换热器内弹性管束流体组合诱导振动响应的数值分析

季家东 1; 葛培琪 1; 2; 毕文波 1

doi:10.7652/xjtuxb201509005

您当前的位置：

首页 >

文章列表页 >

换热器内弹性管束流体组合诱导振动响应的数值分析

更新时间：2025-07-09

- 换热器内弹性管束流体组合诱导振动响应的数值分析
- Numerical Analysis on the Combined Flow Induced Vibration Response of Elastic Tube Bundle in Heat Exchanger
- 西安交通大学学报 2015年49卷第9期页码：24-29
- 作者机构：
  
  山东大学机械工程学院,济南,250061
- 作者简介：
- 基金信息：
  
  : 2015-03-16。作者简介: 季家东(1982—),男,博士生;葛培琪(通信作者),男,教授,博士生导师。基金项目: 国家自然科学基金资助项目(51475268);国家重点基础研究发展计划资助项目(2007CB206903)
- DOI：10.7652/xjtuxb201509005
  中图分类号： TH123;TK172
- 网络首发：2015-09-10，
  
  纸质出版：2015
- 稿件说明：
移动端阅览
季家东 1, 葛培琪 1, 2, 等. 换热器内弹性管束流体组合诱导振动响应的数值分析[J]. 西安交通大学学报, 2015,49(9):24-29.

Numerical Analysis on the Combined Flow Induced Vibration Response of Elastic Tube Bundle in Heat Exchanger[J]. 2015, 49(9): 24-29.
季家东 1, 葛培琪 1, 2, 等. 换热器内弹性管束流体组合诱导振动响应的数值分析[J]. 西安交通大学学报, 2015,49(9):24-29. DOI： 10.7652/xjtuxb201509005.

Numerical Analysis on the Combined Flow Induced Vibration Response of Elastic Tube Bundle in Heat Exchanger[J]. 2015, 49(9): 24-29. DOI： 10.7652/xjtuxb201509005.

摘要

为了探讨换热器内弹性管束在流体诱导下的振动特性

采用流固耦合的弱耦合法

研究了弹性管束在不同流速的壳程和管程两场流体组合诱导下的振动响应

并对比分析了壳程流体和管程流体对弹性管束振动响应的影响。研究表明:当壳程和管程流速一定时

弹性管束两监测点各方向的振动主频、谐频大小一致

且振动主要体现为面内振动。壳程流速较低时

监测点沿壳程流速方向的位移曲线存在明显的二倍谐频。壳程流速变化对管束振动响应的影响较大

管程流速变化对管束振动响应的影响较小

说明弹性管束的振动主要由壳程流体引起。由于流体的冲击和管束重力的影响

当壳程流速较低时

管束沿壳程流速方向的振动平衡位置较低

随着流速的增加

管束沿壳程流速方向的振动平衡位置逐渐上移。

Abstract

The vibration characteristics of the elastic tube bundle in heat exchanger

under the combined induction of shell-side and tube-side cross flows at different inlet water velocities are studied using weak coupling method of fluid-structure interaction. And the influences of shell-side and tube-side cross flows on the vibration responses of the elastic tube bundle are also analyzed comparatively. Numerical results show that the flow-induced dominant and harmonic frequency vibration frequencies

at the two monitor points of the elastic tube bundle and under the same water velocity

are uniform in all directions; and the flow-induced vibration is mainly an in-plane vibration. There is an obvious second harmonic frequency in the shell-side water flow direction at the two monitor points when the water velocity is relatively low. Compared with the change of the shell-side water velocity

the variation of the tube-side inlet flow velocity has less effect on the vibration response. It shows that the vibration is mainly induced by the shell-side cross flow. Furthermore

the vibration balance position of the elastic tube bundle in shell-side water flow direction is also low when the velocity is low

due to the influences of the gravity of tube bundle and the impact force of fluid; and the vibration balance position gradually moves up with the increase of the shell-side water velocity.

关键词

Keywords

references

程林. 弹性管束换热器原理与应用 [M]. 北京: 科学出版社, 2001: 34-67.

CHENG Lin, LUAN Ting, DU Wenjing, et al. Heat transfer enhancement by flow-induced vibration in heat exchangers [J]. International Journal of Heat and Mass Transfer, 2009, 52(3): 1053-1057.

YAN Ke, GE Peiqi, HONG Jun. Experimental study of shell side flow-induced vibration of conical spiral tube bundle [J]. Journal of Hydrodynamics, 2013, 25(5): 695-701.

JIANG Bo, TIAN Maocheng, CHENG Lin. Research on vibration and heat transfer characteristics of an optimized structure of elastic tube bundle [J]. Advanced Materials Research, 2013, 816/817: 260-265.

闫柯, 葛梦然, 高军, 等. 空间锥螺旋管束流体诱导振动换热器及性能分析 [J]. 西安交通大学学报, 2011, 45(11): 22-26.

YAN Ke, GE Mengran, GAO Jun, et al. Performance of flow-induced vibration heat exchanger with conical spiral tube bundle [J]. Journal of Xi'an Jiaotong University, 2011, 45(11): 22-26.

闫柯, 葛培琪, 宿艳彩. 基于复模态的空间锥螺旋管管内流固耦合振动特性的有限元分析 [J]. 振动与冲击, 2011, 31(1): 204-207.

YAN Ke, GE Peiqi, SU Yancai. FEM analysis for fluid-structure interaction in a dimensional helical tube base on complex mode theory [J]. Journal of Vibration and Shock, 2011, 31(1): 204-207.

姜波, 郝卫东, 刘福国, 等. 流体脉动对新型弹性管束传热特性影响的实验研究 [J]. 振动与冲击, 2012, 31(10): 59-63.

JIANG Bo, HAO Weidong, LIU Fuguo, et al. Experiments on effects of fluid pulsation on heat transfer characteristics of the new type elastic tube bundle [J]. Journal of Vibration and Shock, 2012, 31(10): 59-63.

闫柯. 换热器内锥螺旋弹性管束振动与传热特性研究 [D]. 济南: 山东大学, 2012.

YAN Ke, GE Peiqi, HU Ruirong, et al. Heat transfer and resistance characteristics of conical spiral tube bundle based on field synergy principle [J]. Chinese Journal of Mechanical Engineering, 2012, 25(2): 370-376.

宿艳彩. 弹性管束流体诱导振动及换热特性研究 [D]. 济南: 山东大学, 2012.

张凡,李兆辉,李晓宇,等.不同材料翅片管换热器特性的实验研究.2015,49(5):62-67.[doi:10.7652/xjtuxb201505010]

文键,杨辉著,王斯民,等.旋梯式螺旋折流板换热器优化结构的数值模拟.2014,48(11):8-14.[doi:10.7652/xjtuxb 201411002]

杨卫卫,曹兴起,何雅玲,等.一种带中间换热器的双热源高温热泵系统.2014,48(11):70-74.[doi:10.7652/xjtuxb 201411012]

文键,杨辉著,杜冬冬,等.螺旋折流板换热器换热强化的数值研究.2014,48(9):43-48.[doi:10.7652/xjtuxb201409008]

韩辉,何雅玲,唐桂华.硫酸蒸气在换热器表面沉积特性的数值研究.2013,47(11):7-13.[doi:10.7652/xjtuxb201311002]

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

采用不同管排组合的换热器弹性管束壳程流体诱导振动响应

换热器内逆向折流板对螺旋管传热性能的影响

小型气体水合物蓄冷装置的实验研究

中空纤维膜换热器传热传质特性的实验和理论研究

利用能量守恒和径向基函数插值的流固耦合界面数据传递方法