300 MW一次再热亚临界燃煤发电站系统改进研究

李沁伦; 王璐凯; 刘银河; 车得福

doi:10.7652/xjtuxb201809007

您当前的位置：

首页 >

文章列表页 >

300 MW一次再热亚临界燃煤发电站系统改进研究

更新时间：2025-05-01

- 300 MW一次再热亚临界燃煤发电站系统改进研究
- Novel System Design for a 300 MW Single Reheat Subcritical Coal-Fired Power Plant
- 西安交通大学学报 2018年52卷第9期页码：54-63
- 作者机构：
  
  西安交通大学动力工程多相流国家重点实验室,西安,710049
- 作者简介：
- 基金信息：
  
  : 2017-11-16。作者简介: 李沁伦(1994—),男,硕士生;刘银河(通信作者),男,教授。基金项目: 国家自然科学基金资助项目(51576158)
- DOI：10.7652/xjtuxb201809007
  中图分类号： TK115
- 网络首发：2018-09-10，
  
  纸质出版：2018
- 稿件说明：
移动端阅览
李沁伦, 王璐凯, 刘银河, 等. 300 MW一次再热亚临界燃煤发电站系统改进研究[J]. 西安交通大学学报, 2018,52(9):54-63.

Novel System Design for a 300 MW Single Reheat Subcritical Coal-Fired Power Plant[J]. 2018, 52(9): 54-63.
李沁伦, 王璐凯, 刘银河, 等. 300 MW一次再热亚临界燃煤发电站系统改进研究[J]. 西安交通大学学报, 2018,52(9):54-63. DOI： 10.7652/xjtuxb201809007.

Novel System Design for a 300 MW Single Reheat Subcritical Coal-Fired Power Plant[J]. 2018, 52(9): 54-63. DOI： 10.7652/xjtuxb201809007.

摘要

在传统300 MW一次再热亚临界燃煤发电站的空气预热器中

烟气与空气的换热温差大

导致了较大的损失

并且硫酸蒸汽易在冷端凝结使受热面产生低温腐蚀和堵灰的问题。此外

在回热系统中

汽轮机的抽汽与凝结水在换热时

回热加热器热端处的传热温差大

抽汽的过热度难以利用。针对传统电站的上述不足

提出了一种新型电站设计方案

并对其进行了热力学分析和技术经济性分析。在改进电站中

烟气凝结水预热器(flue gas-condensate preheater

FGCP)替换了传统电站中的空气预热器

省煤器后的烟气全部被用来加热部分凝结水

空气和其余凝结水则由汽轮机的抽汽进行加热

同时

增加1股高压抽汽用于保证热空气达到设计的温度要求。研究结果表明:保持FGCP中凝结水和烟气的热容流率相等

可以消除常规电站内空气预热器中的温差夹点

锅炉排烟温度降至103 ℃而不会产生低温腐蚀和堵灰; 将空气加热器与回热加热器串联布置

优先利用了抽汽的过热热来加热空气

减小了蒸汽和凝结水的传热温差; 改进电站的发电效率和净发电效率分别达到了45.34%和44.20%

相较常规电站分别提高了1.2和1.0个百分点; 改进电站的动态投资回收期约为4.27a

具有可行性。

Abstract

For conventional 300 MW single reheat subcritical coal-fired power plants

the heat transfer temperature difference between flue gas and air in the air preheater is large

resulting in a large exergy loss. Moreover

the sulfuric acid vapor easily condenses on the cold side

which causes low-temperature corrosion and ash plugging on the heated surface. In the regenerative system

the heat transfer temperature difference between the extraction steam and the condensate water at the hot end of regenerative heater(RH)is large

and the superheat degree of the extraction steam is difficult to use. To solve these problems

a novel conceptual system design for the conventional power plants is proposed. Thermodynamic analysis and techno-economic analysis of the proposed plant are performed. In the proposed system

air preheater in conventional power plant is completely replaced by flue gas-condensate preheater(FGCP)

all the flue gas from the economizer is used to heat partial condensate in FGCP

total air together with the rest of the condensate is preheated by extraction steam

and an extra steam bleed is added to ensure that the air temperature meets the design requirement. The results show that keeping heat-capacity flow-rate of the partial condensate equal to that of flue gas in FGCP can avoid the pinch point of temperature difference of conventional air preheater

and the exit temperature of flue gas from boiler can be reduced to 130 ℃ without cold end corrosion and clog. Steam and air heaters are arranged in series after corresponding RHs

and total air is preferentially heated by extraction steam

which reduces the heat transfer temperature difference between the steam and the condensate. The power generation efficiency and the net power generation efficiency of the novel power plant are 45.34% and 44.20% respectively

increasing 1.2 and 1.0 percentage points compared with that of the conventional unit at the same capacity. The dynamic investment payback period of the modified power plant is about 4.27 years

which is feasible.

关键词

Keywords

references

闵怡, 陈冬林. 300 MW亚临界燃煤锅炉超临界改造的热力特性研究 [J]. 中国电业(技术版), 2016(3): 51-55.

MIN Yi, CHEN Donglin. Study on the thermodynamic property of supercritical reform for 300 MW subcritical coal-fired boiler [J]. China Electric Power(Technology Edition), 2016(3): 51-55.

杨磊磊. 300 MW亚临界机组节能改造技术路线简述 [J]. 节能, 2017, 36(3): 54-57.

YANG Leilei. Energy-saving retrofit technical route of 300 MW subcritical unit [J]. Energy Conservation, 2017, 36(3): 54-57.

刘心纯, 杨波. 300 MW燃煤机组集约型超低排放改造实践 [C]∥中国电机工程学会年会论文集. 北京: 中国电机工程学会, 2016: 1-2.

YANG Y, XU C, XU G, et al. A new conceptual cold-end design of boilers for coal-fired power plants with waste heat recovery [J]. Energy Conversion and Management, 2015, 89: 137-46.

刘鹤忠, 连正权. 低温省煤器在火力发电厂中的运用探讨 [J]. 电力勘测设计, 2010(4): 32-38.

LIU Hezhong, LIAN Zhengquan. Application of low temperature saving coal device in generate electricity power plant [J]. Electric Power Survey and Design, 2010(4): 32-38.

李斌, 党自力. 低温省煤器设计及其动态特性分析 [J]. 热力发电, 2014(2): 25-29.

LI Bin, DANG Zili. Design and dynamic analysis of a low temperature economizer [J]. Thermal Power Generation, 2014(2): 25-29.

MA Y, YANG L, LU J, PEI Y. Techno-economic comparison of boiler cold-end exhaust gas heat recovery processes for efficient brown-coal-fired power generation [J]. Energy, 2016, 116(1): 812-823.

田鑫, 胡清, 孙少鹏, 等. 新型电站锅炉暖风器系统优化分析 [J]. 应用能源技术, 2015(6): 32-35.

TIAN Xin, HU Qing, SUN Shaopeng, et al. The optimization analysis of the new system of the air heater in the utility boiler [J]. Applied Energy Technology, 2015(6): 32-35.

罗宁, 何青. 1 000 MW超超临界机组烟气余热集成利用技术研究 [J]. 电力科学与工程, 2017, 33(6): 42-47.

LUO Ning, HE Qing. Research on integrated utilization technology of flue gas waste heat for 1 000 MW ultra-supercritical unit [J]. Electric Power Science and Engineering, 2017, 33(6): 42-47.

刘彤, 李君, 徐钢, 等. 锅炉前置式空气预热器综合分析与优选 [J]. 华东电力, 2013, 41(8): 1755-1759.

LIU Tong, LI Jun, XU Gang, et al. Comprehensive analysis and optimal selection of front-loading air preheater in utility boiler [J]. East China Electric Power, 2013, 41(8): 1755-1759.

王岩. 660 MW超超临界机组低温省煤器配置方案研究 [J]. 应用能源技术, 2013(7): 28-31.

WANG Yan. The layout plan research of low temperature economizer in 660 MW ultra supercritical coal-fired unit [J]. Applied Energy Technology, 2013(7): 28-31.

ESPATOLERO S, CORTÉS C, ROMEO L M. Optimization of boiler cold-end and integration with the steam cycle in supercritical units [J]. Applied Energy, 2010, 87(5): 1651-1660.

马有福, 杨丽娟. 褐煤锅炉冷端优化热力系统技术经济性比较 [J]. 化工进展, 2016, 35(12): 4088-4095.

MA Youfu, YANG Lijuan. Techno-economic comparison of the thermodynamic system at lignite-fired boiler's cold-end for recovering waste heat of exhaust gases [J]. Chemical Industry and Engineering Progress, 2016, 35(12): 4088-4095.

XU G, XU C, YANG Y, et al. A novel flue gas waste heat recovery system for coal-fired ultra-supercritical power plants [J]. Applied Thermal Engineering, 2014, 67(1/2): 240-249.

STEVANOVIC V D, WALA T, MUSZYNSKI S, et al. Efficiency and power upgrade by an additional high pressure economizer installation at an aged 620 MWe lignite-fired power plant [J]. Energy, 2014, 66(2): 907-918.

郑莆燕, 王乔良, 朱群志, 等. 电站锅炉烟气余热利用方案优化 [J]. 热力发电, 2017(7): 5-11.

ZHEN Puyan, WANG Qiaoliang, ZHU Qunzhi, et al. Optimization on flue gas waste heat recovery scheme in utility boiler [J]. Thermal Power Generation, 2017(7): 5-11.

LIU Y, LI Q, DUAN X, et al. Thermodynamic analysis of a modified system for a 1 000 MW single reheat ultra-supercritical thermal power plant [J]. Energy, 2018, 145: 25-37.

西安热工研究院. 燃煤发电机组能耗分析与节能诊断技术 [M]. 北京: 中国电力出版社, 2014: 19-21.

郑体宽, 杨晨. 热力发电厂 [M]. 北京: 中国电力出版社, 2008: 154-158.

车得福. 锅炉 [M].西安:西安交通大学出版社,2008: 102-105.

古尔维奇, 库兹涅佐夫. 锅炉机组热力计算标准方法 [M]. 北京锅炉厂设计科, 译. 北京: 机械工业出版社, 1976: 49-59.

张华东, 张知翔, 贾兆鹏, 等. 低温省煤器与暖风器联合系统应用 [J]. 热力发电, 2016, 45(10): 127-132.

ZHANG Huadong, ZHANG Zhixiang, JIA Zhaopeng, et al. Application of combined system of low pressure economizer and air heater [J]. Thermal Power Generation, 2016, 45(10): 127-132.

ZHANG H G, WANG E H, FAN B Y. Heat transfer analysis of a finned-tube evaporator for engine exhaust heat recovery [J]. Energy Conversion and Management, 2013, 65(1): 438-47.

HAN Y, XU G, ZHENG Q, et al. New heat integration system with bypass flue based on the rational utilization of low-grade extraction steam in a coal-fired power plant [J]. Applied Thermal Engineering, 2017, 113: 460-471.

林宗虎, 徐通模. 实用锅炉手册 [M]. 北京: 化学工业出版社, 2009: 550-568.

卓宁, 孙家庆. 工程对流换热 [M]. 北京: 机械工业出版社, 1991: 136-139.

蔡明坤. 几种回转式空气预热器密封结构的比较 [J]. 锅炉技术, 2011, 42(2): 8-13.

CAI Mingkun. Comparison of different manners for air preheater leakage control [J]. Boiler Technology, 2011, 42(2): 8-13.

吴志祥, 王存新. 1 000 MW机组高位收水冷却塔项目的技术经济性分析 [J]. 东北电力大学学报, 2016, 36(3): 34-40.

WU Zhixiang, WANG Cunxin. Technical and economic analysis of the project of the high water cooling tower of 1 000 MW unit [J]. Journal of Northeast Dianli University, 2016, 36(3): 34-40.

刘亚臣. 工程经济学 [M]. 大连: 大连理工大学出版社, 2008: 53-54.

王朝阳,常仁杰,朱庆玉,等.两种水煤比控制策略下调峰机组的能耗特性.2018,52(7):115-122.[doi:10.7652/xjtuxb 201807017]

林宗虎.中国燃煤锅炉节能减排技术近况及展望.2016,50(12):1-5.[doi:10.7652/xjtuxb201612001]

邱硕,王雪强,毕胜山,等.模型下的陕西省节能与温室气体减排潜力分析.2016,50(11):28-35.[doi:10.7652/xjtuxb 201611005]

王佳莹,高毅超,曹越,等.湿空气透平循环的压缩空气储能热电联供系统热力学分析.2016,50(7):26-31.[doi:10.7652/xjtuxb201607005]

姚尔人,王焕然,席光.一种压缩空气储能与内燃机技术耦合的冷热电联产系统.2016,50(1):22-27.[doi:10.7652/xjtuxb201601004]

韩小渠,严俊杰,穆祺伟,等.褐煤烟气预干燥发电系统变工况特性的仿真研究.2015,49(1):27-33.[doi:10.7652/xjtuxb201501005]

金阳,刘海峰,郑晓泉,等.110 kV变电站高压裸线扩径增强绝缘护套研究.2014,48(12):34-40.[doi:10.7652/xjtuxb 201412006]

李千军,刘光耀,韩伟,等.采用喷射式热泵提高火电机组给水温度的理论研究.2013,47(11):25-28.[doi:10.7652/xjtuxb201311005]

严俊杰,刘明,种道彤,等.预干燥燃褐煤发电系统理论研究.2011,45(5):1-5.[doi:10.7652/xjtuxb201105001]

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

两种多等级运行的压缩二氧化碳储能系统综合性能对比

一种带中间换热器的双热源高温热泵系统

一种新型压缩空气与抽水复合储能系统的热力学分析

船用燃气轮机超临界CO2/有机闪蒸余热回收循环的热力学分析