带零序电流抑制的开绕组永磁同步电机断相故障容错控制

冯智煜; 高琳; 李丰

doi:10.7652/xjtuxb202212010

您当前的位置：

首页 >

文章列表页 >

带零序电流抑制的开绕组永磁同步电机断相故障容错控制

—————————————————————— | 更新时间：2025-07-09

- 带零序电流抑制的开绕组永磁同步电机断相故障容错控制
- Fault-Tolerant Control of Open-Winding Permanent Magnet Synchronous Motor under One-Phase Fault with Zero-Sequence Current Suppression
- 西安交通大学学报 2022年56卷第12期页码：97-107
- 作者机构：
  
  西安交通大学电气工程学院,西安,710049
- 作者简介：
  
  : 2022-05-12。作者简介: 冯智煜(1998—),男,硕士生
  高琳(通信作者),女,副教授,硕士生导师
- 基金信息：
- DOI：10.7652/xjtuxb202212010
  中图分类号： TM351
- 网络首发：2022-12-10，
  
  纸质出版：2022
- 稿件说明：
移动端阅览
冯智煜, 高琳, 李丰. 带零序电流抑制的开绕组永磁同步电机断相故障容错控制[J]. 西安交通大学学报, 2022,56(12):97-107.

FENG Zhiyu, GAO Lin, LI Feng. Fault-Tolerant Control of Open-Winding Permanent Magnet Synchronous Motor under One-Phase Fault with Zero-Sequence Current Suppression[J]. 2022, 56(12): 97-107.
冯智煜, 高琳, 李丰. 带零序电流抑制的开绕组永磁同步电机断相故障容错控制[J]. 西安交通大学学报, 2022,56(12):97-107. DOI： 10.7652/xjtuxb202212010.

FENG Zhiyu, GAO Lin, LI Feng. Fault-Tolerant Control of Open-Winding Permanent Magnet Synchronous Motor under One-Phase Fault with Zero-Sequence Current Suppression[J]. 2022, 56(12): 97-107. DOI： 10.7652/xjtuxb202212010.

摘要

针对共直流母线型开绕组永磁同步电机在绕组出现断相故障后控制策略以及零序电流抑制策略不再适用的问题

采用一种断相后坐标转换和零序电流抑制的改进控制策略

以保证系统运行的可靠性和控制精度。基于断相前后定子电流合成磁势不变的原理

对剩余两相建立坐标系并重构其与静止αβ坐标系间的变换矩阵

调整非故障相电流的幅值与相位

保证断相故障后电机运行的稳定性。为实现逆变器组间的协同作用

设计分配方案

对逆变器容量进行合理分配

并利用一种比例谐振控制方法对断相后系统零序电流进行抑制

削弱三次谐波零序电流在同步坐标系中电流产生的谐波

从而减小电磁转矩脉动

提高系统的控制性能。仿真结果表明

改进后的方法提高了断相故障状态下开绕组永磁同步电机控制系统的可靠性和控制精度。研究结果可为共母线型开绕组电机系统在断相工况下的控制提供理论依据。

Abstract

An improved control strategy of coordinate transformation and zero-sequence current suppression after open-phase fault is adopted to solve the problem that the control strategy and the zero-sequence current(ZSC)suppression strategy open-winding permanent magnet synchronous motor(OW-PMSM)with common DC bus are no longer applicable for each other after the open-phase fault and to ensure the reliability and control accuracy of the system. Based on the principle that the combined magnetic potential of the stator current does not change after the open-phase fault

a coordinate system for the remaining two healthy phases and the transformation matrix between them is established and the static αβ coordinate system is reconstructed

meanwhile the amplitude and phase of the healthyphase current are adjusted to ensure the stability of the motor system after openphase fault. In order to realize the synergy between the inverters

a distribution scheme is designed to distribute the inverter capacity reasonably

and a proportional resonance control method is used to suppress the zero-sequence current of the system after the open-phase fault and to weaken the harmonics generated by the current in the synchronous coordinate system

accordingly reduce the electromagnetic torque ripple and improve the control performance of the system. The simulation results show that the method improves the reliability and control accuracy of the open-winding permanent magnet synchronous motor control system under the open-phase fault state. The research results can provide a theoretical basis for the control of the open-winding motor system with common DC bus under open-phase conditions.

关键词

Keywords

references

殷凯轩, 高琳, 陈锐, 等. 带参数识别的永磁同步电机多虚拟信号注入最大转矩电流比控制 [J]. 西安交通大学学报, 2021, 55(11): 87-96.

YIN Kaixuan, GAO Lin, CHEN Rui, et al. Multiple virtual signals injection maximum torque per ampere control for permanent magnet synchronous motor with parameter identification [J]. Journal of Xi'an Jiaotong University, 2021, 55(11): 87-96.

刘珅, 高琳. 永磁同步电机的改进模型预测直接转矩控制 [J]. 电机与控制学报, 2020, 24(1): 10-17.

LIU Shen, GAO Lin. Improved model of predictive direct torque control for permanent magnet synchronous motor [J]. Electric Machines and Control, 2020, 24(1): 10-17.

殷凯轩, 高琳, 付文华, 等. 永磁同步电机的改进模型预测自抗扰前馈控制 [J]. 西安交通大学学报, 2021, 55(4): 29-38.

YIN Kaixuan, GAO Lin, FU Wenhua, et al. An improved prediction control model for PMSM with active disturbance rejection and feed-forward control strategy [J]. Journal of Xi'an Jiaotong University, 2021, 55(4): 29-38.

安群涛, 孙力, 孙立志. 新型开放式绕组永磁同步电机矢量控制系统研究 [J]. 中国电机工程学报, 2015, 35(22): 5891-5898.

AN Quntao, SUN Li, SUN Lizhi. Research on novel open-end winding permanent magnet synchronous motor vector control systems [J]. Proceedings of the CSEE, 2015, 35(22): 5891-5898.

MATHEW J, RAJEEVAN P P, MATHEW K, et al. A multilevel inverter scheme with dodecagonal voltage space vectors based on flying capacitor topology for induction motor drives [J]. IEEE Transactions on Power Electronics, 2013, 28(1): 516-525.

魏佳丹, 周波, 韩楚, 等. 一种新型绕组开路型永磁电机起动/发电系统 [J]. 中国电机工程学报, 2011, 31(36): 86-94.

WEI Jiadan, ZHOU Bo, HAN Chu, et al. A novel open-winding permanent magnetic starter-generator [J]. Proceedings of the CSEE, 2011, 31(36): 86-94.

贾一帆, 初亮, 许楠, 等. 车用双电源开绕组电机驱动系统绕组模式切换及电流控制策略 [J]. 吉林大学学报(工学版), 2018, 48(1): 20-29.

JIA Yifan, CHU Liang, XU Nan, et al. Winding mode shifting and current control strategy of dual power open-winding PMSM drive system for electric vehicle [J]. Journal of Jilin University(Engineering and Technology Edition), 2018, 48(1): 20-29.

REDDY B V, SOMASEKHAR V T. A dual inverter fed four-level open-end winding induction motor drive with a nested rectifier-inverter [J]. IEEE Transactions on Industrial Informatics, 2013, 9(2): 938-946.

LI Xueping, ZHANG Shuo, ZHANG Chengning, et al. An improved deadbeat predictive current control scheme for open-winding permanent magnet synchronous motors drives with disturbance observer [J]. IEEE Transactions on Power Electronics, 2021, 36(4): 4622-4632.

ZHENG Zhihao, SUN Dan, WANG Mingze, et al. A dual two-vector-based model predictive flux control with field-weakening operation for OW-PMSM drives [J]. IEEE Transactions on Power Electronics, 2021, 36(2): 2191-2200.

年珩, 阮晨辉, 何峪嵩, 等. 基于Z源逆变器的共直流母线开绕组永磁同步电机系统控制策略 [J]. 中国电机工程学报, 2019, 39(18): 5509-5519.

NIAN Heng, RUAN Chenhui, HE Yusong, et al. Control strategy for open-winding PMSM system with common DC bus based on Z-source inverters [J]. Proceedings of the CSEE, 2019, 39(18): 5509-5519.

王伟, 蒋奕昕, 王政, 等. 共直流母线开绕组电机系统零序电流抑制技术综述 [J]. 中国电机工程学报, 2021, 41(5): 1871-1885.

WANG Wei, JIANG Yixin, WANG Zheng, et al. Overview of zero-sequence current suppression technology for open-end winding motor system with common DC-bus [J]. Proceedings of the CSEE, 2021, 41(5): 1871-1885.

ZHOU Yijie, NIAN Heng. Zero-sequence current suppression strategy of open-winding PMSG system with common DC bus based on zero vector redistribution [J]. IEEE Transactions on Industrial Electronics, 2015, 62(6): 3399-3408.

冯智煜, 高琳, 殷凯轩, 等. 开绕组永磁同步电机零矢量注入模型预测控制 [J]. 电机与控制学报, 2022, 26(2): 32-42.

FENG Zhiyu, GAO Lin, YIN Kaixuan, et al. Improved model predictive zero vector injection control for open-winding permanent magnet synchronous motors [J]. Electric Machines and Control, 2022, 26(2): 32-42.

曾恒力, 年珩, 周义杰. 基于比例谐振控制的共直流母线开绕组永磁同步电机零序电流抑制技术 [J]. 电工技术学报, 2016, 31(22): 35-44.

ZENG Hengli, NIAN Heng, ZHOU Yijie. Zero sequence current suppression for open winding permanent magnet synchronous motor with common DC bus based on proportional-resonant controller [J]. Transactions of China Electrotechnical Society, 2016, 31(22): 35-44.

方敏, 周新秀, 刘刚. 三相永磁同步电机断相容错控制 [J]. 电工技术学报, 2018, 33(13): 2972-2981.

FANG Min, ZHOU Xinxiu, LIU Gang. Fault-tolerant control strategy for three-phase permanent magnet synchronous motor in case of one phase open-circuit [J]. Transactions of China Electrotechnical Society, 2018, 33(13): 2972-2981.

袁高龙, 向保林, 徐光辉. 基于四桥臂逆变器的PMSM断相容错控制策略 [J]. 电气传动, 2021, 51(22): 34-41.

YUAN Gaolong, XIANG Baolin, XU Guanghui. Fault-tolerant control strategy of PMSM phase failure based on four-bridge inverter [J]. Electric Drive, 2021, 51(22): 34-41.

WALLMARK O, HARNEFORS L, CARLSON O. Control algorithms for a fault-tolerant PMSM drive [J]. IEEE Transactions on Industrial Electronics, 2007, 54(4): 1973-1980.

孟云平, 周新秀, 李红, 等. 基于四桥臂拓扑的永磁同步电机断相容错控制策略 [J]. 电工技术学报, 2019, 34(15): 3158-3166.

MENG Yunping, ZHOU Xinxiu, LI Hong, et al. Fault tolerant strategy of four-leg for permanent magnet synchronous motor in case of open circuit fault [J]. Transactions of China Electrotechnical Society, 2019, 34(15): 3158-3166.

ZHOU Xinxiu, SUN Jun, LI Haitao, et al. High performance three-phase PMSM open-phase fault-tolerant method based on reference frame transformation [J]. IEEE Transactions on Industrial Electronics, 2019, 66(10): 7571-7580.

HU Wei, RUAN Chenhui, NIAN Heng, et al. Simplified modulation scheme for open-end winding PMSM system with common DC bus under open-phase fault based on circulating current suppression [J]. IEEE Transactions on Power Electronics, 2020, 35(1): 10-14.

陈文汉, 孙丹, 王铭泽. 断相故障下开绕组永磁同步电机模型预测控制容错控制策略研究 [J]. 电工技术学报, 2021, 36(1): 77-86.

CHEN Wenhan, SUN Dan, WANG Mingze. Research on fault-tolerance strategy based on model predictive control for open-winding PMSM system under open-phase fault [J]. Transactions of China Electrotechnical Society, 2021, 36(1): 77-86.

吕康飞, 董新伟, 刘丽丽, 等. 考虑零序电流抑制的开绕组永磁同步电机断相故障下统一调制策略 [J]. 电工技术学报, 2020, 35(11): 2387-2395.

LÜ Kangfei, DONG Xinwei, LIU Lili, et al. The unified modulation scheme of open-end winding PMSM with common DC bus under the open-phase fault considering the suppression of zero-sequence current [J]. Transactions of China Electrotechnical Society, 2020, 35(11): 2387-2395.

ZMOOD D N, HOLMES D G. Stationary frame current regulation of PWM inverters with zero steady-state error [J]. IEEE Transactions on Power Electronics, 2003, 18(3): 814-822.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

语义区分和子图整合驱动的知识图谱表示学习方法

水蒸气掺混对氨裂解气旋流燃烧与排放特性的影响研究

超临界水异常区域热力学特性研究

张角凹坑气膜孔对双层壁气膜冷却特性的影响

三塔合一间接空冷系统结构参数对夏季运行特性的影响研究