表面活性剂对中尺度气泡形状及速度的调控研究

刘艳艳; 李彦鹏; 朱婷婷

您当前的位置：

首页 >

文章列表页 >

表面活性剂对中尺度气泡形状及速度的调控研究

更新时间：2025-07-09

- 表面活性剂对中尺度气泡形状及速度的调控研究
- Study on Modulating Shape and Velocity of Meso-Scale Bubble Using Surfactants
- 西安交通大学学报 2011年45卷第10期页码：93-97
- 作者机构：
  
  长安大学环境科学与工程学院,西安,710064
- 作者简介：
- 基金信息：
  
  : 2011-01-02. 作者简介: 刘艳艳(1984-),女,硕士生;李彦鹏(联系人),男,教授. 基金项目: 国家自然科学基金资助项目(20706007);中央高校基本科研业务专项基金资助项目(CHD2009JC011);流体动力与机电系统国家重点实验室开放基金资助项目(GZKF-201026)
- DOI：
  中图分类号： O363;TK124
- 网络首发：2011-10-10，
  
  纸质出版：2011
- 稿件说明：
移动端阅览
刘艳艳, 李彦鹏, 朱婷婷. 表面活性剂对中尺度气泡形状及速度的调控研究[J]. 西安交通大学学报, 2011,45(10):93-97.

Study on Modulating Shape and Velocity of Meso-Scale Bubble Using Surfactants[J]. 2011, 45(10): 93-97.
刘艳艳, 李彦鹏, 朱婷婷. 表面活性剂对中尺度气泡形状及速度的调控研究[J]. 西安交通大学学报, 2011,45(10):93-97. DOI：

Study on Modulating Shape and Velocity of Meso-Scale Bubble Using Surfactants[J]. 2011, 45(10): 93-97. DOI：

摘要

为了有效调控中尺度气泡的行为

在纯水中通过添加不同浓度的3种表面活性剂实验研究了气泡上升过程中的形状与速度的变化.在一个方截面柱形容器内生成了4种中尺度气泡

再利用高速摄影仪记录了气泡的瞬时运动过程

通过图像处理软件分析了气泡的形状和速度.结果表明

由于Marangoni效应

适量的表面活性剂可以有效抑制中尺度气泡的变形

减小气泡的形状变化幅度

降低气泡的上升速度.相比于纯水

当曲拉通的浓度为0.15 mmol/L时

气泡高宽比的变化幅度缩减了57%; 当曲拉通的浓度为0.05 mmol/L时

气泡终端上升速度降低了35%.实验中还发现

气泡的形状变化影响着气泡的瞬时速度

气泡高度比越小

上升得越快.在实验条件范围内

不同表面活性剂对气泡的调控效果有所不同

曲拉通的调控效果优于聚乙二醇和正戊醇.

Abstract

Experiments were conducted on the variations of shape and velocity of single bubbles during rising in three types of surfactant solutions with different concentration in order to effectively modulate the behavior of meso-scale bubbles in bubbly flow. Single bubbles with the size of 1.3-6 mm were generated in a square glass column

and the instantaneous motion of single bubbles was recorded using a high-speed camera. Then bubble shape and velocity were determined from the recorded frames using the image analysis software. The results show that the right concentration of surfactants used here would dampen bubble deformation

reduce shape oscillation amplitude and slow down the bubble rise velocity significantly due to the Marangoni effect. The addition of 0.15 mmol/L Triton X-100 would reduce the oscillation amplitude of the bubble aspect ratio by 57% while the addition of 0.05 mmol/L Triton X-100 would lower the terminal velocity of bubbles by 35% compared with those in pure water. Moreover

The bubble shape oscillation would influence the bubble transient velocity. It seems that under the present experimental conditions

the modulation effect of the addition of different types of surfactants on meso-scale bubble behavior is quite different. The addition of Triton X-100 has stronger effect on the modulation than the addition of Polyethylene glycol or n-Pentanol.

关键词

Keywords

references

KULKARNI A A, JOSHI J B. Bubble formation and bubble rise velocity in gas-liquid systems: a review [J]. Industrial and Engineering Chemistry Research, 2005, 44(16): 5873-5931.

CLIFT R, GRACE J R, WEBER M E. Bubbles, drops, and particles [M]. 2nd ed. New York, USA: Academic Press, 2005.

TSUKADA T. The effect of EHD convection on motion of a bubble under microgravity [J]. Journal of Chemical Engineering, 1995, 28(6): 810-815.

ELLENBERGER J, KRISHNA R. Levitation of air bubbles in liquid under low frequency vibration excitement[J].Chemical Engineering Science, 2007, 62(18): 5669-5673.

CUI Zhe, LI Yanpeng, GE Yang, et al. Bubble modulation using acoustic standing waves in a bubbling system [J]. Chemical Engineering Science, 2005, 60(22): 5971-5981.

李彦鹏,FAN L S.鼓泡塔中驻波声场调制大气泡的直接模拟 [J].应用基础与工程科学学报, 2007, 15(2): 217-225.

LI Yanpeng, FAN L S. Direct simulation of a large bubble modulation with an acoustic standing wave in a bubble column [J]. Journal of Basic Science and Engineering, 2007, 15(2): 217-225.

FINCH J A, NESSET J E, ACUNA C. Role of frother on bubble production and behavior in flotation [J]. Minerals Engineering, 2008, 21(12/13/14):949-957.

KRACHT W, FINCH J A. Effect of frother on initial bubble shape and velocity [J]. International Journal of Mineral Processing, 2010, 94(3/4):115-120.

KRZAN M, ZAWALA J, MALYSA K. Development of steady state adsorption distribution over interface of a bubble rising in solutions of n-alkanols and n-alkyltrimethylammonium bromides[J]. Colloids and Surfaces: A Physicochem Eng Aspects, 2007, 298(1/2):42-51.

TAKAGI S, OGASAWARA T, MATSUMOTO Y. The effect of surfactant on the multiscale structure of bubbly flows [J]. Philosophical Transactions of the Royal Society: A, 2008, 366(3):2117-2129.

杜建伟, 唐翠萍, 樊栓狮, 等. Span20促进甲烷水合物生成的实验研究[J]. 西安交通大学学报, 2008,42(9): 1165-1168.

DU Jianwei, TANG Cuiping, FAN Shuanshi, et al. Experimental investigation on Span20 promoting effect on methane hydrate formation [J]. Journal of Xi'an Jiaotong University, 2008, 42(9): 1165-1168.

王焕然, 李彦鹏, 杨栋, 等. 粘性液体中单个气泡上升的形状特性[J]. 工程热物理学报, 2009, 30(9): 1492-1494.

WANG Huanran, LI Yanpeng, YANG Dong, et al. On the shape feature of a single bubble rising in viscous liquids [J]. Journal of Engineering Thermophysics, 2009, 30(9): 1492-1494.

何丹, 李彦鹏, 刘艳艳. 初始形状对浮升气泡动力特性的影响[J]. 西安交通大学学报, 2011,45(1): 6-10.

HE Dan, LI Yanpeng, LIU Yanyan. Effect of initial bubble shape on the dynamics of a buoyancy-driven bubble [J]. Journal of Xi'an Jiaotong University, 2011, 45(1): 6-10.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

Span20促进甲烷水合物生成的实验研究

跃移沙粒运动参数的数字图像分析

中等浓度表面活性剂溶液流变特性的实验研究

表面活性剂与纵向微沟槽协同减阻实验研究

多工况下离心压气机叶轮-机匣一体联合设计优化