采用内嵌边界方法模拟错列管束的磨损

金台; 罗坤; 杨建胜; 樊建人

您当前的位置：

首页 >

文章列表页 >

采用内嵌边界方法模拟错列管束的磨损

更新时间：2025-07-09

- 采用内嵌边界方法模拟错列管束的磨损
- Numerical Investigation into Erosion of Staggered Tube Bank Based on Immersed Boundary Method
- 西安交通大学学报 2012年46卷第7期页码：122-127
- 作者机构：
  
  浙江大学能源清洁利用国家重点实验室,杭州,310027
- 作者简介：
- 基金信息：
  
  : 2012-01-07. 作者简介: 金台(1988-),男,博士生;罗坤(通信作者),男,教授. 基金项目: 国家自然科学基金资助项目(50976098);钱江人才资助项目(2011R10030)
- DOI：
  中图分类号： O359
- 网络首发：2012-07-10，
  
  纸质出版：2012
- 稿件说明：
移动端阅览
金台, 罗坤, 杨建胜, 等. 采用内嵌边界方法模拟错列管束的磨损[J]. 西安交通大学学报, 2012,46(7):122-127.

Numerical Investigation into Erosion of Staggered Tube Bank Based on Immersed Boundary Method[J]. 2012, 46(7): 122-127.
金台, 罗坤, 杨建胜, 等. 采用内嵌边界方法模拟错列管束的磨损[J]. 西安交通大学学报, 2012,46(7):122-127. DOI：

Numerical Investigation into Erosion of Staggered Tube Bank Based on Immersed Boundary Method[J]. 2012, 46(7): 122-127. DOI：

摘要

采用内嵌边界方法

模拟研究了不同Stokes数St的煤灰颗粒穿过槽道中10×11错列不锈钢管束时的运动情况及其对管束的磨损规律.其中

流场与管束之间的耦合采用内嵌边界技术描述

颗粒的运动采用拉格朗日轨道模型求解.结果表明

不同St的颗粒有不同的运动特点

对管束造成的磨损也不同.第1排管束的平均磨损量在St=0.01

0.1时都较小

此后磨损量随着St的增大而增大.St=0.1时

第1排圆管的磨损量最小.靠近槽道壁面两列管束的平均磨损量大于中间管束

需加强防磨措施.

Abstract

The immersed boundary method was applied to investigate particle-laden flow passing a 10×11 staggered stainless tube bank in a duct at different Stokes numbers. The dispersion of coal ash particles and the tube erosion yielded by the flow were studied in detail. The interactions between tubes and flow were simulated using the immersed boundary technique. The trajectories of the particles were tracked through the Lagrangian approach with two-way coupling. The results show that the particles at different Stokes numbers have quite different dispersion patterns

leading to different tube erosion characteristics. Particles at larger Stokes number cause more erosion on the first row of tubes. However

only slight erosion occurs when St=0.01 and 0.1

and particles cause the smallest erosion on the first row of tubes when St=0.1. More attention should be paid to the anti-erosion of the tubes near the side walls where mass erosion is greater than that of the tubes in the middle.

关键词

Keywords

references

TABAKOFF W, KOTWAL R, HAMED A. Erosion study of different materials affected by coal ash particles [J]. Wear, 1979, 52(1):161-173.

TILLY G P. Erosion caused by impact of solid particles [J]. Treatise on Materials Science and Technology, 1979,13:287-298.

柳成文,毛靖儒, 俞茂铮. 90°弯管内稀疏气固两相流及固粒对壁面磨损量的数值研究[J].西安交通大学学报, 1999,33(9):53-57.

LIU Chengwen, MAO Jingru, YU Maozheng. Analysis of gas-solid two-phase flow and erosion in a 90° curved duct [J].Journal of Xi'an Jiaotong University, 1999,33(9):53-57.

姚军,陈丽华,樊建人,等. 一种气固两相流中弯管抗磨方法的数值试验研究[J].中国电机工程学报,2002,22(5):134-138.

YAO Jun, CHEN Lihua, FAN Jianren, et al. Numerical simulation of a new method for protecting bends from erosion in a gas-particle flows [J]. Proceeding of the CSEE, 2002,22(5):134-138.

LEE B, FLETCHER C A J, BEHNIA M. Computational study of solid particle erosion for a single tube in cross flow [J]. Wear, 2000,240(1/2): 95-99.

LEE B E, TU J Y, FLETCHER C A J. On numerical modeling of particle-wall impaction in relation to erosion prediction: Eulerian versus Lagrangian method [J].Wear, 2002, 252(3/4):179-188.

SATO S, SHIMIZU A, YOKOMINE T. Numerical prediction of erosion for suspension flow duct [J]. Wear, 1995, 186/187(1): 203-209.

FAN Jianren, ZHOU Dadong, JIN Jun. Numerical simulation of tube erosion by particle impaction [J].Wear, 1991, 142(1):171-184.

闫洁,李文春,樊建人,等. 绕流中颗粒与柱体碰撞和磨损的直接数值模拟[J]. 浙江大学学报:工学版, 2007,41(4):589-593.

YAN Jie, LI Wenchun, FAN Jianren, et al. Direct numerical simulation of collisions and erosions between particles and cylinder in circular cylinder wake [J].Journal of Zhejiang University: Engineering Science, 2007,41(4):589-593.

王则力, 罗坤, 樊建人. 颗粒与顺列管束磨损的数值模拟[J].工程热物理学报,2008,29(9): 1518-1520.

WANG Zeli, LUO Kun, FAN Jianren. Numerical study of the particulate erosion on aligned tube bank [J]. Journal of Engineering Thermophysics, 2008, 29(9): 1518-1520.

FAN J R, LUO K, ZHANG X Y, et al. Large eddy simulation of the anti-erosion characteristics of the ribbed-bend in gas-solid flows [J]. J of Eng for Gas Turbines and Power, 2004, 126(3): 672-679.

PESKIN C S. The immersed boundary method [J]. Acta Numer, 2002,11:479-517.

WANG Z L, FAN J R, LUO K. Combined multi-direct forcing and immersed boundary method for simulating flows with moving particles [J]. International Journal of Multiphase Flow, 2008, 34(3):283-302.

WANG Z L, FAN J R, LUO K. Numerical study of solid particle erosion on the tubes near the side walls in a duct with flow past an aligned tube bank [J]. AIChE Journal, 2010, 56(1):66-78.

ELGHOBASHI S. On predicting particle-laden turbulent flows [J]. Applied Scientific Research, 1994,52:309-329.

EATON J K, FESSLER J R. Preferential concentration of particles by turbulence [J]. International Journal of Multiphase Flow, 1994,20:169-209.

LUO K, FAN J R, LI W C, et al. Transient, three-dimensional simulation of particle dispersion in flows around a circular cylinder(Re=140-260)[J].Fuel, 2009,88(7):1294-1301.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

相邻圆柱/斜坡及其展向间距对平板流动转捩影响的直接数值模拟

低冲击能量液滴与球面碰撞沉积特性的数值研究

旋转矩形通道内湍流流动与换热的直接数值模拟

旋转矩形通道内湍流雷诺应力分析

泡状流相分布及湍流结构的欧拉-拉格朗日双向耦合数值研究