GIS盆式绝缘子表面污秽模态分析检测方法研究

袁文泽; 何聪; 蔡鋆; 侯志强; 李军浩

doi:10.7652/xjtuxb202102012

您当前的位置：

首页 >

文章列表页 >

GIS盆式绝缘子表面污秽模态分析检测方法研究

更新时间：2025-07-09

- GIS盆式绝缘子表面污秽模态分析检测方法研究
- A Detection Method of Surface Pollution of GIS Basin Insulator Using Modal Analysis
- 西安交通大学学报 2021年55卷第2期页码：100-111
- 作者机构：
  
  西安交通大学电气工程学院,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb202102012
  中图分类号： TM84
- 网络首发：2021-02-10，
  
  纸质出版：2021
- 稿件说明：
移动端阅览
袁文泽, 何聪, 蔡鋆, 等. GIS盆式绝缘子表面污秽模态分析检测方法研究[J]. 西安交通大学学报, 2021,55(2):100-111.

A Detection Method of Surface Pollution of GIS Basin Insulator Using Modal Analysis[J]. 2021, 55(2): 100-111.
袁文泽, 何聪, 蔡鋆, 等. GIS盆式绝缘子表面污秽模态分析检测方法研究[J]. 西安交通大学学报, 2021,55(2):100-111. DOI： 10.7652/xjtuxb202102012.

A Detection Method of Surface Pollution of GIS Basin Insulator Using Modal Analysis[J]. 2021, 55(2): 100-111. DOI： 10.7652/xjtuxb202102012.

摘要

为探究气体绝缘金属封闭开关设备(GIS)盆式绝缘子振动模态与表面污秽状况之间的关联关系

采用模态分析方法对盆式绝缘子表面污秽状况进行了检测分析。通过三维有限元软件进行了数值仿真

研究了污秽质量、面积、位置、材料特性对盆式绝缘子模态特性的影响

并在220 kV GIS模型上进行盆式绝缘子的模态试验

对其表面污秽状况检测技术进行了相关研究。研究结果表明:污秽质量是影响盆式绝缘子模态特性的关键因素

污秽面积、位置、材料特性对其模态特性的影响较小; 当盆式绝缘子表面污秽质量增加时

Abstract

To explore the relationship between the vibration mode of a gas insulated switchgear(GIS)basin insulator and the surface contamination

this study detects and analyzes the surface contamination of basin insulators based on the modal analysis method. The effects of pollution mass

area

location and material on the modal characteristics of basin insulators are simulated

and the modal test of basin insulators is carried out on the 220 kV GIS model

and related research on the surface contamination detection technology is carried out. The research results show that the pollution mass is the key factor that affects the modal characteristics of the basin insulator

and the pollution area

location and material have little effect on the modal characteristics. When the pollution mass on the surface of the pot insulator increases

the correlation coefficient will decrease significantly

the pollution accumulation value in the 2 000-3 000 Hz vibration signal will increase significantly

and the pollution index in the signal frequency band 2 000-4 000 Hz will increase obviously. This research may provide a method that can be implemented on-site for the live detection of surface contamination of GIS basin insulators.

关键词

Keywords

references

李军浩, 韩旭涛, 刘泽辉, 等. 电气设备局部放电检测技术述评 [J]. 高电压技术, 2015, 41(8): 116-134.

LI Junhao, HAN Xutao, LIU Zehui, et al. Review on partial discharge measurement technology of electrical equipment [J]. High Voltage Engineering, 2015, 41(8): 116-134.

邱毓昌. GIS装置及其绝缘技术 [M]. 西安: 西安交通大学出版社, 2007: 2-10.

安滨. 1 000 kV GIS设备故障检测及实例分析 [J]. 电工电气, 2019(8): 46-49.

AN Bin. Fault detection and case analysis of 1 000 kV GIS equipment [J]. Electrician Electric, 2019(8): 46-49.

路士杰, 张连根, 周宏扬, 等. 温度对工频下环氧支柱沿面闪络电压的影响 [J]. 高电压技术, 2019, 45(9): 2774-2781.

LU Shijie, ZHANG Liangen, ZHOU Hongyang, et al. Influence of temperature on the flashover voltage of epoxy pillars at power frequency [J]. High Voltage Engineering, 2019, 45(9): 2774-2781.

丁登伟, 唐诚, 高文胜, 等. GIS中典型局部放电的频谱特征及传播特性 [J]. 高电压技术, 2014, 40(10): 3243-3251.

DING Dengwei, TANG Cheng, GAO Wensheng, et al. Spectrum characteristics and propagation characteristics of typical partial discharges in GIS [J]. High Voltage Engineering, 2014, 40(10): 3243-3251.

肖燕, 郁惟镛. GIS中局部放电在线监测研究的现状与展望 [J]. 高电压技术, 2005(1): 49-51.

XIAO Yan, YU Weiyong. The status and prospects of on-line partial discharge monitoring research in GIS [J]. High Voltage Engineering, 2005(1): 49-51.

李锦辉. GIS交流耐压试验盆式绝缘子闪络的原因及防范措施 [J]. 电气技术, 2018, 19(9): 133-135, 141.

LI Jinhui. Causes of flashovers of basin insulators in GIS AC withstand voltage test [J]. Electrical Engineering, 2018, 19(9): 133-135, 141.

刘荣海, 臧春艳, 杨迎春, 等. 盆式绝缘子开裂故障的无损检测技术研究 [J]. 高压电器, 2019, 55(3): 151-155.

LIU Ronghai, ZANG Chunyan, YANG Yingchun, et al. Research on nondestructive testing technology of basin insulator cracking failure [J]. High Voltage Apparatus, 2019, 55(3): 151-155.

牛博, 杨鼎革, 于义亮, 等. 基于超声波的GIS盆式绝缘子表面污秽检测技术仿真研究 [J]. 高压电器, 2018, 54(11): 105-110.

NIU Bo, YANG Dingge, YU Yiliang, et al. Simulation of surface contamination detection technology of GIS basin insulator based on ultrasound [J]. High Voltage Apparatus, 2018, 54(11): 105-110.

张璐, 王森, 孙蕾, 等. 金属微粒对GIS中绝缘子冲击闪络特性的影响 [J]. 高电压技术, 2018, 44(9): 2807-2814.

ZHANG Lu, WANG Sen, SUN Lei, et al. Impact of metal particles on impact flashover characteristics of insulators in GIS [J]. High Voltage Engineering, 2018, 44(9): 2807-2814.

郭翠娟, 杨明珠, 荣锋, 等. 基于振动响应分析的盆式绝缘子损伤检测系统 [J]. 传感技术学报, 2016, 29(10): 1606-1612.

GUO Cuijuan, YANG Mingzhu, RONG Feng, et al. Basin insulator damage detection system based on vibration response analysis [J]. Journal of Transduction Technology, 2016, 29(10): 1606-1612.

黄清, 魏旭, 许建刚, 等. 基于振动原理的GIS母线触头松动缺陷诊断技术研究 [J]. 高压电器, 2017, 53(11): 99-104, 108.

HUANG Qing, WEI Xu, XU Jiangang, et al. Research on diagnosis technology of loose contact defect of GIS bus bar based on vibration principle [J]. High Voltage Apparatus, 2017, 53(11): 99-104, 108.

黄建, 胡晓光, 巩玉楠. 基于经验模态分解的高压断路器机械故障诊断方法 [J]. 中国电机工程学报, 2011(12): 110-115.

HUANG Jian, HU Xiaoguang, GONG Yunan. Method for mechanical fault diagnosis of high voltage circuit breaker based on empirical mode decomposition [J]. Proceedings of the CSEE, 2011(12): 110-115.

邱志斌, 阮江军, 黄道春, 等. 高压隔离开关机械故障分析及诊断技术综述 [J]. 高压电器, 2015(8): 171-179.

QIU Zhibin, RUAN Jiangjun, HUANG Daochun, et al. Summary of mechanical failure analysis and diagnosis technology for high voltage isolation switch [J]. High Voltage Apparatus, 2015(8): 171-179.

孙来军, 胡晓光, 纪延超. 一种基于振动信号的高压断路器故障诊断新方法 [J]. 中国电机工程学报, 2006(6): 159-163.

SUN Laijun, HU Xiaoguang, JI Yanchao. A new method for fault diagnosis of high voltage circuit breakers based on vibration signals [J]. Proceedings of the CSEE, 2006(6): 159-163.

RéBILLAT M, BARTHES C B, MECHBAL N, et al. Structural health monitoring of high voltage electrical switch ceramic insulators in seismic areas [C]∥7th European Workshop on Structural Health Monitoring, Nantes, France: EWSHM, 2014: 2183-2190.

李秀广, 吴旭涛, 朱洪波, 等. 基于振动信号的GIS触头接触异常研究分析 [J]. 高压电器, 2016(10): 165-169.

LI Xiuguang, WU Xutao, ZHU Hongbo, et al. Research and analysis of contact abnormality of GIS contact based on vibration signal [J]. High Voltage Apparatus, 2016(10): 165-169.

马朋飞, 史腾飞, 刘云海, 等. 振动法评估盆式绝缘子机械状态的分析 [J]. 云南电力技术, 2017(3), 45(3): 19-22.

MA Pengfei, SHI Tengfei, LIU Yunhai, et al. Analysis of mechanical condition of basin insulators by vibration method [J]. Yunnan Electric Power Technology, 2017(3): 19-22.

李晓红, 郭慧英, 刘云, 等. 基于振动法检测的瓷绝缘子损伤探讨 [J]. 高压电器, 2009(1): 106-108.

LI Xiaohong, GUO Huiying, LIU Yun, et al. Discussion on damage of porcelain insulators based on vibration detection [J]. High Voltage Apparatus, 2009(1): 106-108.

于卓琦, 高晋文, 王克胜, 等. 基于模态分析的GIS盆式绝缘子裂纹缺陷检测方法研究 [J]. 电测与仪表, 2019, 53(9): 100-104.

YU Zhuoqi, GAO Jinwen, WANG Kesheng, et al. Research on GIS basin insulator crack defect detection method based on modal analysis [J]. Electric Measurement Instrumentation, 2019, 53(9): 100-104.

牛博, 杨鼎革, 于义亮, 等. 基于超声波的GIS盆式绝缘子表面污秽检测技术仿真研究 [J]. 高压电器, 2018, 54(11): 97-102.

NIU Bo, YANG Dingge, YU Yiliang, et al. Simulation research on surface contamination detection technology of GIS basin insulators based on ultrasonic [J]. High Voltage Apparatus, 2018, 54(11): 97-102.

梁伟平, 张旭, 高敏. 基于有限元的积污绝缘子温度场研究 [J]. 电力科学与工程, 2019(10): 36-41.

LIANG Weiping, ZHANG Xu, GAO Min. Research on temperature field of contaminated insulator based on finite element [J]. Electric Power Science and Engineering, 2019(10): 36-41.

刘万锋, 张维锋. 一种快速方便的试验模态分析方法:锤击法 [J]. 西安公路学院学报, 1993, 13(4): 80-85.

LIU Wanfeng, ZHANG Weifeng. A fast and convenient experimental modal analysis method-hammering method [J]. Journal of Xi’an Highway University, 1993, 13(4): 80-85.

刘媛, 杨景刚, 贾勇勇, 等. 基于振动原理的GIS隔离开关触头接触状态检测技术 [J]. 高电压技术, 2019, 45(5): 1591-1599.

LIU Yuan, YANG Jinggang, JIA Yongyong, et al. Contact state detection technology of GIS disconnect switch based on vibration principle [J]. High Voltage Engineering, 2019, 45(5): 1591-1599.

吴泽华,田汇冬,靳守锋,等.252 kV紧凑型气体绝缘金属封闭输电线路三相盆式绝缘子结构综合优化.2020,54(12):138-146.[doi:10.7652/xjtuxb202012017]

贾云飞,高璐,汲胜昌,等.1 100 kV气体绝缘金属封闭输电线路用三支柱绝缘子电气性能优化.2020,54(7):168-179.[doi:10.7652/xjtuxb202007020]

郭小凯,卢雨欣,孙廷玺,等.用于电缆局部放电检测的储能式交流激励型振荡波测试系统.2020,54(10):100-107.[doi:10.7652/xjtuxb202010012]

李乃一,彭宗仁.气固绝缘系统电场模型的建立与求解方法.2019,53(6):151-160,168.[doi:10.7652/xjtuxb201906020]

庞培川,孙泽明,张芊,等.直流电压作用下极不均匀电场中SF6/N2混合气体局部放电起始特性研究.2019,53(4):44-50.[doi:10.7652/xjtuxb201904007]

韩旭涛,刘泽辉,张亮,等.GIS中局部放电光信号传播特性仿真研究.2018,52(6):128-134.[doi:10.7652/xjtuxb201806 019]

赵煦,刘晓航,孟永鹏,等.采用小波包树能量矩阵奇异值分解的局部放电模式识别.2017,51(8):116-121.[doi:10.7652/xjtuxb201708019]

崔彦捷,彭平,曹沛,等.针板电极下局部放电对油浸绝缘纸板表面的影响.2017,51(4):37-44.[doi:10.7652/xjtuxb 201704006]

邵先军,何文林,刘石,等.电力设备局部放电特高频电磁波数值计算技术研究.2016,50(12):24-31.[doi:10.7652/xjtuxb201612005]

李文栋,刘哲,有晓宇,等.叠层式介电功能梯度绝缘子的介电常数分布优化.2016,50(10):19-26.[doi:10.7652/xjtuxb 201610004]

邵先军,何文林,刘石,等.电力设备局部放电特高频电磁波数值计算技术研究.2016,50(12):24-31.[doi:10.7652/xjtuxb201612005]

张亮,车斌,韩旭涛,等.负极性振荡雷电冲击电压下SF6尖板模型局部放电特性.2016,50(4):108-116.[doi:10.7652/xjtuxb201604017]

钟理鹏,汲胜昌,刘凯,等.低微水的体积分数对SF6局部放电及分解特性的影响.2016,50(3):112-119.[doi:10.7652/xjtuxb201603018]

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

往复压缩机轴系扭振的数值分析

三维叶盘失谐模态分析的摄动降阶方法

面向高海拔空冷发电机防晕性能演化规律的电热耦合研究

电子级超纯氮深冷空分流程节能优化研究

扇贝仿生密封腔室内超临界二氧化碳泄漏流湍动能耗散机理研究