交流伺服系统永磁同步电机电流及位置二级状态观测器设计

郝双晖; 王磊; 宋宝玉; 郝明晖

doi:10.7652/xjtuxb201505016

您当前的位置：

首页 >

文章列表页 >

交流伺服系统永磁同步电机电流及位置二级状态观测器设计

更新时间：2025-07-09

- 交流伺服系统永磁同步电机电流及位置二级状态观测器设计
- Second Level State Observer of Current and Position for Permanent Magnet Synchronous Motor on AC Control System Model
- 西安交通大学学报 2015年49卷第5期页码：100-107+115
- 作者机构：
  
  哈尔滨工业大学机电工程学院,哈尔滨,150001
- 作者简介：
- 基金信息：
  
  : 2014-10-21。作者简介: 王磊(1986—),男,博士生;郝明晖(通信作者),男,教授,博士生导师。基金项目: 国家自然科学基金资助项目(50975057)
- DOI：10.7652/xjtuxb201505016
  中图分类号： TH-39
- 网络首发：2015-05-10，
  
  纸质出版：2015
- 稿件说明：
移动端阅览
郝双晖, 王磊, 宋宝玉, 等. 交流伺服系统永磁同步电机电流及位置二级状态观测器设计[J]. 西安交通大学学报, 2015,49(5):100-107+115.

Second Level State Observer of Current and Position for Permanent Magnet Synchronous Motor on AC Control System Model[J]. 2015, 49(5): 100-107+115.
郝双晖, 王磊, 宋宝玉, 等. 交流伺服系统永磁同步电机电流及位置二级状态观测器设计[J]. 西安交通大学学报, 2015,49(5):100-107+115. DOI： 10.7652/xjtuxb201505016.

Second Level State Observer of Current and Position for Permanent Magnet Synchronous Motor on AC Control System Model[J]. 2015, 49(5): 100-107+115. DOI： 10.7652/xjtuxb201505016.

摘要

为了提高交流伺服控制系统的反馈精度

并消除反馈信号的滞后问题

针对永磁同步电机电压控制模型及其运动学控制模型进行深入分析

并在此基础上对控制系统反馈环节的工作时序进行分析

得到了电流及位置反馈环节的滞后周期数

提出电流及位置一级状态观测器。通过当前控制周期反馈位置及电流值

对下一个控制周期的电流及反馈位置值进行精确估计

并将一级状态观测器的观测输出值作为二级状态观测器的输入

进一步抑制电流及位置反馈信号的高频振荡及时滞。结果表明:二级电流及位置状态观测器对反馈信号的高频噪声起到明显的抑制作用

并对反馈值进行了准确的预计观测; 二级位置观测误差小于0.005 rad

并消除了反馈中夹杂的高频噪声。将该方法应用于交流伺服控制系统中

进行高速高响应定位控制

响应频率达到200 Hz

加速度达到62 831 rad/s

此时系统相电流稳定

定位精度达到1.5°

从而实现了电流及位置的精确观测。

Abstract

The voltage control model and the rotor kinematic model of PMSM(permanent magnet synchronous motor)are analyzed to improve the feedback accuracy of servo control system and to solve the delay problem of feedback signal. The analyzing results are further used to analyze the work timing of control system's feedback loop and the number of hysteretic cycles is obtained. Then

a first level state observer of current and position for PMSM is proposed. The current and position values in the current control cycle are used to obtain accurate estimations of the current and position values in the next control cycle

and the observation output of the first level state observe

r is served as the input of the second level state observer so that the high frequency oscillation and the time-delay of the current and position's feedback signal can be further suppressed. Results show that the second level state observer of current and position has a significant inhibition on the high frequency noise and an accurate prediction on the feedback value. The observation error of the second level position is less than 0.005 rad

and the high frequency noise included in feedback has is eliminated. When the proposed method is applied in an AC servo control system for position control with high speed and high response

the response frequency of the system reaches 200 Hz

and acceleration arrives at 62 831 rad/s

and its positioning accuracy is 1.5

while the system's phase current is stable. It can be concluded that the proposed method realizes the accurate observation on current and position values.

关键词

Keywords

references

刘文静, 王民慧. 电流检测方法研究 [J]. 传感器世界, 2012(9): 28-31.

LIU Wenjing, WANG Minhui. The research on current detection method [J]. Sensor World, 2012(9): 28-31.

王高林, 张国强, 贵献国. 永磁同步电机无位置传感器混合控制策略 [J]. 中国电机工程学报, 2012, 32(24): 103-109.

WANG Gaolin, ZHANG Guoqiang, GUI Xianguo. Hybrid sensorless control strategy for permanent magnet synchronous motors [J]. Proceedings of the CSEE, 2012, 32(24): 103-109.

LUIGI R. Design of a high-performance optical system for angular position measurement [J]. IEEE Transactions on Instrumentation and Measurement, 2005, 54(5): 2075-2081.

黄元峰, 王海峰. 基于DSP的无刷直流电机控制器中电流检测系统 [J]. 电力电子技术, 2011, 45(5): 55-57.

HUANG Yuanfeng, WANG Haifeng. Design of current detection system of BLDCM controller based on DSP, 2011, 45(5): 55-56.

高强, 刘桂花. 一种永磁同步压缩机三相电流重构方法 [J]. 电机与控制学报, 2009, 13(2): 267-271.

GAO Qiang, LIU Guihua. Method to three-phase current reconstruction of PMSM compressor [J]. Proceedings of the CSEE, 2009, 13(2): 267-271.

郝双晖, 刘勇. 基于查表原理的单对磁极编码器研制 [J]. 中国电机工程学报, 2006, 26(19): 165-168.

HAO Shuanghui, LIU Yong. Design of single pair-pole magnetic encoder based on looking-up table [J]. Proceedings of the CSEE, 2006, 26(19): 165-168.

吴忠, 吕绪明. 基于磁编码器的伺服电机速度及位置观测器设计 [J]. 中国电机工程学报, 2011, 31(9): 82-87.

WU Zhong, LÜ Xuming. Design of angular velocity and position observer for servo motors with magnetic encoders [J]. Proceedings of the CSEE, 2011, 31(9): 82-87.

FUERTES J M. Absolute-type shaft encoding using LFSR sequences with a prescribed length [J]. IEEE Transactions on Instrumentation and Measurement, 2008, 57(5): 915-922.

马雷, 王荣本. 高速智能车辆状态观测器设计 [J]. 吉林大学学报, 2005, 33(2): 174-178.

MA Lei, WANG Rongben. State observer design on high speed intelligent vehicle [J]. Journal of Jilin University, 2005, 33(2): 174-178.

王岩青, 姜长生. 中立型线性系统时滞独立状态观测器的设计 [J]. 吉林大学学报, 2006, 44(2): 207-210.

WANG Yanqing, JIANG Changsheng. Design of delay-independent state observer for neutral linear systems [J]. Journal of Jilin University, 2006, 44(2): 207-210.

GECKELER R D, FRICKE A. Calibration of angle encoders using transfer functions [J]. Measurement Science and Technology, 2006, 17(10): 2811-2818.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

永磁同步电机新型有效磁链固定时滑模扰动辨识策略

采用d-q同步旋转坐标系的永磁同步电机无位置传感器控制

用于重型电动卡车的双电机与双行星排新驱动装置设计及动力学特性研究

面向永磁同步电机无位置传感器驱动的新型Κ∞等效滑模控制

面向永磁同步电机无传感器控制的新型已知回归项有效磁链全阶模型