双燃料发动机电控单元的设计与控制策略

杨博; 刘亦夫; 尉星; 曾科

doi:10.7652/xjtuxb201405002

您当前的位置：

首页 >

文章列表页 >

双燃料发动机电控单元的设计与控制策略

更新时间：2025-07-09

- 双燃料发动机电控单元的设计与控制策略
- The Development of a Dual Fuel Engine Electronic Control Unit and Control Strategy
- 西安交通大学学报 2014年48卷第5期页码：8-14+26
- 作者机构：
  
  西安交通大学内燃机研究所,西安,710049
- 作者简介：
- 基金信息：
  
  : 2013-10-08。作者简介: 杨博(1984—),男,博士生;刘亦夫(通信作者),男,博士后。基金项目: 国家“973计划”资助项目(2011CB707200)
- DOI：10.7652/xjtuxb201405002
  中图分类号： TK421.4
- 网络首发：2014-05-10，
  
  纸质出版：2014
- 稿件说明：
移动端阅览
杨博, 刘亦夫, 尉星, 等. 双燃料发动机电控单元的设计与控制策略[J]. 西安交通大学学报, 2014,48(5):8-14+26.

The Development of a Dual Fuel Engine Electronic Control Unit and Control Strategy[J]. 2014, 48(5): 8-14+26.
杨博, 刘亦夫, 尉星, 等. 双燃料发动机电控单元的设计与控制策略[J]. 西安交通大学学报, 2014,48(5):8-14+26. DOI： 10.7652/xjtuxb201405002.

The Development of a Dual Fuel Engine Electronic Control Unit and Control Strategy[J]. 2014, 48(5): 8-14+26. DOI： 10.7652/xjtuxb201405002.

摘要

为了改善传统的基于标定数据的柴油/天然气双燃料发动机控制系统性能

开发了天然气进气歧管顺序喷射电子控制单元(ECU)

提出了基于原柴油机喷油脉宽信号实时采集的燃料等热值替代控制策略

并在一台经过双燃料改装的高压共轨发动机上对该系统的引燃油喷射、天然气喷射、原机喷油脉宽信号实时采集等功能

以及等热值替代的控制策略进行了实验验证。结果表明:与基于标定数据的控制系统相比

所提出的控制单元及其相应控制策略可以有效改善双燃料发动机的动态控制性能; 该系统设计正确

工作稳定。在此基础上

研究了天然气喷射正时对双燃料发动机总碳氢(THC)排放的影响

实验表明:天然气喷射正时变化对双燃料发动机THC排放有显著影响

通过实时控制天然气喷射正时

可以避免过早喷入天然气

降低双燃料发动机的THC排放

特别是在中小负荷下

排放的最大降幅可达32.6%。

Abstract

A natural gas sequential injection dual fuel electronic control unit(ECU)was developed for the purpose to improve the performance of the dual fuel engine control system according to the calibration data. And a real-time diesel equivalent heating value substitution control strategy following the signal of original diesel injection pulse width was also proposed. A direct injection engine equipped with high pressure common rail system was converted into diesel/natural gas dual fuel engine and experiments were conducted to validate the functions of pilot diesel injection

natural gas injection

original diesel injection pulse width signal acquisition and the real-time equivalent heating value substitution control strategy. It indicates that the developed dual fuel ECU works stably and the dynamic performance of the dual fuel engine can be improved dramatically. The influence of natural gas injection timing on the total hydrogen carbon(THC)emissions is discussed

the significant influence on the THC emissions is found in the corresponding experiments. Adjusting natural gas injection timing in real-time facilitates avoiding early injection of natural gas

the THC can be reduced significantly. Especially

under light and medium loads

and the maximum reduction gets up to 32.6%.

关键词

Keywords

references

KORAKIANITIS T, NAMASIVAYAM A M, CROOKES R J. Natural-gas fueled spark-ignition(SI)and compression ignition(CI)engine performance and emissions[J]. Progress in Energy and Combustion Science, 2011, 37(1): 89-112.

WAGEMAKERS, A. M, LEERMAKERS C. A. J. Review on the effects of dual-fuel operation, using diesel and gaseous fuels, on emissions and performance, SAE 2012-01-0869[R]. Warrendale, PA, USA: SAE, 2012.

PAPAGIANNAKIS R G, RAKOPOULOS C D, HOUNTALAS D T, et al. Emission characteristics of high speed, dual fuel, compression ignition engine operating in a wide range of natural gas/diesel fuel proportions[J]. Fuel, 2010. 89(7): 1397-1406.

苏万华, 林志强, 汪洋, 等. 气口顺序喷射、稀燃、全电控柴油/天然气双燃料发动机的研究[J]. 内燃机学报, 2001, 19(2): 102-108.

SU Wanhua, LIN Zhiqiang, WANG Yang, et al. Development of a sequencial port injection, fully electronically controlled gas/diesel dual fuel engine[J]. Transactions of CSICE, 2001, 19(2): 102-108.

姚春德, 刘增勇, 高昌卿. 柴油引燃预混天然气准均质压燃着火过程的研究[J], 内燃机学报. 2003, 21(1): 7-12.

YAO Chunde, LIU Zengyong, GAO Changqing. Study on HCCI of premixed natural gas ignited by pilot diesel[J]. Transactions of CSICE, 2003, 21(1): 7-12.

Internet homepage westport[EB/OL].[2013-09-08]. http:∥www.westport.com/is/core-technologies/hpdi.

STMicroelectronics. SPC563Mxx 32-bit power architecture based MCU reference manual[EB/OL].[2013-09-08]. http:∥www.st.com/.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

不同喷油提前角下双燃料发动机的燃烧特性和稳定特性

天然气掺氢火花点火式发动机排放性能研究

天然气掺氢配合废气再循环发动机的性能及排放研究

缸内直喷天然气/氢气混合燃料配合废气再循环的性能与排放

排气再循环下柴油引燃天然气发动机循环变动特性研究