翅片管式蒸发器超声波除霜理论与技术研究

谭海辉 1; 陶唐飞 1; 2; 徐光华 1; 3; 万翔 1; 张鑫 1

doi:10.7652/xjtuxb201509018

您当前的位置：

首页 >

文章列表页 >

翅片管式蒸发器超声波除霜理论与技术研究

更新时间：2025-07-09

- 翅片管式蒸发器超声波除霜理论与技术研究
- Ultrasonic Defrosting Theory and Technology for Finned-Tube Evaporator
- 西安交通大学学报 2015年49卷第9期页码：105-113
- 作者机构：
  
  西安交通大学机械工程学院,西安,710049
- 作者简介：
- 基金信息：
  
  : 2015-02-13。作者简介: 谭海辉(1984—),男,博士生;徐光华(通信作者),男,教授,博士生导师。基金项目: 陕西省科学技术研究发展计划资助项目(2012k09-16)
- DOI：10.7652/xjtuxb201509018
  中图分类号： TB65
- 网络首发：2015-09-10，
  
  纸质出版：2015
- 稿件说明：
移动端阅览
谭海辉 1, 陶唐飞 1, 2, 等. 翅片管式蒸发器超声波除霜理论与技术研究[J]. 西安交通大学学报, 2015,49(9):105-113.

Ultrasonic Defrosting Theory and Technology for Finned-Tube Evaporator[J]. 2015, 49(9): 105-113.
谭海辉 1, 陶唐飞 1, 2, 等. 翅片管式蒸发器超声波除霜理论与技术研究[J]. 西安交通大学学报, 2015,49(9):105-113. DOI： 10.7652/xjtuxb201509018.

Ultrasonic Defrosting Theory and Technology for Finned-Tube Evaporator[J]. 2015, 49(9): 105-113. DOI： 10.7652/xjtuxb201509018.

摘要

针对传统逆除霜技术能耗高、热舒适度差的问题

研究应用于翅片管式蒸发器的超声波除霜新技术。结合MATLAB数值求解方法与有限元压电结构耦合仿真方法

分析蒸发器结构中的频散曲线

确定蒸发器结构中的超声导波类型、模态及导波传播特性

并将超声频散曲线分析结果与有限元仿真结果进行对比。研究结果表明

在激励频率小于250 kHz时

蒸发器翅片上存在Lamb波的A0和S0模态以及SH波的SH0模态

Lamb波在翅片与霜层界面处激发破碎应力

SH波激发剪切应力; 翅片上振动以Lamb波的S0模态为主

铜管上可以清楚看到对称的纵向模态

有限元仿真结果与频散曲线分析结果完全吻合; 超声除霜试验与能耗分析结果表明

超声除霜能耗不到传统逆除霜能耗的1/22

除霜效率至少提高了7倍

是一种高效、低能耗的翅管式换热器除霜新技术。

Abstract

Aiming at the high energy consumption

low thermal comfort of traditional reverse cycle defrosting technology

a new ultrasonic defrosting technology for finned-tube evaporator

is investigated. Combining the MATLAB numerical method with the finite element analysis method of piezoelectric-structure coupling simulation

the dispersion curve in the evaporator structure is analyzed and the type

mode and transmission characteristics of ultrasonic wave in the evaporator structure are determined. The ultrasonic frequency dispersion curve analysis results and finite element simulation results are compared. It is found that the A0 and S0 mode of Lamb wave and SH0 mode of SH wave exist in the fin when the excitation is less than 250 kHz

and the crushing stress and the shear stress at the interface between fin and frost layer are excited by Lamb wave and SH wave

respectively. The vibration mode in the fin is primarily the S0 mode of Lamb wave

the symmetrical longitudinal mode obviously appears in the tube

and the finite element simulation results coincide well with the calculation results of ultrasonic dispersion curve. The ultrasonic defrosting experiments and energy consumption analysis indicates that the ultrasonic defrosting energy consumption is less than 1/22 of the traditional reverse cycle defrosting and the defrosting efficiency is improved more than 7 times.

关键词

Keywords

references

董建锴, 姜益强, 姚杨, 等. 空气源热泵相变蓄能除霜蓄能特性实验研究 [J]. 土木建筑与环境工程, 2011, 33(2): 74-79.

DONG Jiankai, JIANG Yiqiang, YAO Yang, et al. Experimental analysis on characteristics of energy storage for defrosting of air source heat pump with phase change energy storage [J]. Journal of Civil, Architectural & Environmental Engineering, 2011, 33(2): 74-79.

郭宪民, 王善云, 汪伟华, 等. 环境参数对空气源热泵蒸发器表面霜层影响研究 [J]. 西安交通大学学报, 2011, 45(3): 30-34.

GUO Xianmin, WANG Shanyun, WANG Weihua, et al. Effect of environmental condition on evaporator surface frost layer for air source heat pump [J]. Journal of Xi'an Jiaotong University, 2011, 45(3): 30-34.

姚杨, 姜益强, 马最良. 翅片管换热器结霜时霜密度和厚度的变化 [J]. 工程热物理学报, 2003, 24(6): 1040-1042.

YAO Yang, JIANG Yiqiang, MA Zuiliang. Change of frost density and thickness for finned-tube heat exchanger under frosting [J]. Journal of Engineering Thermophysics, 2003, 24(6): 1040-1042.

WU Xiaomin, RALPH L W. Investigation of the possibility of frost release from a cold surface [J]. Experimental Thermal and Fluid Science, 2011, 24(3/4): 151-156.

阎勤劳, 朱琳, 张密娥, 等. 冷风机超声波除霜技术试验研究 [J]. 农业机械学报, 2003, 34(4): 74-75.

YAN Qinlao, ZHU Lin, ZHANG Mi'e, et al. Study on ultrasonic defrost technology of refrigeration fan [J]. Journal of Agriculture and Machine, 2003, 34(4): 74-75.

LI Dong, CHEN Zhenqian, SHI Mingheng. Effect of ultrasound on frost formation on a cold flat surface in atmospheric air flow [J]. Experimental Thermal and Fluid Science, 2010, 34(8): 1247-1252.

TAN Haihui, TAO Tangfei, XU Guanghua, et al. Experimental study on defrosting mechanism of intermittent ultrasonic resonance for a finned-tube evaporator [J]. Experimental Thermal and Fluid Science, 2014, 52: 308-317.

OVERMEYER A, PALACIOS J L, SMITH E C. Actuator bonding optimization and system control of a rotor blade ultrasonic deicing system [C/OL]∥53rd AIAA/ASME/ASCE/AHS/ASC structural, structural dynamics, and materials conference, Honolulu, Hawaii, April 23-26, 2012 [2015-01-24]. http: ∥arc. aiaacg/doi/pdf/10.2514/6.2012-1476.

ZHU Yun, PALACIOS J L, ROSE J L, et al. De-icing of multi-layer composite plates using ultrasonic guided waves [C/OL]∥49th AIAA/ASME/ASCE/AHS/ASC Structures, Structural Dynamics and Materials Conference, Schaumburg, IL, April 7-10, 2008 [2014-12-12]. http: ∥arc.aiaa.org/doi/pdf/10. 2514 /6.2008-1862.

ROSE J L. Ultrasonic waves in solid media [M]. Cambridge, UK: Cambridge University Press, 2014: 155-275.

李录平, 谭海辉, 卢绪祥, 等. 层状结构中的超声传播理论及其在风力机桨叶除冰中的应用 [J]. 中国电机工程学报, 2012, 32(17): 125-132.

LI Luping, TAN Haihui, LU Xuxiang, et al. Ultrasonic propagation theory in multi-layer composite structure and its application to blade de-icing of wind turbine [J]. Proceedings of the CSEE, 2012, 32(17): 125-132.

谭海辉, 李录平, 靳攀科, 等. 风力机叶片超声波除冰理论与方法 [J]. 中国电机工程学报, 2010, 30(35): 112-117.

TAN Haihui, LI Luping, JIN Panke, et al. Ultrasonic de-icing theory and method for wind turbine blades [J]. Proceedings of the CSEE, 2010, 30(35): 112-117.

PALACIOS J L, SMITH E C, GAO Huidong, et al. Ultrasonic shear wave anti-icing system for helicopter rotor blades [C/OL]∥American Helicopter Society 62nd Annual Forum, Phoenix, AZ, May 9-11, 2006 [2014-12-16]. http: ∥citeseerx.ist.psu. edu/viewdoc/download?doi=10.1.1. 131.8425rep=rep1type=pdf.

JANG Jingyong, BAE H H, LEE S L, et al. Continuous heating of an air-source heat pump during defrosting and improvement of energy efficiency [J]. Applied Energy, 2013, 110: 9-16.

QU Minglu, LIANG Xia, DENG Shiming, et al. A study of the reverse cycle defrosting performance on a multi-circuit outdoor coil unit in an air source heat pump: Part I Experiments [J]. Applied Energy, 2012, 91(1): 122-129.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

隧道内燃料电池汽车氢气泄漏扩散特性及影响因素

采用试验设计方法的第三代CO2气体箔轴承箔片几何参数敏感性分析

超临界水异常区域热力学特性研究

不同板叠材料热声热机能量转换过程数值模拟研究

多工况下离心压气机叶轮-机匣一体联合设计优化