基于喘振频域特性的失稳预警技术研究

孙涛 1; 徐光华 1; 2; 张春梅 3

您当前的位置：

首页 >

文章列表页 >

基于喘振频域特性的失稳预警技术研究

专题研究 | 更新时间：2025-12-08

- 基于喘振频域特性的失稳预警技术研究
- Instability Early Warning Based on Frequency-Domain Characteristic of Surge
- 西安交通大学学报 2007年41卷第11期页码：1321-1325
- 作者机构：
  
  1. 西安交通大学机械工程学院,西安,710049
  2. 西安交通大学机械制造系统工程国家重点实验室,西安,710049
- 作者简介：
- 基金信息：
  
  : 2007-03-16. 作者简介: 孙涛(1977～),男,博士生;徐光华(联系人),男,教授,博士生导师. 基金项目: 国家发改委工业自动化高技术产业化专项资助项目(2004-2080-20)
- DOI：
  中图分类号： TP206.3
- 网络首发：2007-11-10，
  
  纸质出版：2007
- 稿件说明：
移动端阅览
孙涛 1, 徐光华 1, 2, 等. 基于喘振频域特性的失稳预警技术研究[J]. 西安交通大学学报, 2007,41(11):1321-1325.

孙涛 1, 徐光华 1, 2, et al. Instability Early Warning Based on Frequency-Domain Characteristic of Surge[J]. 2007, 41(11): 1321-1325.
孙涛 1, 徐光华 1, 2, 等. 基于喘振频域特性的失稳预警技术研究[J]. 西安交通大学学报, 2007,41(11):1321-1325. DOI：

孙涛 1, 徐光华 1, 2, et al. Instability Early Warning Based on Frequency-Domain Characteristic of Surge[J]. 2007, 41(11): 1321-1325. DOI：

摘要

为了寻求离心压缩机喘振发作的早期征兆

利用相关积分法结合细化快速傅里叶变换

研究了完整记录喘振发展变化的压力信号的频域特性

并根据喘振产生的物理机制提出了一种新的喘振预警方法.该方法采用与监测频带能量相对应的参数

来度量喘振过程中离心压缩机内部流动特性的变化.分析结果表明

在离心压缩机完全进入喘振前

喘振频带能量有明显的增长过程

增长时刻距喘振完全发作有1～2 s的时间间隔

这对实现离心压缩机安全高效运行具有十分重要的意义.

Abstract

To seek the incipient symptom of surge in the centrifugal compressor

the frequency-domain characteristics of the pressure signal from the state far from surge to the state of full developed surge are analyzed by correlation integral method combining with zoom fast Fourier transform

and a new surge early warning method defining a parameter related with the frequency band energy as the measure is proposed according to the fact that the perturbed energy increases nonlinearly during the surge process. It is illustrated that the frequency band energy of surge is endowed with a visible increase process

and the time delay of 1 - 2 s between the initial rise and the full onset of surge is long enough to allow the effective response of the controller. The investigation offers a powerful support for the compressor to operate under safe and high-efficient condition.

关键词

Keywords

references

宋智民.离心压缩机喘振预测和控制研究[D].大庆:大庆石油学院,2006.

聂超群,戴冀,廖生芳.离心压缩系统喘振先兆的实验研究[J].工程热物理学报,1997,18(3):306-310.

Nie Chaoqun, Dai Ji, Liao Shengfang. Experiment investigation into surge inception in centrifugal compression system [J]. Journal of Engineering Thermophysics, 1997,18(3):306-310.

聂超群,陈静宜,乔晓辉.压缩系统喘振现象主动控制的实验研究[J].工程热物理学报,1995,16(2):166-171.

Nie Chaoqun, Chen Jingyi, Qiao Xiaohui, et al. Experiment study on active control of surge in centrifugal compression system [J]. Journal of Engineering Thermophysics,1995,16(2):166-171.

李美林,张春梅,王尚锦,等.用小波和分维数方法处理喘振实验数据[J].工程热物理学报,2002,23(2):175-178.

Li Meilin, Zhang Chunmei, Wang Shangjin, et al. Surge data processing based on wavelet analysis and fractal methods[J]. Journal of Engineering Thermophysics,2002,23(2):175-178.

蒋峻.离心风机喘振在线预报和自适应调节的实验研究[D].北京:中科院工程热物理所,2001.

Bright M M,Qammar H K,Weig H J,et al.Stall precursor identification in high-speed compressor stages using chaotic time series analysis methods [J]. ASME Journal of Turbomachinery, 1997,119(3):491-499.

Bright M M,Helen K Q,Wang Leizhen.Investigation of pre-stall mode and pip inception in high speed compression through the use of correlation integral [J]. AEME Journal of Turbomachinary,1999, 121(4):743-750.

吴云,李应红,张朴.某涡喷发动机压气机气动失稳过程的非线性分析[J].航空动力学报,2005,20(5):890-894.

Wu Yun, Li Yinghong, Zhang Pu. Nonlinear analysis of the process of loosing compressor aerodynamic stability in a turbojet engine[J].Journal of Aerospace Power, 2005,20(5):890-894.

孙涛,徐光华,张春梅. 基于相关积分法的离心压气机喘振过程的非线性监测[J].航空动力学报, 2006,21(6):1092-1097.

Sun Tao, Xu Guanghua, Zhang Chunmei. Nonlinear monitoring of the process of surge in centrifugal compressors based on correlation integral method [J].Journal of Aerospace Power, 2006,21(6):1092-1097.

Sun Tao, Xu Guanghua, Zhang Chunmei, et al.Investigation of fast algorithm for correlation integral method[C]∥Proceeding of the Sixth International Conference on Intelligent Systems Design and Applications.Piscataway, USA: IEEE, 2006:755-760.

丁康,陈健林,苏向荣.平稳和非平稳振动信号的若干处理方法及发展[J].振动工程学报,2003,16(1):1-10.

Ding Kang, Chen Jianlin, Su Xiangrong. Development in vabration signal analysis and processing methodss[J]. Journal of Vabration Engineering, 2003,16(1):1-10.

刘进明,应怀樵.FFT谱连续细化分析的傅立叶变换法[J].振动工程学报,1995,5(2):162-166.

Liu Jinming, Ying Huaiqiao. Zoom FFT spectrum by Fourier transform [J]. Journal of Vibration Engineering, 1995,5(2):162-166.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

采用关联模型的离心压缩机喘振工况数值研究

离心压缩机性能预测中雷诺平均湍流模型的不确定度量化与分析

R1234ze（E）替代R134a对二级压缩循环离心压缩机及制冷性能的影响

离心压缩机级间加气的出口流场特性

离心压缩机叶轮叶片疲劳断裂故障的数值分析