蚕丝蛋白/明胶多孔肝组织支架的制备及性能研究

郝星 1; 贺健康 1; 高琨 2; 李涤尘 1; 刘亚雄 1

您当前的位置：

首页 >

文章列表页 >

蚕丝蛋白/明胶多孔肝组织支架的制备及性能研究

更新时间：2025-07-09

- 蚕丝蛋白/明胶多孔肝组织支架的制备及性能研究
- Preparation and Properties of Silk Fibroin/Gelatin Porous Scaffolds for Liver Tissue Engineering
- 西安交通大学学报 2011年45卷第11期页码：121-126
- 作者机构：
  
  西安交通大学机械制造系统工程国家重点实验室,西安,710049
- 作者简介：
- 基金信息：
  
  : 2011-06-15. 作者简介: 郝星(1986-),女,硕士生;刘亚雄(联系人),男,副教授. 基金项目: 国家高技术研究发展计划资助项目(2009AA043801)
- DOI：
  中图分类号： Q813;R318.08
- 网络首发：2011-11-10，
  
  纸质出版：2011
- 稿件说明：
移动端阅览
郝星 1, 贺健康 1, 高琨 2, 等. 蚕丝蛋白/明胶多孔肝组织支架的制备及性能研究[J]. 西安交通大学学报, 2011,45(11):121-126.

Preparation and Properties of Silk Fibroin/Gelatin Porous Scaffolds for Liver Tissue Engineering[J]. 2011, 45(11): 121-126.
郝星 1, 贺健康 1, 高琨 2, 等. 蚕丝蛋白/明胶多孔肝组织支架的制备及性能研究[J]. 西安交通大学学报, 2011,45(11):121-126. DOI：

Preparation and Properties of Silk Fibroin/Gelatin Porous Scaffolds for Liver Tissue Engineering[J]. 2011, 45(11): 121-126. DOI：

摘要

采用冷冻干燥法制备了蚕丝蛋白/明胶多孔支架

并分别在-20 ℃和-70 ℃预冻

以观察支架的微孔结构

测量支架的孔隙率、溶胀吸水性及力学性能

研究HepG2细胞在支架中的生长增殖情况.结果表明:随预冻温度降低

支架的孔径减小且微孔分布更加均匀

孔隙率及力学性能均得到提高.细胞培养结果显示:随预冻温度降低

支架的细胞贴壁率减小

-20 ℃预冻支架中的细胞数量稳步增加

而-70 ℃预冻支架中的细胞在培养前期生长良好

在培养后期增殖受到限制.此项研究证明

采用冷冻干燥法可以成功制备蚕丝蛋白/明胶多孔支架

通过改变预冻温度可以控制支架的孔隙结构及性能.

Abstract

The silk fibroin/gelatin porous scaffold was prepared by the freeze-drying method. The temperature was set as -20 ℃ and -70 ℃

respectively. The micro-porous morphology was observed by SEM and the porosities were measured. The swelling performance and mechanical property were also investigated. HepG2 cells were cultured in the two kinds of scaffolds to evaluate their biocompatibility. The results show that with decrease of the freezing temperature

the pore size becomes smaller and the porous morphology gets more homogeneous. Reducing freezing temperature results in higher porosity and much stronger mechanical performance. The cell culture results demonstrate that with the decrease of freezing temperature

fewer cells adhere to the scaffold. Cells in scaffolds with higher freezing temperature proliferate gradually. Cells in scaffolds at lower freezing temperature proliferate very well at first

while the proliferation is limited later. It is concluded that the silk fibroin/gelatin porous scaffold can be successfully prepared by the freeze-drying method

and the porous structure and properties of the scaffold can be controlled by adjusting the freezing temperature.

关键词

Keywords

references

ZAVAN B, BRUN P, VINDIGNI V, et al. Extracellular matrix-enriched polymeric scaffolds as a substrate for hepatocyte cultures: in vitro and in vivo studies [J]. Biomaterials, 2005, 26(34): 7038-7045.

YOHKO G, SHINGO N, TAKAO H, et al. Preparation of lactose-silk fibroin conjugates and their application as a scaffold for hepatocyte attachment [J]. Biomaterials, 2004, 25(6): 1131-1140.

LI Keguo, QU Xinjian, WANG Yun, et al. Improved performance of primary rat hepatocytes on blended natural polymers [J]. Journal of Biomedical Materials Research: Part A, 2005, 75A(2): 268-274.

VASSILIS K, LORENZ M, SANDRA H, et al. Bone morphogenetic protein-2 decorated silk fibroin films induce osteogenic differentiation of human bone marrow stromal cells [J]. Journal of Biomedical Materials Research: Part A, 2004, 71A(3): 528-537.

LAWRENCE B D, MARCHANT J K, PINDRUS M A, et al. Silk film biomaterials for cornea tissue engineering [J]. Biomaterials, 2009, 30(7): 1299-1308.

YAMAMOTO K, TOMITA N, FUKUDA Y, et al. Time-dependent changes in adhesive force between chondrocytes and silk fibroin substrate [J]. Biomaterials, 2007, 28(10): 1838-1846.

LIU Haifeng, FAN Hongbin, WANG Yue, et al. The interaction between a combined knitted silk scaffold and microporous silk sponge with human mesenchymal stem cells for ligament tissue engineering [J]. Biomaterials, 2008, 29(6): 662-674.

LU Qiang, ZHANG Xiaohui, HU Xiao, et al. Green process to prepare silk fibroin/gelatin biomaterial scaffolds [J]. Macromolecular Bioscience, 2010, 10(3): 289-298.

TIYABOONCHAI W, CHOMCHALAO P, PONGCHAROEN S, et al. Preparation and characterization of blended Bombyx mori silk fibroin scaffolds [J]. Fibers and Polymers, 2011, 12(3): 324-333.

NAZAROV R, JIN H J, KAPLAN D L. Porous 3-D saffolds from regenerated silk fibroin [J]. Biomacromolecules, 2004, 5(3): 718-726.

MANDAL B B, KUNDU S C. Non-bioengineered silk fibroin protein 3D scaffolds for potential biotechnological and tissue engineering applications [J]. Macromolecules Bioscience, 2008, 8(9): 807-818.

REN Lei, TSURU K, HAYAKAWA S, et al. Novel approach to fabricate porous gelatin-siloxane hybrids for bone tissue engineering [J]. Biomaterials, 2002, 23(24): 4765-4773.

FUKASAWA T, DENG Z Y, ANDO M, et al. Pore structure of porous ceramics synthesized from water-based slurry by freeze-dry process [J]. Journal of Materials Science, 2001, 36(10): 2523-2527.

DEVILLE S, SAIZ E, NALLA R K, et al. Freezing as a path to build complex composites [J]. Science, 2006, 311(5760): 515-518.

DEVILLE S, SAIZ E, TOMSIA A P. Freeze casting of hydroxyapatite scaffolds for bone tissue engineering [J]. Biomaterials, 2006, 27(32): 5480-5489.

ZHANG H, COOPER A I. Aligned porous structures by directional freezing [J]. Advanced Materials, 2007, 19(11): 1529-1533.

MUKAI S R, NISHIHARA H, TAMON H. Morphology maps of ice-templated silica gels derived from silica hydrogels and hydrosols [J]. Microporous Mesoporous Materials, 2008, 116(1/2/3):166-170.

YUNOKI S, IKOMA T, MONKAWA A, et al. Control of pore structure and mechanical property in hydroxyapatite/collagen composite using unidirectional ice growth [J]. Materials Letters, 2006, 60(8): 999-1002.

张洁,徐烈.冻干支架孔隙形态的影响因素[J]. 低温工程, 2002(2): 38-43.

ZHANG Jie, XV Lie. Analysis of the influence factors on the scaffold porous configuration based on freeze drying method [J]. Cryogenic Engineering, 2002(2): 38-43.

MANDAL B B, KUNDU S C. Cell proliferation and migration in silk fibroin 3D scaffolds [J]. Biomaterials, 2009, 30(15): 2956-2965.

RANUCCI C, KUMAR A, BATRA S, et al. Control of hepatocyte function on collagen foams: sizing matrix pores toward selective induction of 2-D and 3-D cellular morphogenesis [J]. Biomaterials, 2000, 21(8): 783-793.

RANUCCI C, MOGHE P. Polymer substrate topography actively regulates the multicellular organization and liver-specific functions of cultured hepatocytes [J]. Tissue Engineering, 1999, 5(5): 407-419.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

肝组织工程支架的仿生设计与有限元分析

多工况下离心压气机叶轮-机匣一体联合设计优化

隧道内燃料电池汽车氢气泄漏扩散特性及影响因素

采用试验设计方法的第三代CO2气体箔轴承箔片几何参数敏感性分析

张角凹坑气膜孔对双层壁气膜冷却特性的影响