HCFC-141b水合物在管道中形成及堵塞实验研究

王武昌 1; 3; 樊栓狮 4; 梁德青 1; 2 关进安 1; 2; 3

您当前的位置：

首页 >

文章列表页 >

HCFC-141b水合物在管道中形成及堵塞实验研究

专题研究 | 更新时间：2025-12-08

- HCFC-141b水合物在管道中形成及堵塞实验研究
- Experimental Investigation on Formation and Blockage of HCFC-141b Hydrates in Pipeline
- 西安交通大学学报 2008年42卷第5期页码：602-606
- 作者机构：
  
  1. 中国科学院广州能源研究所,广州,510640
  2. 中国科学院可再生能源与天然气水合物重点实验室,广州,510640
  3. 中国科学院研究生院,北京,100039
- 作者简介：
- 基金信息：
  
  : 2007-09-14. 作者简介: 王武昌(1979-),男,博士生;樊栓狮(联系人),男,教授,博士生导师. 基金项目: 国家自然科学基金资助项目(90410003);国家高技术研究发展计划资助项目(2006AA05Z204)
- DOI：
  中图分类号： TQ021
- 纸质出版：2008
- 稿件说明：
移动端阅览
王武昌 1, 3, 樊栓狮 4, 等. HCFC-141b水合物在管道中形成及堵塞实验研究[J]. 西安交通大学学报, 2008,42(5):602-606.

王武昌 1, 3, 樊栓狮 4, et al. Experimental Investigation on Formation and Blockage of HCFC-141b Hydrates in Pipeline[J]. 2008, 42(5): 602-606.
王武昌 1, 3, 樊栓狮 4, 等. HCFC-141b水合物在管道中形成及堵塞实验研究[J]. 西安交通大学学报, 2008,42(5):602-606. DOI：

王武昌 1, 3, 樊栓狮 4, et al. Experimental Investigation on Formation and Blockage of HCFC-141b Hydrates in Pipeline[J]. 2008, 42(5): 602-606. DOI：

摘要

为了研究水合物浆在管道中的安全流动

在低温室中搭建了内径为42 mm、长为30 m的不锈钢实验环道

借助于实验环道进行了一氟二氯乙烷(HCFC-141b)水合物在管道中的形成以及堵塞实验.在水过量的条件下

管道中的水合物形态有浆状水合物和泥状水合物两种

在二者的过渡区

水合物的体积分数为30%～40%.管道中水合物的颗粒粒径在154～450 μm之间

而且随着水合物含量的增加

平均粒径逐渐增大.当水合物体积分数达到70%时

管道被完全堵塞.当管道中出现泥状水合物后

随着水合物含量的增加

水合物在管道中的聚集加剧

会很快造成整个管道堵塞

因此在运行过程中应避免泥状水合物的出现.

Abstract

Experiments on formation and blockage of CH

CCl

F(HCFC-141b)hydrate in pipelines were conducted in a newly built flow loop with a diameter of 42 mm and length of 30 m. The results show that there are two kinds of hydrate structures in the pipeline

slurrylike hydrates and slushlike hydrates

with superfluous water in the pipeline and the transition from slurrylike hydrates to slushlike hydrates occurred when the hydrate volume fraction is from 30% to 40%. Diameters of the hydrate particles in the pipeline are mainly from 154 μm to 450 μm and the average diameter of the hydrate particles increases with the increase of the hydrate volume fraction. Moreover

the pipeline is completely blocked with the hydrate when the hydrate volume fraction in the pipeline reaches

70%. In addition

the hydrates aggregate quickly with the increase of the hydrate volume fraction when slushlike hydrates occur

which can result in blockage in the whole pipeline.

关键词

Keywords

references

DENDY S E. A changing hydrate paradigm-from apprehension to avoidance to risk management[J]. Fluid Phase Equilib,2005,228: 67-74.

SINQUIN A, PALERMO T, PEYSSON Y. Rheological and flow properties of gas hydrate suspensions [J]. Oil Gas J, 2004,59(1): 41-57.

KINI R A, MATTHEWS P N, SUBRAMANIAN S, et al. Change the focus of hydrate plug prevention in the oil industry [C]∥The fifth international conference on gas hydrates. Trondheim, Norway: Tapir Academic Press, 2005:1208-1215.

DENDY S E. Seven industrial hydrate flow assurance lessons from 1993-2003[C]∥The fifth international conference on gas hydrates. Trondheim, Norway: Tapir Academic Press, 2005:1420-1431.

MARITA W, ARE L, NITA O, et al. Cold flow black oil slurry transport of the suspended hydrate and wax solids[C]∥The fifth international conference on gas hydrates. Trondheim, Norway: Tapir Academic Press, 2005:1101-1106.

KLEEHAMMER D M. Rheology of hydrate slurries: transferability between a laboratory viscometer and a pilot scale flow loop [D]. Golden, Colorado, USA: Colorado School of Mines, 2005.

LUND A. Comments to some preliminary results from the exx on hydrate flow loop[J]. Annals New York Academy of Scences,1994, 715: 447-449.

ANNIE F D, FREDERIC G, HERRI J M. Rheology of methane hydrate slurries during their crystallization in a water in dodecane emulsion under flowing [J]. Chemical Engineering Science, 2006, 61: 505-515.

TAYLOR C J. Micromechanical adhesion force measurements between tetrahydrofuran hydrate particles [J]. Journal of Colloid and Interface Science, 2007, 306(2):255-261.

LI Jinping, GUO Kaihua, LIANG Deqing, et al. Experiments on fast nucleation and growth of HCFC-141b gas hydrate in static water columns [J]. Int J Refrigeration, 2004, 27: 932-939.

KITANOVSKI A, POREDOS A. Concentration distribution and viscosity of ice-slurry in heterogeneous flow[J]. Int J Refrigeration, 2002, 25: 827-835.

TURNER D J, KLEEHAMMER D M, MILLER K T, et al. Formation of the hydrate obstructions in pipelines hydrate particle development and slurry flow[C]∥The fifth international conference on gas hydrates. Trondheim, Norway: Tapir Academic Press, 2005:1116-1125.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

EBSILON软件在热电联产系统优化中的应用综述

电动车辆间接热系统快速除湿响应迟滞机理及优化控制策略

不同板叠材料热声热机能量转换过程数值模拟研究

混合电解槽阵列协同的风光耦合制氢系统双层多目标优化

电子级超纯氮深冷空分流程节能优化研究