正方形小通道内不同性质溶液-氮气两相流型

杨竹强; 毕勤成

您当前的位置：

首页 >

文章列表页 >

正方形小通道内不同性质溶液-氮气两相流型

更新时间：2025-07-09

- 正方形小通道内不同性质溶液-氮气两相流型
- Experimental Investigation on Flow Pattern of Different Fluid-Nitrogen in Square Channels
- 西安交通大学学报 2011年45卷第1期页码：26-30
- 作者机构：
  
  西安交通大学动力工程多相流国家重点实验室,西安,710049
- 作者简介：
- 基金信息：
  
  : 2010-06-05. 作者简介: 杨竹强(1986-),男,硕士生;毕勤成(联系人),男,教授,博士生导师. 基金项目: 国家自然科学基金资助项目(50576076)
- DOI：
  中图分类号： TK124
- 网络首发：2011-01-10，
  
  纸质出版：2011
- 稿件说明：
移动端阅览
杨竹强, 毕勤成. 正方形小通道内不同性质溶液-氮气两相流型[J]. 西安交通大学学报, 2011,45(1):26-30.

Experimental Investigation on Flow Pattern of Different Fluid-Nitrogen in Square Channels[J]. 2011, 45(1): 26-30.
杨竹强, 毕勤成. 正方形小通道内不同性质溶液-氮气两相流型[J]. 西安交通大学学报, 2011,45(1):26-30. DOI：

Experimental Investigation on Flow Pattern of Different Fluid-Nitrogen in Square Channels[J]. 2011, 45(1): 26-30. DOI：

摘要

采用可视化手段研究了水力直径为2.5 mm的正方形小通道内蔗糖-氮气、羧甲基纤维素钠(CMC)-氮气、水-氮气和水力直径为1.0 mm的正方形小通道内蔗糖-氮气的垂直绝热上升流动

对其流型、压降进行了实验采集.实验中的典型流型有:弹状流、搅拌流和环状流.通过大量的数据得到了各个溶质的流型转变图和压降曲线

对各种流型的流动机理进行了分析

着重对黏弹性对于流动的影响进行了研究.通过水力直径为2.5 mm的小通道内蔗糖-氮气、CMC-氮气和水-氮气流型的对比

总结了流体的黏弹性、流量对于流型转变的影响.对不同水力直径时的蔗糖-氮气流型进行对比研究

总结了流体水力直径、表面张力等因素对于流型转变的影响

同时在水力直径为1.0 mm的小通道内发现了明显的二次流动现象.实验证实Chisholm方法对于非牛顿流体的压降处理已不再适用.

Abstract

Flow visualization experiments of different fluid-nitrogen co-current upward flow were conducted in a square channel with a hydraulic diameter of 2.5 mm. Three kinds of fluids were studied

i.e.

water

saccharose

and sodium carboxymethyl cellulose(CMC). The typical flow patterns of different gases at liquid superficial velocities were recognized

including slug flow

churn flow

and annular flow. Flow visualization experiments on saccharose-nitrogen co-current upward flow were also carried out in a square channel with a hydraulic diameter of 1.0 mm. The flow regime maps and the pressure drop of the working fluids were obtained according to the plentiful experimental data. Flow mechanism in each flow pattern was discussed and the main factors affecting flow pattern were explored

in particular

the influence of the viscosity and the fluid flux. The results show that the surface tension

secondary flow

and hydraulic diameter have significant effect on the flow pattern transition. The experiment with the hydraulic diameter of 2.5 mm indicates that the Chisholm method may not suit the non-Newtonian fluid.

关键词

Keywords

references

WILLIMARTH T,ISII M.Two-phase flow regime in narrow rectangular vertical and horizontal Channels[J].International Journal of Heat and Mass Transfer,1994,37(12):1749-1758.

WILLIMARTH T,ISII M. Interfacial area concentration and void fraction of two-phase flow in narrow rectangular vertical channels[J].Journal of Fluid Engineering,1997,119(4):916-922.

TRIPLETT K A, GHIAASIAAN S M. Gas-liquid two-phase flow in microchannels: partⅡ void fraction and pressure drop[J]. International Journal of Multiphase Flow, 1999, 25(11):395-401.

WOLK G, DREVER M, RATH H J. Flow patterns in small diameter vertical non-circular channels[J]. International Journal of Multiphase Flow, 2000, 26(6):1037-1061.

ZHAO T S, BI Q C. Co-current air-water two-phase pattern in vertical triangular microchannels[J]. International Journal of Multiphase Flow, 2001, 27(5):765-782.

SATITCHAICHAROEN P, WONGWISES S. Two-phase flow pattern maps for vertical upward gas-liquid flow in mini-gap channels[J].International Journal of Multiphase Flow,2004,30(2):225-236.

HIBIKI T, TAKAMASA T, ISHII M. Some characteristics of developing bubbly flow in a vertical mini pipe[J]. International Journal of Heat and Fluid Flow, 2007, 28(5):1034-1048.

KAWAHARA A, SADATOMI M, NEI K, et al. Experimental study on bubble velocity, void fraction and pressure drop for gas-liquid two-phase flow in a circular microchannel[J]. International Journal of Heat and Fluid Flow, 2009,30(5):831-841.

李静.羧甲基纤维素钠溶液的流变性质及其对酸性乳体系的稳定作用[D].上海:上海交通大学化学化工学院,2007:16-23.

WEAST R C, ASTLE M J, BEYER W H. Handbook of chemistry and physics[M]. 67th ed. Boca Raton,Florida,America:CRC Press, 1986.

郭亚军,毕勤成,何永清.正方形截面直通道内二次流现象的实验研究[J].西安交通大学学报,2009,43(7):83-87.

GUO Yajun, BI Qincheng, HE Yongqing. Experimental investigation on secondary flow of air-water two-phase flow in straight channel with square cross-section[J]. Journal of Xi'an Jiaotong University,2009,43(7):83-87.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

S型柔性立管内空气水两相流流型特征的实验研究

矩形通道内高速蒸汽与过冷水直接接触凝结换热流型的实验研究

调节阀内流型分布及利用声音突变判别流型转变的方法

离子液体改性燃料的电流体动力学效应研究

扇贝仿生密封腔室内超临界二氧化碳泄漏流湍动能耗散机理研究