网络首发:2006-01-10,
纸质出版:2006
移动端阅览
魏进家1, 川口靖夫2. 零下温度时二维通道内界面活性剂减阻流动的实验研究
[J]. 西安交通大学学报, 2006,40(1):79-0084. DOI: 10.7652/xjtuxb200601019.
Experimental Study of Surfactant Drag2Reducing Flow in 2-D Channel at Sub-ero Temperature
[J]. 2006, 40(1): 79-0084. DOI: 10.7652/xjtuxb200601019.
为了进行零下温度时区域供冷系统的界面活性剂减阻设计
测量了- 5 ℃时以质量分数为<br />20 %的甘醇不冻液为溶剂的界面活性剂溶液油醇基二羟乙基甲基氯化铵在二维通道内的减阻特<br />性
同时用粒子成像测速仪对减阻流动的湍流特性进行了测量. 实验发现:质量分数为5 ×10 - 5 ~<br />5 ×10 - 4的低浓度油醇基二羟乙基甲基氯化铵界面活性剂溶液在一定的雷诺数范围内均呈现减阻<br />特性
且其减阻特性与质量分数和温度呈复杂关系
最大减阻值可高达70 %以上;在湍流液体中只<br />需加入少量该界面活性剂即可大幅度减少液体输送的动力消耗. 与单独的质量分数为20 %的甘醇<br />不冻液湍流流动相比
添加界面活性剂抑制了湍流速度脉动
使雷诺应力完全消失.<br />
To design an efficient dist rict cooling system with surfactant drag reduction at sub-ero<br />temperat ure
t he drag2reducing characteristics of Et hoquad O12/ NaSal surfactant solution were<br />measured wit h a 20 % mass2f raction ethylene glycol aqueous solution ( EG/ W) as solvent in a 2OD<br />channel at - 5 -
and the t urbulence feat ures of the surfactant drag2reducing flow were al so<br />measured via particle image velocimet ry ( PIV) technique. It is found t hat t he Et hoquad O12/<br />NaSal surfactant flowing wit h low mass f raction ranging f rom 5 -10 - 5 to 5 -10 - 4 demonst rates<br />t he maximum drag reduction above 70 %
and a complicated relationship of the drag2reducing<br />characteristics with mass f raction and temperat ure. Added only small amount of t his surfactant<br />into t he liquid t urbulent flow
t he p umping energy is reduced greatly during t he liquid t ransporta2<br />tion. Compared wit h EG/ W turbulent flow
t he added surfactant suppre
Li P W , Kawaguchi Y, Yabe A. Transitional heat
t ransfer and turbulent characteristics of drag2reducing
flow through a cont racted channel [J ] . Journal of En2
hanced Heat Transfer , 2001 , 8 (1) : 23O40.
Li P W , Kawaguchi Y, Daisaka Y, et al. Heat t rans2
fer enhancement to the drag2reducing flow of surfactant
solution in two2dimensional channel with mesh2screen
insert s at the inlet [J ] . ASME Journal of Heat Trans2
fer , 2001 , 123 (4) : 779O789.
Li F C , Wang D Z , Kawaguchi Y, et al. Simultaneous
measurement of velocity and temperature fluctuations
in thermal boundary layer in a drag2reducing surfactant
solution flow [ J ] . Experiment s in Fluids , 2004 , 36
(1) : 131O140.
Ohlendorf D , Interthal W , Hoffmann H. Surfactant
system for drag reduction : physic2chemical properties
and theological behavior [J ] . Rheologica Acta , 1986 ,
25 (5) :468O486.
Lu B. Characterization of drag2reducing surfactant sys2
tems by rheology and flow biref ringence measurement s
. Ohio : The Ohio State University , 1997.
Dean R B. Reynolds number dependence of skin f ric2
tion and other bulk flow variables in two2dimensional
rectangular duct flow [ J ] . ASME Journal of Fluids
Engineering , 1978 , 100 (2) :215O223.
Zakin J L , Myska J . New limiting drag reduction and
velocity profile asymptotes for non2polymeric additives
systems [ J ] . AIChE Journal , 1996 , 42 ( 12) : 3544O
3546.
(
0
浏览量
5
下载量
8
CSCD
关联资源
相关文章
相关作者
相关机构
京公网安备11010802024621