间冷式冰箱冷藏室内流场的粒子图像速度场实验研究

孟祥兆; 俞炳丰

您当前的位置：

首页 >

文章列表页 >

间冷式冰箱冷藏室内流场的粒子图像速度场实验研究

专题研究 | 更新时间：2025-12-08

- 间冷式冰箱冷藏室内流场的粒子图像速度场实验研究
- Digital Particle Image Velocimetry Measurement of Inner Flow Field in Cooling Chamber of Frost-Free Refrigerator
- 西安交通大学学报 2007年41卷第9期页码：1075-1079
- 作者机构：
  
  西安交通大学能源与动力工程学院,西安,710049
- 作者简介：
- 基金信息：
- DOI：
  中图分类号： TB657
- 网络首发：2007-09-10，
  
  纸质出版：2007
- 稿件说明：
移动端阅览
孟祥兆, 俞炳丰. 间冷式冰箱冷藏室内流场的粒子图像速度场实验研究[J]. 西安交通大学学报, 2007,41(9):1075-1079.

孟祥兆, 俞炳丰. Digital Particle Image Velocimetry Measurement of Inner Flow Field in Cooling Chamber of Frost-Free Refrigerator[J]. 2007, 41(9): 1075-1079.
孟祥兆, 俞炳丰. 间冷式冰箱冷藏室内流场的粒子图像速度场实验研究[J]. 西安交通大学学报, 2007,41(9):1075-1079. DOI：

孟祥兆, 俞炳丰. Digital Particle Image Velocimetry Measurement of Inner Flow Field in Cooling Chamber of Frost-Free Refrigerator[J]. 2007, 41(9): 1075-1079. DOI：

摘要

以一台BCD-190W间冷式冰箱为研究对象

制作了间冷式冰箱透明模型

搭建了冰箱模型中空气流场测量的实验系统.采用数字化粒子图像速度场(DPIV)技术测量了间冷式冰箱模型冷藏室内特征平面区域内的平均速度分布.实验测量结果表明:冷藏室顶层间室内送风口流速最大

底层间室送风口流速略小

而中间两层间室送风口流速低于0.1 m/s

不能满足设计功能要求; 各间室内对称的2个送风口流速差别明显

必将导致冰箱间室内温度分布不均匀.实验结果验证了DPIV技术用于测量间冷式冰箱内流场的可行性

揭示了冰箱送风口流速和流量设计中存在的不足

并进一步指明了各间室流量分配的关键在于风道的阻力和流量设计

可为改进冰箱结构和性能提供参考.

Abstract

A transparent model based on a BCD-190W type frost-free refrigerator was constructed with organic glass

and the experiment system for measuring the air flow characters in the cooling chamber of the model was built. Using digital particle image velocimetry(DPIV)technology

the mean velocities distributions on the typical 2-D zones in the cooling chamber of the model were measured. The experiment results show that the air flow velocities and air flow rates at the supply-air openings were non-uniform. The air flow velocities at the openings in the top chest were the largest in the four chests

and those in the fourth chest were somewhat lower. Moreover

the air velocities at the openings in the second and third chests were less than 0.1 m/s

and thus the flow rates could not meet the function requirement of the chests. Through the analysis of the velocities distributions

the practicability of using DPIV system to measure the flow characters in the chests of the model were verified

and the shortages of the air velocities and flow rates design were discovered. The measurement results also indicate that the resistance and flow rates design for the air flow ducts are the key factors for the refrigerator design.

关键词

Keywords

references

Radermacher R, Kin K. Domestic refrigerators: recent developments [J]. International Journal of Refrigeration, 1996, 19(1):61-69.

Zhou Qin, Pannock J, Raderamcher R. Development and testing of a high efficiency refrigerator [J]. ASHRAE Trans, 1994, 100:1351-1358.

Asano A, Takenaka N, Fujii T, et al. Application of neutron radiography to a diagnosis of refrigerator [J]. Nuclear Instruments and Methods in Physics Research: Section A, 1996, 377:170-173.

阙雄才,于兵,陈芝久,等. 间冷式冰箱风道阻力与流量分配特性的探讨[J]. 上海交通大学学报. 1997,31(3):13-16.

Que Xiongcai, Yu Bing, Cheng Zhijiu. Study on characteristics of air tunnel resistance vs flow rate distribution in indirect-cool refrigerator [J]. Journal of Shanghai Jiaotong University,1997, 31(3):13-16.

丁国良, Oellrich L R. 冰箱中空气流场和温度场的有限元模拟[J]. 上海交通大学学报, 1998,32(7):18-22.

Ding Guoliang, Oellrich L R. Simulation of air flow and temperature field inside a refrigerated chamber with finite element method [J]. Journal of Shanghai Jiaotong University,1998, 32(7):18-22.

俞炳丰,费继友,孟祥兆,等. 间冷式冰箱冷冻室内流场的DPIV测量和计算模拟[J]. 制冷学报, 2003, 24(2):32-36.

Yu Bingfeng, Fei Jiyou, Meng Xiangzhao, et al. DPIV measurement and numerical simulation of the inner flow field of freezer chest of frost-free refrigerator [J]. Journal of Refrigeration, 2003, 24(2):32-36.

俞炳丰. 制冷与空调应用新技术[M]. 北京:化学工业出版社,2002.

康琦,申功炘. 全场测速技术进展[J]. 力学进展, 1997, 27(1):106-120.

Kang Qi, Shen Gongxin. Development of the full flow field measurement [J]. Advances in Mechanics, 1997, 27(1):106-120.

盛森之,沈熊,舒玮. 流速测量技术[M]. 北京:北京大学出版社,1987.

徐挺. 相似方法及其应用[M]. 北京:机械工业出版社,1995.

张玮,王元,徐忠,等. 应用粒子图像速度场仪对泊肃叶流动及圆柱绕流的测量 [J]. 西安交通大学学报,2002,36(3):246-251.

Zhang Wei, Wang Yuan, Xu Zhong, et al. Application of particle image velocimetry to measurement of Poisoeullie flow and flow around a circular cylinder [J]. Journal of Xi'an Jiaotong University, 2002, 36(3):246-251.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

间冷式冰箱冷冻室粒子图像速度场测量和数值模拟

Bingham型黏性泥石流流体的三维数值模拟

新型直旋混合射流破岩特性及机理分析

地面热力学排气系统实验研究

一种新型热压缩机运行特性实验研究