R134a/R23复叠制冷系统级间容量比的优化分析

乔亦圆 1; 杨东方 1; 曹锋 1; 黄振华 2

doi:10.7652/xjtuxb201602018

您当前的位置：

首页 >

文章列表页 >

R134a/R23复叠制冷系统级间容量比的优化分析

更新时间：2025-07-09

- R134a/R23复叠制冷系统级间容量比的优化分析
- Optimization of Compressors Displacement Ratio in R134a/R23 Cascade Refrigeration System
- 西安交通大学学报 2016年50卷第2期页码：104-110
- 作者机构：
  
  西安交通大学能源与动力工程学院,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb201602018
  中图分类号： TB61
- 网络首发：2016-02-10，
  
  纸质出版：2016
- 稿件说明：
移动端阅览
乔亦圆 1, 杨东方 1, 曹锋 1, 等. R134a/R23复叠制冷系统级间容量比的优化分析[J]. 西安交通大学学报, 2016,50(2):104-110.

Optimization of Compressors Displacement Ratio in R134a/R23 Cascade Refrigeration System[J]. 2016, 50(2): 104-110.
乔亦圆 1, 杨东方 1, 曹锋 1, 等. R134a/R23复叠制冷系统级间容量比的优化分析[J]. 西安交通大学学报, 2016,50(2):104-110. DOI： 10.7652/xjtuxb201602018.

Optimization of Compressors Displacement Ratio in R134a/R23 Cascade Refrigeration System[J]. 2016, 50(2): 104-110. DOI： 10.7652/xjtuxb201602018.

摘要

为了提高复叠制冷系统的性能以及优化系统设计时各循环压缩机的匹配问题

提出了无量纲参数——级间容量比

即低温循环压缩机进口处的体积流量与高温循环压缩机进口处的体积流量之比。建立了复叠制冷系统的数学模型

分析了级间容量比对中间温度和系统性能系数(COP)的影响

并在蒸发温度为-75～-55 ℃、冷凝温度为20～50 ℃及复叠温差为5～13 ℃的各种工况下

探究了最优级间容量比与工况参数的关系。结果表明:若级间容量比增加

则中间温度增加

COP先增加后缓慢减小

存在使COP最大的最优级间容量比; 工况温度对COP的影响大于级间容量比对COP的影响

随冷凝温度上升

最优级间容量增大

蒸发温度上升

最优级间容量比增大; 复叠温差增大

最优级间容量比减小; 冷凝温度、蒸发温度及复叠温差平均每上升10 ℃

最优级间容量比变化范围为0.1～0.2。由工况参数和最优级间容量比的计算结果拟合得到了优化关联式

其计算思路和结果分析可为实际设计中各循环压缩机排量的选型匹配提供理论依据。

Abstract

A dimensionless parameter

the compressor displacement ratio

is proposed to investigate the performance of the R134a/R23 cascade system and optimize the match of compressors of the system. The parameter is defined as the ratio of the compressor inlet volume flow rates between the low temperature cycle and the high temperature cycle. A numerical model is established to analyze the effect of the displacement ratio on the COP and the intermediate temperature. The relationship between the optimal displacement ratio and the operating parameters is discussed under various conditions when the evaporating temperature

condensing temperature and cascade temperature difference are ranged within -75～-55 ℃

20～50 ℃ and 5～13 ℃

respectively. The results show that the intermediate temperature increases with the displacement ratio

while the COP rises first and then drops slowly. The variation of the operating temperature exerts a stronger impact on the COP than the displacement ratio. The optimal displacement ratio increases with the condensing temperature and the evaporation temperature

and decreases when the cascade temperature difference rises. The correlations of the optimal displacement ratio are obtained by fitting data of the working condition parameters and the optimum compressor displacement ratio.

关键词

Keywords

references

赖芬, 吴裕远, 欧阳前武, 等. 新型部分自复叠热泵的理论研究 [J]. 西安交通大学学报, 2012, 46(3): 15-20.

LAI Fen, WU Yuyuan, OUYANG Qianwu, et al. Theoretical research on a new partial auto-cascade heat pump [J]. Journal of Xi'an Jiaotong University, 2012, 46(3): 15-20.

颜俊, 任挪颖, 钱伟, 等. R600a/CO2一级分凝和二级分凝自复叠制冷循环的性能研究 [J]. 西安交通大学学报, 2007, 41(3): 321-325.

YAN Jun, Ren Nuoying, QIAN Wei, et al. Performance study on R600a/CO2 auto-cascade refrigerating cycle with one-step dephlegmation and two-step dephlegmation [J]. Journal of Xi'an Jiaotong University, 2007, 41(3): 321-325.

DA SILVA A, BANDARRA FILHO E P, ANTUNES A H P. Comparison of a R744 cascade refrigeration system with R404A and R22 conventional systems for supermarkets [J]. Applied Thermal Engineering, 2012, 41: 30-35.

PARK H, KIM D H, KIM M S. Thermodynamic analysis of optimal intermediate temperatures in R134a-R410A cascade refrigeration systems and its experimental verification [J]. Applied Thermal Engineering, 2013, 54(1): 319-327.

MA Ming, YU Jianlin, WANG Xiao. Performance evaluation and optimal configuration analysis of a CO2/NH3 cascade refrigeration system with falling film evaporator-condenser [J]. Energy Conversion and Management, 2014, 79(1): 224-231.

ALBERTO DOPAZO J, FERNÁNDEZ-SEARA J, SIERES J, et al. Theoretical analysis of a CO2-NH3 cascade refrigeration system for cooling applications at low temperatures [J]. Applied Thermal Engineering, 2009, 29(8): 1577-1583.

KILICARSLAN A. An experimental investigation of a different type vapor compression cascade refrigeration system [J]. Applied Thermal Engineering, 2004, 24(17): 2611-2626.

RATTS E B, BROWN J S. A generalized analysis for cascading single fluid vapor compression refrigeration cycles using an entropy generation minimization method [J]. International Journal of Refrigeration, 2000, 23(5): 353-365.

MAFI M, NAEYNIAN S M, AMIDPOUR M. Exergy analysis of multistage cascade low temperature refrigeration systems used in olefin plants [J]. International Journal of Refrigeration, 2009, 32(2): 279-294.

赖艳华, 董震, 邵长波, 等. R404A/CO2复叠式制冷系统的热力学分析与优化 [J]. 山东大学学报: 工学版, 2011, 41(2): 149-153.

LAI Yanhua, DONG Zhen, SHAO Changbo, et al. Thermodynamic analysis and optimization of R404A/CO2 cascade refrigeration system [J]. Journal of Shandong University: Engineering Science, 2011, 41(2): 149-153.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

混合工质成分对自复叠冷冻干燥装置降温速率的影响

求解约束优化问题的多成员人工蜂群算法

特高压交流套管尾部均压球结构优化研究

考虑气动和湿汽损失综合影响的低压多级透平优化

用于环境嵌入式系统的多时段动态功耗管理方法