高速蒸汽与过冷水直接接触凝结局部换热特性研究

宗潇 1; 2; 刘浩 3; 杨赪石 2; 严俊杰 1; 刘继平 1

doi:10.7652/xjtuxb201809018

您当前的位置：

首页 >

文章列表页 >

高速蒸汽与过冷水直接接触凝结局部换热特性研究

更新时间：2025-05-01

- 高速蒸汽与过冷水直接接触凝结局部换热特性研究
- Experimental Study on the Local Heat Transfer Characteristics in the Direct Contact Condensation of Steam Jet with Subcooled Water
- 西安交通大学学报 2018年52卷第9期页码：134-139+147
- 作者机构：
  
  1. 西安交通大学热流科学与工程教育部重点实验室,西安,710049
  2. 中国船舶重工集团公司第705研究所,西安,710075
- 作者简介：
- 基金信息：
  
  : 2017-12-06。作者简介: 宗潇(1988—),男,博士后;刘继平(通信作者),男,教授,博士生导师。基金项目: 国家自然科学基金资助项目(51436006,51506167,61403306);中国博士后科学基金资助项目(2018M633600)
- DOI：10.7652/xjtuxb201809018
  中图分类号： TK2
- 网络首发：2018-09-10，
  
  纸质出版：2018
- 稿件说明：
移动端阅览
宗潇 1, 2, 刘浩 3, 等. 高速蒸汽与过冷水直接接触凝结局部换热特性研究[J]. 西安交通大学学报, 2018,52(9):134-139+147.

Experimental Study on the Local Heat Transfer Characteristics in the Direct Contact Condensation of Steam Jet with Subcooled Water[J]. 2018, 52(9): 134-139+147.
宗潇 1, 2, 刘浩 3, 等. 高速蒸汽与过冷水直接接触凝结局部换热特性研究[J]. 西安交通大学学报, 2018,52(9):134-139+147. DOI： 10.7652/xjtuxb201809018.

Experimental Study on the Local Heat Transfer Characteristics in the Direct Contact Condensation of Steam Jet with Subcooled Water[J]. 2018, 52(9): 134-139+147. DOI： 10.7652/xjtuxb201809018.

摘要

针对气液两相流喷射器内高速蒸汽与过冷水直接接触凝结过程

设计并搭建了使用矩形截面喷嘴及混合腔的可视化实验台

在蒸汽质量流率为200～600 kg·m

-2

·s

-1

、入口过冷水质量流率为4～18 t·m

-2

·s

-1

、入口过冷水温度为20～50 ℃的实验条件下

使用图像处理技术分析可视化图像

研究了气液界面的波动特性

建立了局部凝结换热系数的计算方法

并对界面波动与局部凝结换热系数的关系进行了研究。研究结果表明:实验中观察到的界面波是界面不稳定性的一种表现形式; 界面波在传播过程中振幅逐渐增加

强度增大

平均振幅在0.12～0.38 mm之间; 局部凝结换热系数沿流动方向逐渐增大

其值在1.8～5.9 MW·m

-2

·℃

-1

之间; 界面波振幅与局部凝结换热系数对比的结果表明

界面的波动对汽水直接接触凝结的换热过程具有强化作用。

Abstract

Aiming at the direct contact condensation process of steam jet with subcooled water

a visualized experimental rig composed of rectangular steam nozzle and mixing chamber was designed and built. The flow field was observed when the steam mass flux

water mass flux and water temperature were in the range of 200 - 600 kg·m

-2

·s

-1

4 - 18 t·m

-2

·s

-1

and 20 - 50 ℃

respectively. The steam-water interfacial fluctuation was investigated by image processing techniques

and a model for calculating local heat transfer coefficients was established. Besides

the relationship between interfacial fluctuation

and local heat transfer characteristic was also studied. The results indicate that the interfacial wave observed in the research implies an interfacial instability

the interfacial wave amplitude and local heat transfer coefficient increase along the interface

and a relatively great local heat transfer coefficient can be achieved at steam jet tail. Furthermore

the interfacial fluctuation can enhance the heat and mass transfer in the condensation process of steam jet in water flow.

关键词

Keywords

references

SIMPSON M E, CHAN C K. Hydrodynamics of a subsonic vapor jet in subcooled liquid [J]. ASME Journal of Heat Transfer, 1982, 104(2): 271-278.

CELATA G P, CUMO M, FARELLO G E, et al. Direct contact condensation of steam on slowly moving water [J]. Nuclear Engineering and Design, 1986, 96(1): 21-31.

CHAWLA T C. The Kelvin-Helmholtz instability of the gas-liquid interface of a sonic gas jet submerged in a liquid [J]. Journal of Fluid Mechanics, 1975, 67(3): 513-537.

KHAN A, HAQ N U, CHUGHTAI I R, et al. Experimental investigations of the interface between steam and water two phase flows [J]. International Journal of Heat and Mass Transfer, 2014, 73: 521-532.

KIM Y S, PARK J W, SONG C H. Investigation of the steam-water direct contact condensation heat transfer coefficients using interfacial transport models [J]. International Communications of Heat and Mass Transfer, 2004, 31(3): 397-408.

AYA I, NARIAI H. Evaluation of heat-transfer coefficient at direct-contact condensation of cold water and steam [J]. Nuclear Engineering and Design, 1991, 131(1): 17-24.

XU Q, GUO L J. Direct contact condensation of steam jet in crossflow of water in a vertical pipe: experimental investigation on condensation regime diagram and jet penetration length [J]. International Journal of Heat and Mass Transfer, 2016, 94: 528-538.

WU X Z, YAN J J, SHAO S F, et al. Experimental study on the condensation of supersonic steam jet submerged in quiescent subcooled water: steam plume shape and heat transfer [J]. International Journal of Multiphase Flow, 2007, 33(12): 1296-1307.

ZONG X, LIU J P, YANG X P, et al. Experimental study on the direct contact condensation of steam jet in subcooled water flow in a rectangular mix chamber [J]. International Journal of Heat and Mass Transfer, 2015, 80: 448-457.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

语义区分和子图整合驱动的知识图谱表示学习方法

电动车辆间接热系统快速除湿响应迟滞机理及优化控制策略

EBSILON软件在热电联产系统优化中的应用综述

超临界二氧化碳向心透平轮背间隙内风阻损失及流动特性研究

面向高海拔空冷发电机防晕性能演化规律的电热耦合研究