非均匀入流对CAP1400核主泵内流及性能的影响研究

张恒; 刘雷; 刘立军

doi:10.7652/xjtuxb202302005

您当前的位置：

首页 >

文章列表页 >

非均匀入流对CAP1400核主泵内流及性能的影响研究

专题新型燃料与燃烧过程优化 | 更新时间：2025-07-09

- 非均匀入流对CAP1400核主泵内流及性能的影响研究
- Effect of Non-Uniform Inflow on the Internal Flow and Performance of the Reactor Coolant Pump in CAP1400 System
- 西安交通大学学报 2023年57卷第2期页码：39-48
- 作者机构：
  
  1. 西安交通大学能源与动力工程学院,西安,710049
  2. 沈阳鼓风机集团股份有限公司,沈阳,110869
- 作者简介：
  
  : 2022-05-05。作者简介: 张恒(1997—),男,硕士生
  刘立军(通信作者),男,教授,博士生导师。基金项目: 国家重点研发计划资助项目(2018YFB0606104)。
- 基金信息：
  
  : 2022-05-05。作者简介: 张恒(1997—),男,硕士生;刘立军(通信作者),男,教授,博士生导师。基金项目: 国家重点研发计划资助项目(2018YFB0606104)。
- DOI：10.7652/xjtuxb202302005
  中图分类号： TL353
- 网络首发：2023-02-10，
  
  纸质出版：2023
- 稿件说明：
移动端阅览
张恒, 刘雷, 刘立军. 非均匀入流对CAP1400核主泵内流及性能的影响研究[J]. 西安交通大学学报, 2023,57(2):39-48.

ZHANG Heng, LIU Lei, LIU Lijun. Effect of Non-Uniform Inflow on the Internal Flow and Performance of the Reactor Coolant Pump in CAP1400 System[J]. 2023, 57(2): 39-48.
张恒, 刘雷, 刘立军. 非均匀入流对CAP1400核主泵内流及性能的影响研究[J]. 西安交通大学学报, 2023,57(2):39-48. DOI： 10.7652/xjtuxb202302005.

ZHANG Heng, LIU Lei, LIU Lijun. Effect of Non-Uniform Inflow on the Internal Flow and Performance of the Reactor Coolant Pump in CAP1400 System[J]. 2023, 57(2): 39-48. DOI： 10.7652/xjtuxb202302005.

摘要

针对CAP1400反应堆冷却剂系统中

由于蒸发器下腔室和核主泵直接相连导致核主泵入口产生非均匀入流

从而影响核主泵内部流场的问题

通过基于剪切应力运输模型的全三维CFD模拟方法

对蒸发器下腔室和核主泵联合模型进行数值模拟

分析了蒸发器下腔室致非均匀流动的形成机理

研究了非均匀入流对核主泵内部流动和水力性能的影响。结果表明:下腔室非对称结构和突缩截面的流动分离是非均匀流动的主要成因。在额定工况下

非均匀入流导致左侧和右侧核主泵扬程分别下降6.0%、5.1%

效率分别下降7.2%、6.6%; 在0.5～1.2倍额定流量工况范围内

性能下降幅度与流量呈正相关。非均匀入流呈现轴向速度分布不均匀并伴随二次流动的稳定结构

并且左右两侧叶轮内非均匀入流的旋流畸变特性和轴向速度分布不同。叶轮入口旋流畸变引起入口冲角发生变化

与均匀入流相比

左右两侧叶轮叶高中部的冲角变化相反

而叶顶部分冲角均增加、叶根部分冲角均减小; 叶轮入口轴向速度不均匀引起左右两侧叶轮各流道的流量波动分别增大3倍和2倍

降低了核主泵的运行稳定性。

Abstract

In CAP1400 reactor coolant system

because the lower header of steam generator and the reactor coolant pump are directly connected

non-uniform inflow is generated at the pump inlet and impacts the internal flow of the pump. By full-scale three-dimensional CFD simulation based on shear stress transport model

numerical calculation of the lower header-pump combined model is conducted to analyze the formation mechanism of non-uniform inflow in the lower header of steam generator and investigate the effect of non-uniform inflow on the internal flow and hydraulic performance of the pump. The results show that non-uniform inflow is mainly caused by the asymmetric structure of the lower header and the flow separation at suddenly reduced section. Under the design flow rate conditions

the non-uniform inflow leads to a 6.0% and 5.1% decrease in head and a 7.2% and 6.6% decrease in efficiency for the left and right pumps

respectively. Under the condition of 0.5 to 1.2 times design flow rate

the performance decrease is positively correlated with flow rate. In addition

non-uniform inflow presents a stable structure with uneven axial velocity distribution and secondary flow

and the inflows of the left and right impellers have different swirl distortion characteristics and axial velocity distribution. The swirl distortion at the impeller inlet causes changes in the inlet impulse angle. Compared with uniform inflow

the impulse angle in the middle of the blade of the left and right impellers changes in the opposite direction

while the impulse angle at the blade top increases and the angle at the blade root decreases. The flow fluctuations in the flow channels of the left and right impellers increase by three times and twice respectively due to the uneven axial velocity at the impeller inlet

leading to degraded operational stability of the reactor coolant pump.

关键词

Keywords

references

雷明凯, 陈语曦, 朱宝, 等. 核主泵压力脉动及其诱导振动研究进展 [J]. 中国核电, 2019, 12(3): 275-279.

LEI Mingkai, CHEN Yuxi, ZHU Bao, et al. Pressure pulsation and its induced vibration of main coolant pumps in nuclear power plant [J].China Nuclear Power, 2019, 12(3): 275-279.

ZHENG Mingguang, YAN Jinquan, JUN Shentu, et al. The general design and technology innovations of CAP1400 [J]. Engineering, 2016, 2(1): 97-102.

NIU Tingting, LIU Chunli, XIA Shuan. Analysis of CAP1400 reactor coolant hot leg flow field [C]//2017 25th International Conference on Nuclear Engineering. New York, NY, USA: ASME, 2017: V008T09A035.

王悦荟, 刘聪, 王鹏飞, 等. 蒸汽发生器致畸变入流对核主泵流动性能的影响 [J]. 浙江大学学报(工学版), 2019, 53(11): 2076-2084.

WANG Yuehui, LIU Cong, WANG Pengfei, et al. Influence of distorted inflow caused by steam generator on flow properties of reactor coolant pump [J]. Journal of Zhejiang University(Engineering Science), 2019, 53(11): 2076-2084.

VAGNOLI S, VERSTRAETE T. URANS analysis of the effect of realistic inlet distortions on the stall inception of a centrifugal compressor [J]. Computers Fluids, 2015, 116: 192-204.

CAO Puyu, WANG Yang, KANG Can, et al. Investigation of the role of non-uniform suction flow in the performance of water-jet pump [J]. Ocean Engineering, 2017, 140: 258-269.

VAN ESCH B P M. Performance and radial loading of a mixed-flow pump under non-uniform suction flow [J]. Journal of Fluids Engineering, 2009, 131(5): 051101.

MITTAG S, GABI M. Experimental and numerical investigation of centrifugal pumps with asymmetric inflow conditions [J]. Journal of Thermal Science, 2015, 24(6): 516-525.

王福军, 张玲, 黎耀军, 等. 轴流式水泵非定常湍流数值模拟的若干关键问题 [J]. 机械工程学报, 2008, 44(8): 73-77.

WANG Fujun, ZHANG Ling, LI Yaojun, et al. Some key issues of unsteady turbulent numerical simulation in axial-flow pump [J]. Chinese Journal of Mechanical Engineering, 2008, 44(8): 73-77.

颜禹, 陆晓峰, 朱晓磊. 进口弯管及前置扰流子对离心泵性能影响 [J]. 农业工程学报, 2013, 29(20): 74-81.

YAN Yu, LU Xiaofeng, ZHU Xiaolei. Effect of import bend and forward turbolator on performance of centrifugal pump [J]. Transactions of the Chinese Society of Agricultural Engineering, 2013, 29(20): 74-81.

施卫东, 张光建, 张德胜, 等. 入口非均匀流对轴流泵性能和压力脉动的影响 [J]. 排灌机械工程学报, 2014, 32(4): 277-282.

SHI Weidong, ZHANG Guangjian, ZHANG Desheng, et al. Effects of non-uniform suction flow on performance and pressure fluctuation in axial-flow pumps [J]. Journal of Drainage and Irrigation Machinery Engineering, 2014, 32(4): 277-282.

冯建军, 杨红红, 王晨, 等. 进口非均匀来流对离心泵失速特性的影响 [J]. 水动力学研究与进展: A辑, 2019, 34(5): 551-558.

FENG Jianjun, YANG Honghong, WANG Chen, et al.Effect of non-uniform inflow on stall characteristics in centrifugal pumps [J]. Chinese Journal of Hydrodynamics: A, 2019, 34(5): 551-558.

黄伟, 张文其, 陶文铨, 等. 蒸汽发生器下封头/主泵连接处流动特性试验研究 [J]. 核动力工程, 2002, 23(S1): 38-42.

HUANG Wei, ZHANG Wenqi, TAO Wenquan, et al. Flow characteristics experimental study within connection between steam generator channel head and pump suction [J].Nuclear Power Engineering, 2002, 23(S1): 38-42.

侯向陶, 王鹏飞, 许忠斌, 等. 蒸汽发生器下封头对核主泵入口流场影响 [J]. 排灌机械工程学报, 2016, 34(4): 277-282.

HOU Xiangtao, WANG Pengfei, XU Zhongbin, et al. Influence of steam generator channel head on reactor coolant pump inflow field [J].Journal of Drainage and Irrigation Machinery Engineering, 2016, 34(4): 277-282.

WANG Yuehui, WANG Pengfei, TAN Xiaohong, et al. Research on the non-uniform inflow characteristics of the canned nuclear coolant pump [J]. Annals of Nuclear Energy, 2018, 115: 423-429.

WANG Yuehui, XU Zhongbin, WANG Pengfei, et al. Numerical and experimental analysis on the non-uniform inflow characteristics of a reactor coolant pump with a steam generator channel head [J]. Engineering Applications of Computational Fluid Mechanics, 2020, 14(1): 477-490.

XU Rui, LONG Yun, WANG Dezhong. Effects of rotating speed on the unsteady pressure pulsation of reactor coolant pumps with steam-generator simulator [J]. Nuclear Engineering and Design, 2018, 333: 25-44.

LONG Yun, WANG Dezhong, YIN Junlian, et al. Experimental investigation on the unsteady pressure pulsation of reactor coolant pumps with non-uniform inflow [J]. Annals of Nuclear Energy, 2017, 110: 501-510.

LONG Yun, WANG Dezhong, YIN Junlian, et al. Numerical investigation on the unsteady characteristics of reactor coolant pumps with non-uniform inflow [J]. Nuclear Engineering and Design, 2017, 320: 65-76.

LI Yibin, FAN Zhaojing, GUO Dongsheng, et al. Dynamic flow behavior and performance of a reactor coolant pump with distorted inflow [J]. EngineeringApplications of Computational Fluid Mechanics, 2020, 14(1): 683-699.

杨国英, 邓清华, 何伟, 等. 圆形截面双扭管内流动稳定性和均匀性评估 [J]. 西安交通大学学报, 2021, 55(6): 102-112.

YANG Guoying, DENG Qinghua, HE Wei, et al. Evaluation of flow stability and uniformity in double elbow pipe with circular cross section [J]. Journal of Xi'an Jiaotong University, 2021, 55(6): 102-112.

夏栓, 冯斌, 张海军. AP1000核岛主泵流场数值模拟 [J].核技术, 2013, 36(4): 101-107.

XIA Shuan, FENG Bin, ZHANG Haijun.Simulation of AP1000 reactor coolant pump flow field CFD [J]. Nuclear Techniques, 2013, 36(4): 101-107.

任芸, 吴登昊, 牟介刚, 等. 考虑旋转和曲率的湍流模型修正及应用 [J]. 西安交通大学学报, 2016, 50(9): 25-30.

REN Yun, WU Denghao, MU Jiegang, et al. Modification for turbulence model considering rotation and curvature with applications [J]. Journal of Xi'an Jiaotong University, 2016, 50(9): 25-30.

马松洋, 李明芮, 陈文振, 等. 进出口阻力对倒U型管束内倒流特性的影响分析 [J]. 核动力工程, 2022, 43(2): 53-58.

MA Songyang, LI Mingrui, CHEN Wenzhen, et al.Influence of inlet and outlet resistance on the characteristics of backflow in inverted U-tube bundle [J]. Nuclear Power Engineering, 2022, 43(2): 53-58.

胡伟波, 程邦勤, 陈志敏, 等. 整体涡旋流畸变对压气机性能影响的研究 [J]. 推进技术, 2015, 36(9): 1324-1330.

HU Weibo, CHENG Bangqin, CHEN Zhimin, et al.Investigation on effects of bulk swirl distortion on compressor performance [J]. Journal of Propulsion Technology, 2015, 36(9): 1324-1330.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

隧道内燃料电池汽车氢气泄漏扩散特性及影响因素

多工况下离心压气机叶轮-机匣一体联合设计优化

面向高海拔空冷发电机防晕性能演化规律的电热耦合研究

EBSILON软件在热电联产系统优化中的应用综述

不同板叠材料热声热机能量转换过程数值模拟研究