二次喷油优化直喷汽油机冷启动排放特性的研究

刘德新; 刘斌

您当前的位置：

首页 >

文章列表页 >

二次喷油优化直喷汽油机冷启动排放特性的研究

更新时间：2025-07-09

- 二次喷油优化直喷汽油机冷启动排放特性的研究
- Study of Two-Stage Injection in Optimizing Cold-Start Emission Characteristics of GDI Engine
- 西安交通大学学报 2012年46卷第1期页码：13-18
- 作者机构：
  
  天津大学内燃机燃烧学国家重点实验室,天津,300072
- 作者简介：
- 基金信息：
  
  : 2011-07-01. 作者简介: 刘德新(1965-),男,副教授. 基金项目: 国家高技术研究发展计划资助项目(2006AA110108)
- DOI：
  中图分类号： TK411
- 网络首发：2012-01-10，
  
  纸质出版：2012
- 稿件说明：
移动端阅览
刘德新, 刘斌. 二次喷油优化直喷汽油机冷启动排放特性的研究[J]. 西安交通大学学报, 2012,46(1):13-18.

Study of Two-Stage Injection in Optimizing Cold-Start Emission Characteristics of GDI Engine[J]. 2012, 46(1): 13-18.
刘德新, 刘斌. 二次喷油优化直喷汽油机冷启动排放特性的研究[J]. 西安交通大学学报, 2012,46(1):13-18. DOI：

Study of Two-Stage Injection in Optimizing Cold-Start Emission Characteristics of GDI Engine[J]. 2012, 46(1): 13-18. DOI：

摘要

研究了一种通过特殊活塞顶面形状结合二次喷射策略来解决直喷汽油机冷启动工况排放问题的新方法.该方法通过适当的二次喷油分配、结合缸内气流运动来改善燃油混合气的分布.利用AVL-Fire对不同喷油策略下直喷汽油机启动时缸内油气混合分布进行了模拟

对不同喷油策略的冷启动排放进行了实验研究.结果表明

采用特殊活塞顶面形状进行合理的壁面引导

同时结合二次喷油策略

能够优化直喷汽油机冷启动工况下缸内空燃比的分布

使得混合气浓度在火花塞附近略高

宜于火花点火

在火花塞周围略低

宜于火焰传播

从而提高燃烧的稳定性

减少燃油的湿壁现象

降低HC的排放.

Abstract

A new solution to the cold start emissions of gasoline direct injection(GDI)engines was presented with two-stage injection strategy and special design of piston crown to improve the distribution of the air-fuel mixture and the combustion stability. AVL-Fire was used to simulate the distribution of fuel-air mixture in a cylinder under cold start condition. The cold-start-exhaust experiment with different injection strategies was conducted. The results show that the two-stage injection strategy combined with reasonably guiding the air flow would optimize the distribution of the fuel-air ratio in the cylinder under cold start condition

thus improving the characteristics of the spark ignition and the spread speed of the flame front

and mitigating fuel wetted-wall phenomenon. It seems that the present method may enhance the combustion stability and reduce the HC emissions.

关键词

Keywords

references

LECOINTE B, MONNIER G. Downsizing a gasoline engine using turbocharging with direct injection, SAE 2003-01-0542[R]. Warrendale, PA, USA: SAE, 2003.

ZHENG Xu, JIANG Yi. Modeling the cold start of the ford 3.5 L V6 EcoBoost engine, SAE 2009-01-1493 [R]. Warrendale, PA, USA: SAE, 2009.

倪培永,姚春德. 汽油机冷启动排放研究进展 [J].小型内燃机与摩托车, 2010, 39(4): 93-96.

NI Peiyong, YAO Chunde. Research process of emissions during cold-start of gasoline engine [J]. Small Internal Combustion Engine and Motorcycle, 2010,39(4):93-96.

栗工,李理光,邱冬平,等. 冷启动首循环瞬态HC排放与进气道燃料输运特性的关系 [J].燃烧科学与技术, 2008, 14(1): 73-78.

LI Gong, LI Liguang, QIU Dongping, et al. Transient HC emissions and fuel transport in the intake port of the first firing cycle during cold start [J]. Small Internal Combustion Engine and Motorcycle, 2008, 14(1): 73-78.

SANTOSO H, CHENG W K. Mixture preparation and hydrocarbon emissions behaviors in the first cycle of SI engine cranking, SAE 2002-01-2805 [R]. Warrendale, PA, USA: SAE, 2002.

史鉴明,李国祥.汽油机缸内直喷技术的研究与发展[J].山东机械, 2005, 24(3): 6-8.

SHI Jianming, LI Guoxiang. Research development of gasoline direct injection engine [J]. Shandong Machinery, 2005, 24(3): 6-8.

程勇,王建昕,吴宁,等.降低汽油机启动及暖机过程中HC排放的探讨[J].内燃机学报,2002,20(4):292-296.

CHENG Yong, WANG Jianxin, WU Ning, et al. Investigation on reducing HC emissions during cold-start and warm-up periods of gasoline engine [J]. Transactions of CSAICE, 2002, 20(4): 292-296.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

直喷汽油机起动过程多环芳烃排放的研究

水蒸气掺混对氨裂解气旋流燃烧与排放特性的影响研究

超临界水异常区域热力学特性研究

隧道内燃料电池汽车氢气泄漏扩散特性及影响因素

扇贝仿生密封腔室内超临界二氧化碳泄漏流湍动能耗散机理研究