地面停放低温液氧贮箱热物理过程研究

刘展 1; 孙培杰 2; 李鹏 2; 厉彦忠 1; 晋永华 1

doi:10.7652/xjtuxb201609006

您当前的位置：

首页 >

文章列表页 >

地面停放低温液氧贮箱热物理过程研究

更新时间：2025-07-09

- 地面停放低温液氧贮箱热物理过程研究
- Research on the Thermal Physical Process of Cryogenic Liquid Oxygen Tank in Ground Parking
- 西安交通大学学报 2016年50卷第9期页码：36-42
- 作者机构：
  
  西安交通大学能源与动力工程学院,西安,710049
- 作者简介：
- 基金信息：
  
  : 2016-01-27。作者简介: 刘展(1988—),男,博士生;厉彦忠(通信作者),男,教授。基金项目: 国家自然科学基金资助项目(51376142);航天低温推进剂技术国家重点实验室开放课题(SKLTSCP1505);上海航天核攀项目(ZY2015-015)
- DOI：10.7652/xjtuxb201609006
  中图分类号： V511
- 网络首发：2016-09-10，
  
  纸质出版：2016
- 稿件说明：
移动端阅览
刘展 1, 孙培杰 2, 李鹏 2, 等. 地面停放低温液氧贮箱热物理过程研究[J]. 西安交通大学学报, 2016,50(9):36-42.

Research on the Thermal Physical Process of Cryogenic Liquid Oxygen Tank in Ground Parking[J]. 2016, 50(9): 36-42.
刘展 1, 孙培杰 2, 李鹏 2, 等. 地面停放低温液氧贮箱热物理过程研究[J]. 西安交通大学学报, 2016,50(9):36-42. DOI： 10.7652/xjtuxb201609006.

Research on the Thermal Physical Process of Cryogenic Liquid Oxygen Tank in Ground Parking[J]. 2016, 50(9): 36-42. DOI： 10.7652/xjtuxb201609006.

摘要

针对低温推进剂箱体射前停放阶段

采用CFD技术数值研究了某低温液氧贮箱在地面停放阶段所经历的开口放置及高温气氧预增压过程。详细分析了该过程中箱体的压力变化、气液相变以及热分层现象。通过与相关试验结果对比

验证了本数值模型的有效性。计算结果表明:在液氧箱体开口停放阶段

在外部漏热下

箱体内部将出现剧烈的沸腾相变现象

并伴随着大量气泡的产生。随着时间的增加

用于低温流体相变的热量主要来自于外部漏热

此时相变过程主要发生在气液界面。在约150 s时

相变强度逐渐趋于稳定。经过250 s的地面开口停放

蒸发气体排放量约6.88 kg。当低温箱体封闭

预增压过程开始

箱体压力将在所设定的压力上下限内波动变化。由于气相过热、液相过冷

在整个过程中气相都处于冷凝状态。随着高温气体的注入

气相质量呈现波动变化

由15.84 kg增加到27.27 kg。液相质量则近似线性增加

由最初的12 243.10 kg增加到12 303.95 kg。气液界面以下的液相呈现出较好的温度分层

气相温度分布则受增压气体影响较大

产生了一定的扰动。

Abstract

The computational fluid dynamics(CFD)was used to investigate the pressurization process of cryogenic liquid oxygen tank including the open parking and pre-pressurization stages in the ground parking before launch. The tank pressure change

liquid-vapor phase change and fluid thermal stratification were analyzed in detail. The present CFD model was proven to have effective prediction ability in comparison with the experimental results. The results showed that under the external heat leakage

the intensive boiling phase change occurred in the tank with a large amount of gas bubbles moving upwards in the fluid during the ground open parking stage. As the heat used to generate phase change became less and mainly from the external heat leakage

the phase change intensity became weak and tended to stable in about 150 s

with the phase change focused on the interface. The total evaporation loss was about 6.88 kg for 250 s ground open parking. When the cryogenic liquid oxygen tank was locked and the ground pre-pressurization started

the tank pressure fluctuated between the maximum and minimum pressure limits. As the ullage was superheated and the liquid was subcooled

the ullage condensation appeared in the whole pre-pressurization process. With the high temperature gas injecting into the tank

the ullage mass presented fluctuation change

with the value increasing from 15.84 kg to 27.27 kg. While the liquid mass displayed an almost linear increasing tendency

and rose from 12 243.10 kg to 12 303.95 kg. An obvious thermal stratification appeared in the liquid region below the liquid-vapor interface

while the ullage was largely influenced by the injection gas with some disturbances.

关键词

Keywords

references

AYDELOTT J C. Normal gravity self-pressurization of 9-inch(23 cm)diameter spherical liquid hydrogen tankage: NASA TN D-4171 [R]Washington, DC, USA: National Aeronautics and Space Administration, 1967: 1-47.

PANZARELLA C H, KASSEMI M. Self-pressurization of large spherical cryogenic tanks in space [J]. Journal of Spacecraft Rockets, 2005, 42(2): 299-308.

STEPHEN B, CHARLES P, MOHAMMAD K. An active vapor approach to modeling pressurization in cryogenic storage tanks [C]∥Proceedings of 43rd AIAA/ASME/SAE/ASEE Joint Propulsion Conference Exhibit. Reston, VA, USA: AIAA, 2007: 1-17.

WINTER A, MARCHETTA J. An energy of fluid(EOF)approach to modeling self pressurization in propellant tanks [C]∥Proceedings of 47th AIAA Aerospace Sciences Meeting Including the New Horizons Forum and Aerospace Exposition. Reston, VA, USA: AIAA, 2007: 1-7.

SIM J, KUAN C K, SHYY W. Simulation of spacecraft fuel tank self-pressurization using Eulerian-Lagrangian method [C]∥Proceedings of 49th AIAA Aerospace Science Meeting Including the New Horizons Forum and Aerospace Exposition. Reston, VA, USA: AIAA, 2011: 1-20.

LUDWIG C, DREYER M E. Investigations on thermodynamic phenomena of the active-pressurization process of a cryogenic propellant tank [J]. Cryogenics, 2014, 63: 1-16.

WANG L, LI Y, ZHAO Z, et al. Transient thermal and pressurization performance of LO 2 tank during helium pressurization combined with outside aerodynamic heating [J]. International Journal of Heat and Mass Transfer, 2013, 62: 263-271.

LOPEZ A, GRAYSON G D, CHANDLER F O, et al. Cryogenic pressure control modeling for ellipsoidal space tanks [C]∥Proceedings of 43rd AIAA/ASME/SAE/ASEE Joint Propulsion Conference Exhibit. Reston, VA, USA: AIAA, 2007: 1-8.

LOPEZ A, GRAYSON G D, CHANDLER F O, et al. Cryogenic pressure control modeling for ellipsoidal space tanks in reduced gravity [C]∥Proceedings of 44th AIAA/ASME/SAE/ASEE Joint Propulsion Conference Exhibit. Reston, VA, USA: AIAA, 2008: 1-9.

代予东, 赵红轩. 运用数学方法模拟推进剂贮箱增压 [J]. 火箭推进, 2003, 29(3): 34-40.

DAI Yudong, ZHAO Hongxuan. Numerical modeling of pressurization of a propellant tank [J]. Journal of Rocket Propulsion, 2003, 29(3): 34-40.

范瑞祥, 黄兵, 田玉蓉. 高温气体增压对液氧贮箱壁面温度影响研究 [J]. 导弹与航天运载技术, 2013(5): 76-81.

FAN Runxiang, HUANG Bing, TIAN Yurong. Study of the effect of high-temperature gas pressurization on LOX tank wall temperature [J]. Missiles and Space Vehicles, 2013(5): 76-81.

陈春富, 李茂, 王树光. 液氧贮箱增压过程研究 [J]. 火箭推进, 2013, 39(4): 80-84.

CHEN Chunfu, LI Mao, WANG Shuguang. Numerical study on pressurization process of liquid oxygen tank [J]. Journal of Rocket Propulsion, 2013, 39(4): 80-84.

刘展, 厉彦忠, 王磊, 等. 在轨运行低温液氢箱体蒸发量计算与增压过程研究 [J]. 西安交通大学学报, 2015, 49(2): 135-140.

LIU Zhan, LI Yanzhong, WANG Lei, et al. Evaporation calculation and pressurization process of on-orbit cryogenic liquid hydrogen storage tank [J]. Journal of Xi'an Jiaotong University, 2015, 49(2): 135-140.

LIU Z, WANG L, JIN Y, et al. Development of thermal stratification in a rotating cryogenic liquid hydrogen tank [J]. International Journal of Hydrogen Energy, 2015, 40(43): 15067-15077.

杨世铭, 陶文铨. 传热学 [M]. 北京: 高等教育出版社, 2006: 258-259.

ARNDT T, DREYER M, BEHRUZI P, et al. Cryogenic sloshing tests in a pressurized cylindrical reservoir [C]∥Proceedings of 45th AIAA/ASME/SAE/ASEE Joint Propulsion Conference Exhibit. Reston, VA, USA: AIAA, 2009: 1-10.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

超临界二氧化碳向心透平轮背间隙内风阻损失及流动特性研究

水蒸气掺混对氨裂解气旋流燃烧与排放特性的影响研究

混合电解槽阵列协同的风光耦合制氢系统双层多目标优化

扇贝仿生密封腔室内超临界二氧化碳泄漏流湍动能耗散机理研究

面向高海拔空冷发电机防晕性能演化规律的电热耦合研究