轴流风机静止部件的流动和损失对比

梁亚勋; 李景银; 田华

您当前的位置：

首页 >

文章列表页 >

轴流风机静止部件的流动和损失对比

专题研究 | 更新时间：2025-12-08

- 轴流风机静止部件的流动和损失对比
- Study on Flow Fields and Losses of the Stationary Components in an Axial Flow Fan
- 西安交通大学学报 2008年42卷第3期页码：269-272
- 作者机构：
  
  西安交通大学能源与动力工程学院,西安,710049
- 作者简介：
- 基金信息：
  
  : 2007-06-28. 作者简介: 梁亚勋(1983-),男,硕士生;李景银(联系人),男,副教授. 基金项目: 国家自然科学基金资助项目(50776066)
- DOI：
  中图分类号： TK432
- 网络首发：2008-03-10，
  
  纸质出版：2008
- 稿件说明：
移动端阅览
梁亚勋, 李景银, 田华. 轴流风机静止部件的流动和损失对比[J]. 西安交通大学学报, 2008,42(3):269-272.

梁亚勋, 李景银, 田华. Study on Flow Fields and Losses of the Stationary Components in an Axial Flow Fan[J]. 2008, 42(3): 269-272.
梁亚勋, 李景银, 田华. 轴流风机静止部件的流动和损失对比[J]. 西安交通大学学报, 2008,42(3):269-272. DOI：

梁亚勋, 李景银, 田华. Study on Flow Fields and Losses of the Stationary Components in an Axial Flow Fan[J]. 2008, 42(3): 269-272. DOI：

摘要

采用三维黏性流场数值分析方法

对轴流风机的静止部件分别进行了单独和整机条件下的数值计算.对2种情况下各静止部件流场和损失的变化进行了分析.结果发现:集流器的损失较大

其效率与扩散筒的效率相当

设计中必须加以考虑; 与各个静止部件单独计算时相比较

在整机计算条件下风机的扩散筒和扩散塔的流场相互干涉比较严重

导致内部流场状况较差

流动损失增大; 该扩散塔的出口速度分布非常不均匀

低速区面积太大

值得改进.

Abstract

By using 3-D viscous flow solvers

the numerical simulation was carried out to investigate the flow fields and losses in stationary part of an axial flow fan. By studying the variations of the flow fields and losses of the stationary components at isolated conditions and in the fan's assembly

it is found that the losses in the collector is large

and its efficiency is almost the same as the diffuser's

therefore its losses should be taken into account in the design. Secondly

the losses of the diffuser and diffusing tower increase in the fan's assembly compared with those at isolated condition

which means that the interference between them is strong and leads to worse flow fields. Finally

the flow fields at the exit of the diffusing tower are very uneven

and there exists a large area of low velocity

leading to a decrease of the static efficiency of the fan. An improvement should be made.

关键词

Keywords

references

李景银,郭琦.轴流通风机扩散筒效率的测量和综述[J].风机技术,2007,(2):5-10.

LI Jingyin,GUO Qi. Measurement and summarize of efficiency of diffuser tube for axial flow fan [J]. Compressor,Blower & Fan Technology,2007(2):5-10.

李庆宜.通风机 [M]. 北京:机械工业出版社,1981:172-173.

SHARMA P B, JAIN Y P, PUNDHIR D S. Study of some factors affecting the performance of a contra-rotating axial compressor state [J]. Power and Process Engineering: Part A,1988(2):15-21.

张夏,楚武利,邓文剑,等. 轴流风机中支板通道的流动分析及改进 [J]. 航空动力学报, 2006,21(6): 1048-1052.

ZHANG Xia,CHU Wuli,DENG Wenjian, et al. Flow analysis and the improvement of axial fan support strut[J].Journal of Aerospace Power,2006,21(6): 1048-1052.

王海桥,李威松. 矿井主扇扩散器通风流场数值模拟研究及其应用 [J]. 湘潭矿业学院学报,2002,17(4):9-11.

WANG Haiqiao,LI Weisong. Numerical simulation study and application on diffuser ventilation flow field of mine main fan [J]. Journal of Xiangtan Mining Institute, 2002,17(4):9-11.

潘地林,程小东,郑昌球. 矿井主要通风机扩散弯道合理流型的研究 [J]. 煤矿安全,2005,36(11):1-4.

PAN Dilin,CHENG Xiaodong,ZHENG Changqiu. Study of fitness flow pattern design for curved diffuser of mine main fan [J]. Safety In Coal Mines, 2005,36(11):1-4.

王军,肖朋. 变工况下对旋风机的数值模拟实验 [J]. 华中科技大学学报(自然科学版),2006,34(9):81-84.

WANG Jun,XIAO Peng. Numerical simulation of a counter-rotating axial flow fan in design or off-design conditions [J].Journal of Huazhong University of Science and Technology(Nature Science Edition), 2006,34(9):81-84.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

整机环境下离心压气机叶轮流固耦合不确定性量化分析

过冷度对喷嘴效率影响的测试研究

轴流风机仿生耦合叶片降噪机理研究

工质对的过量焓对吸收式制冷系数的影响

张角凹坑气膜孔对双层壁气膜冷却特性的影响