-Fuel Combustion[J]. 2023, 57(8): 76-85. DOI: 10.7652/xjtuxb202308008.
赵林, 王长安, 孙瑞金, 等. 富氧分级条件下高碱煤燃烧积灰与NO_x生成规律实验研究[J]. 西安交通大学学报, 2023,57(8):76-85. DOI: 10.7652/xjtuxb202308008. DOI：

ZHAO Lin, WANG Chang'an, SUN Ruijin, et al. An Experimental Study on Ash Deposition and NO_x Generation of High-Alkali Coal under the Condition of Staged Oxy-Fuel Combustion[J]. 2023, 57(8): 76-85. DOI: 10.7652/xjtuxb202308008. DOI：

摘要

为研究高碱煤在分级条件下的富氧燃烧行为

同时探究了高碱煤在该条件下的积灰行为与NO

生成规律。利用两段炉实验系统

首先对比了高碱煤在空气分级和富氧分级条件下的NO

生成和积灰情况

然后分析了富氧分级条件下总氧体积分数和主燃区氧体积分数的影响。结果表明

在氧体积分数均为21%时

富氧分级燃烧可以实现比空气分级燃烧更小的燃料氮转化率(6.8%、 9.6%)和更少的积灰量(62.4、147.3 mg)。富氧分级条件下

随着总氧体积分数的增加(15%～50%)

积灰量近似地线性增加

氧体积分数每增加10%

积灰约增加40 mg

燃料氮转化率也呈现上升趋势

但氧体积分数为15%～30%时变化较小。随着主燃区氧体积分数的增加(25%～60%)

燃料氮转化率和积灰质量均提高

主燃区氧体积分数每增加10%

积灰约增加21 mg。该研究表明

在研究高碱煤在分级条件下的富氧燃烧时

应同时关注NO

生成和积灰情况

这可以为促进高碱煤的清洁安全利用和碳减排事业提供更全面的信息。

Abstract

In order to study the staged oxy-fuel combustion behavior of high-alkali coal

the NO

generation and ash deposition of high-alkali coal in the staged oxy-fuel combustion were investigated simultaneously in this study. With the help of two-stage furnace system

the NO

generation and ash deposition of high-alkali coal in the staged oxy-fuel and air combustion were compared firstly

and then the effects of total oxygen content and oxygen content in the prima

ry combustion zone under the staged oxy-fuel condition were subsequently studied. The experimental results show that compared with the air-staged combustion

the smaller conversion ratio of fuel-nitrogen to NO(6.8%、9.6%)and the less deposited ash(62.4、147.3 mg)can be achieved in the staged oxy-fuel combustion when the oxygen contents were 21%. In the staged oxy-fuel combustion

the mass of ash deposit increases in an approximately linear way as the total oxygen content increases by 15%—50%. For each 10% increase in total oxygen content

the mass of ash deposit increases by about 40 mg. The conversion ratio of fuel-nitrogen to NO also shows an upward trend

but it changes slightly when oxygen content varies from 15% to 30%. With the oxygen content in the primary combustion zone increase by 25%—60%

both the conversion ratio of fuel-nitrogen to NO and mass of ash deposit increase. For each 10% increase in oxygen content in the primary combustion zone

the mass of ash deposit increases by about 21 mg. This study indicates that the NO

generation and ash deposition of high-alkali coal in the staged oxy-fuel combustion should be investigated simultaneously

which could provide comprehensive information for promoting the clean and safe utilization of high-alkali coal

as well as reducing the CO

emission.

关键词

Keywords

references

国家统计局. 中华人民共和国2021年国民经济和社会发展统计公报 [EB/OL].(2022-02-28)[2022-10-10]. http://www.stats. gov. cn/xxgk/sjfb/zxfb2020/202202/ t20220228_1827971.html.

YADAV S, MONDAL S S. A review on the progress and prospects of oxy-fuel carbon capture and sequestration(CCS)technology [J]. Fuel, 2022, 308: 122057.

WALL T, LIU Yinghui, SPERO C, et al. An overview on oxyfuel coal combustion: state of the art research and technology development [J]. Chemical Engineering Research and Design, 2009, 87(8): 1003-1016.

STANGER R, WALL T, SPÖRL R, et al. Oxyfuel combustion for CO2 capture in power plants [J]. International Journal of Greenhouse Gas Control, 2015, 40: 55-125.

ZHA Qiongliang, BU Yufan, WANG Chang'an, et al. Evaluation of anthracite combustion and NOx emissions under oxygen-staging, high-temperature conditions [J]. Applied Thermal Engineering, 2016, 109: 751-760.

LIU Hao, ZAILANI R, GIBBS B M. Comparisons of pulverized coal combustion in air and in mixtures of O2/CO2 [J]. Fuel, 2005, 84(7/8): 833-840.

VODICˇKA M, HRDLICˇKA J, SKOPEC P. Experimental study of the NOx reduction through the staged oxygen supply in the oxy-fuel combustion in a 30 kWth bubbling fluidized bed [J]. Fuel, 2021, 286: 119343.

LI Gengda, LI Shuiqing, DONG Ming, et al. Comparison of particulate formation and ash deposition under oxy-fuel and conventional pulverized coal combustions [J]. Fuel, 2013, 106: 544-551.

STIMPSON C K, BRUNNER D R, REEDER T A, et al. Analysis of deposits collected under staged conditions in a pulverized coal reactor for eight US coals [J]. Applied Energy, 2013, 110: 65-72.

WEI Bo, TAN Houzhang, WANG Yibin, et al. Investigation of characteristics and formation mechanisms of deposits on different positions in full-scale boiler burning high alkali coal [J]. Applied Thermal Engineering, 2017, 119: 449-458.

SHI Hang, WU Yuxin, ZHANG Man, et al. Ash deposition of Zhundong coal in a 350 MW pulverized coal furnace: influence of sulfation [J]. Fuel, 2020, 260: 116317.

KOSTAKIS G. Mineralogical composition of boiler fouling and slagging deposits and their relation to fly ashes: the case of Kardia power plant [J]. Journal of Hazardous Materials, 2011, 185(2/3): 1012-1018.

WANG Yongzhen, JIN Jing, LIU Dunyu, et al. Understanding ash deposition for Zhundong coal combustion in 330 MW utility boiler: focusing on surface temperature effects [J]. Fuel, 2018, 216: 697-706.

LIU Bo, HE Qihui, JIANG Zihao, et al. Relationship between coal ash composition and ash fusion temperatures [J]. Fuel, 2013, 105: 293-300.

YU Shenghui, ZHANG Cheng, YUAN Changle, et al. Investigation on the influence of sulfur and chlorine on the initial deposition/fouling characteristics of a high-alkali coal [J]. Fuel Processing Technology, 2020, 198: 106234.

张守玉, 陈川, 施大钟, 等. 高钠煤燃烧利用现状 [J]. 中国电机工程学报, 2013, 33(5): 1-12.

ZHANG Shouyu, CHEN Chuan, SHI Dazhong, et al. Situation of combustion utilization of high sodium coal [J]. Proceedings of the CSEE, 2013, 33(5): 1-12.

WANG Chang'an, ZHAO Lin, SUN Ruijin, et al. Experimental study on NO emission and ash deposition during oxy-fuel combustion of high-alkali coal under oxygen-staged conditions [J]. Energy, 2022, 251: 123875.

ZHU Tao, HU Yueyi, TANG Chunli, et al. Experimental study on NOx formation and burnout characteristics of pulverized coal in oxygen enriched and deep-staging combustion [J]. Fuel, 2020, 272: 117639.

WANG Pengqian, WANG Chang'an, YUAN Maobo, et al. Experimental evaluation on co-combustion characteristics of semi-coke and coal under enhanced high-temperature and strong-reducing atmosphere [J]. Applied Energy, 2020, 260: 114203.

AARNA I, SUUBERG E M. A review of the kinetics of the nitric oxide-carbon reaction [J]. Fuel, 1997, 76(6): 475-491.

LÓPEZ D, CALO J. The N2O-carbon reaction: the influence of CO and potassium on reactivity and populations of oxygen surface complexes [J]. Fuel, 2007, 86(12/13): 1900-1907.

王鹏乾, 王长安, 杜勇博, 等. O2/CO2燃烧条件下NO2还原特性的实验研究 [J]. 西安交通大学学报, 2017, 51(5): 16-22, 141.

WANG Pengqian, WANG Chang'an, DU Yongbo, et al. Experimental investigation on the NO2 reduction property under O2/CO2 combustion condition [J]. Journal of Xi'an Jiaotong University, 2017, 51(5): 16-22, 141.

WANG Yungang, CHEN Heng, CHEN Zhongya, et al. Slagging and fouling characteristics of HRSG for ferrosilicon electric furnaces [J]. Energies, 2015, 8(2): 1101-1113.

WATANABE H, YAMAMOTO J I, OKAZAKI K. NOx formation and reduction mechanisms in staged O2/CO2 combustion [J]. Combustion and Flame, 2011, 158(7): 1255-1263.

赵磊, 王长安, 朱晨钊, 等. 灰化方式和温度对新疆高碱煤灰理化特性的影响 [J]. 西安交通大学学报, 2018, 52(8): 139-145.

ZHAO Lei, WANG Chang'an, ZHU Chenzhao, et al. Effects of ashing method and temperature on the ash physicochemical properties of high-alkali coals in Xinjiang [J]. Journal of Xi'an Jiaotong University, 2018, 52(8): 139-145.

MCLENNAN A R, BRYANT G W, BAILEY C W, et al. An experimental comparison of the ash formed from coals containing pyrite and siderite mineral in oxidizing and reducing conditions [J]. Energy Fuels, 2000, 14(2): 308-315.

吕俊复, 史航, 吴玉新, 等. 烟气气氛对准东煤灰熔融特性影响的显微观察 [J]. 煤炭学报, 2021, 46(1): 263-273.

LÜ Junfu, SHI Hang, WU Yuxin, et al. Influence of fluegas atmosphere on Zhundong coal ash melting characteristics through microscopic observation [J]. Journal of China Coal Society, 2021, 46(1): 263-273.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

不同板叠材料热声热机能量转换过程数值模拟研究

超临界水异常区域热力学特性研究

混合电解槽阵列协同的风光耦合制氢系统双层多目标优化

水蒸气掺混对氨裂解气旋流燃烧与排放特性的影响研究

采用试验设计方法的第三代CO2气体箔轴承箔片几何参数敏感性分析

富氧分级条件下高碱煤燃烧积灰与NOx生成规律实验研究

An Experimental Study on Ash Deposition and NOx Generation of High-Alkali Coal under the Condition of Staged Oxy-Fuel Combustion

DOI：10.7652/xjtuxb202308008

摘要

Abstract

关键词

Keywords

references

富氧分级条件下高碱煤燃烧积灰与NO_x生成规律实验研究

An Experimental Study on Ash Deposition and NO_x Generation of High-Alkali Coal under the Condition of Staged Oxy-Fuel Combustion