Influence of Hydrogen Blending in Natural Gas on the Dynamic Characteristics ofShaft-End Dry Gas Seals in Pipeline Compressors

XIA Yongbo; OUYANG Xin; CHENG Lei; LI Zhigang; LI Jun

doi:10.7652/xjtuxb202412018

您当前的位置：

首页 >

文章列表页 >

Influence of Hydrogen Blending in Natural Gas on the Dynamic Characteristics ofShaft-End Dry Gas Seals in Pipeline Compressors

更新时间：2025-07-28

- Influence of Hydrogen Blending in Natural Gas on the Dynamic Characteristics ofShaft-End Dry Gas Seals in Pipeline Compressors
- Vol. 58, Issue 12, Pages: 186-196(2024)
- 作者机构：
  
  1. 西安交通大学叶轮机械研究所,西安,710049
  2. 国家石油天然气管网集团有限公司
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb202412018
  CLC： TH136
- Online First：10 December 2024，
  
  Published：2024
- 稿件说明：
移动端阅览
XIA Yongbo, OUYANG Xin, CHENG Lei, et al. Influence of Hydrogen Blending in Natural Gas on the Dynamic Characteristics ofShaft-End Dry Gas Seals in Pipeline Compressors[J]. 2024, 58(12): 186-196.
DOI：

XIA Yongbo, OUYANG Xin, CHENG Lei, et al. Influence of Hydrogen Blending in Natural Gas on the Dynamic Characteristics ofShaft-End Dry Gas Seals in Pipeline Compressors[J]. 2024, 58(12): 186-196. DOI： 10.7652/xjtuxb202412018.

摘要

为探究天然气掺氢对管线压缩机轴端干气密封动力学特性的影响

提出了干气密封动力学特性的三自由度多频扰动非定常计算流体力学摄动数值预测方法

通过实验和数值结果验证了方法的可靠性。采用该方法研究了10种扰动频率、4种掺氢比和3种进口压力对干气密封动力学特性系数的影响规律

结果表明:所提方法能准确预测干气密封受轴向和角向多频率扰动时的动力学特性系数; 随着扰动频率的增大

气膜轴向阻尼和角向直接阻尼呈抛物线趋势减小

表明气膜在高频扰动下易失稳; 随着掺氢比的增加

气膜轴向刚度和角向直接刚度分别减小了7.81%～12.19%、6.66%～14.05%

轴向阻尼和角向直接阻尼变化较小(<5%)

表明天然气掺氢降低了气膜抵抗外界轴向和角向扰动的能力

但对气膜恢复平衡稳定的能力影响较小; 增加进口压力会提高各动力学特性系数

有利于干气密封形成稳定气膜。研究可为掺氢条件下天然气管线压缩机轴端干气密封的可靠设计和安全稳定运行提供参考。

Abstract

To explore the impact of hydrogen blending in natural gas on the dynamic characteristics of shaft-end dry gas seals(DGS)in pipeline compressors

a three-degree-of-freedom multi-frequency perturbation unsteady computational fluid dynamics perturbation numerical prediction method for dynamic characteristics of DGS is proposed. The method's reliability is verified through experimental and numerical results. Using this method

the effects of ten disturbance frequencies

four hydrogen blending ratios

and three inlet pressures on the dynamic characteristic coefficient of DGS are examined. The results demonstrate that the proposed method accurately predicts the dynamic characteristic coefficients of DGS under axial and angular multi-frequency perturbations. As the disturbance frequency increases

the axial gas film damping and angular direct damping decrease in a parabolic manner

indicating the gas film's susceptibility to instability under high-frequency perturbations. With an escalation in hydrogen blending ratio

the axial gas film stiffness and angular direct stiffness diminish by 7.81% to 12.19% and 6.66% to 14.05%

respectively

while the axial damping and angular direct damping exhibit minimal changes(<5%). This suggests that hydrogen blending in natural gas reduces the gas film's capacity to withstand external axial and angular disturbances

but has a relatively minor impact on its ability to restore balance and stability. Furthermore

increasing the inlet pressure enhances all dynamic characteristic coefficients

which is beneficial for the formation of a stable gas film in DGS. This study provides valuable insights for the reliable design and safe operation of shaft-end DGS in natural gas pipeline compressors under hydrogen blending conditions.

关键词

Keywords

references

TIMMERBERG S, KALTSCHMITT M. Hydrogen from renewables: supply from North Africa to Central Europe as blend in existing pipelines-potentials and costs [J]. Applied Energy, 2019, 237: 795-809.

司起步, 邱硕, 毕胜山, 等. 碳强度和水资源约束下2030年中国西北五省能源供给规划研究 [J]. 西安交通大学学报, 2022, 56(5): 31-42.

SI Qibu, QIU Shuo, BI Shengshan, et al. Energy supply planning of the five northwest provinces in 2030 under carbon intensity and water resource constraints [J]. Journal of Xi'an Jiaotong University, 2022, 56(5): 31-42.

LIU Bo, LIU Shixue, GUO Shusheng, et al. Economic study of a large-scale renewable hydrogen application utilizing surplus renewable energy and natural gas pipeline transportation in China [J]. International Journal of Hydrogen Energy, 2020, 45(3): 1385-1398.

YUAN Tao, LI Zhigang, LI Jun, et al. Static and rotordynamic characteristics for supercritical carbon dioxide spiral groove dry gas seal with the tilted seal ring [J]. Journal of Engineering for Gas Turbines and Power, 2023, 145(1): 011011.

陈珂, 王硕琨, 杜文海, 等. 天然气管道掺氢输送对离心压缩机气动性能的影响 [J]. 油气储运, 2023, 42(4): 398-406.

CHEN Ke, WANG Shuokun, DU Wenhai, et al. Influence of hydrogen-blended natural gas via pipeline transportation on aerodynamic performance of centrifugal compressor [J]. Oil Gas Storage and Transportation, 2023, 42(4): 398-406.

夏永波, 宦宣州, 李志刚, 等. 掺氢天然气干气密封启动特性研究 [J]. 西安交通大学学报, 2024, 58(3): 82-94.

XIAYongbo, HUAN Xuanzhou, LI Zhigang, et al. Study on startup characteristics of dry gas seal with hydrogen-blended natural gas [J]. Journal of Xi'an Jiaotong University, 2024, 58(3): 82-94.

宋鹏云, 胡晓鹏, 许恒杰. 实际气体对T槽干气密封动态特性的影响 [J]. 化工学报, 2014, 65(4): 1344-1352.

SONG Pengyun, HU Xiaopeng, XU Hengjie. Effect of real gas on dynamic performance of T-groove dry gas seal [J]. CIESC Journal, 2014, 65(4): 1344-1352.

许恒杰, 宋鹏云, 毛文元, 等. 考虑氢气实际气体效应和阻塞流效应的螺旋槽干气密封动态特性分析 [J]. 化工学报, 2017, 68(12): 4675-4684.

XU Hengjie, SONG Pengyun, MAO Wenyuan, et al. Dynamic characteristics of spiral groove dry gas seals with consideration of hydrogen real gas and choked flow effects [J]. CIESC Journal, 2017, 68(12): 4675-4684.

江锦波, 滕黎明, 孟祥铠, 等. 基于多变量摄动的超临界CO2干气密封动态特性 [J]. 化工学报, 2021, 72(4): 2190-2202.

JIANG Jinbo, TENG Liming, MENG Xiangkai, et al. Dynamic characteristics of supercritical CO2 dry gas seal based on multi variables perturbation [J]. CIESC Journal, 2021, 72(4): 2190-2202.

MALANOSKI S B, PAN C H T. The static and dynamic characteristics of the spiral-grooved thrust bearing [J]. Journal of Basic Engineering, 1965, 87(3): 547-555.

ZIRKELBACK N, SAN ANDRÉS L. Effect of frequency excitation on force coefficients of spiral groove gas seals [J]. Journal of Tribology, 1999, 121(4): 853-861.

FARIA M T C. An efficient finite element procedure for analysis of high-speed spiral groove gas face seals [J]. Journal of Tribology, 2001, 123(1): 205-210.

FARIA M T C. Finite element analysis of the misalignment effects on the dynamic force coefficients of spiral groove gas face seals [J]. JSME International Journal: Series C Mechanical Systems, Machine Elements and Manufacturing, 2004, 47(1): 289-296.

RUAN Bo. A semi-analytical solution to the dynamic tracking of non-contacting gas face seals [J]. Journal of Tribology, 2002, 124(1): 196-202.

许恒杰, 宋鹏云. 三自由度微扰下的静压干气密封动态特性分析 [J]. 排灌机械工程学报, 2017, 35(1): 56-64.

XU Hengjie, SONG Pengyun. Analysis on dynamic characteristics of aerostatic dry gas seals with three degrees of freedom perturbation [J]. Journal of Drainage and Irrigation Machinery Engineering, 2017, 35(1): 56-64.

XU Hengjie, YUE Yinggang, SONG Pengyun, et al. Analysis on the dynamic characteristics of spiral groove dry gas seal based on the gas film adaptive adjustment model [J]. Industrial Lubrication and Tribology, 2023, 75(4): 406-414.

陈源, 彭旭东, 李纪云, 等. 螺旋槽结构参数对干气密封动态特性的影响研究 [J]. 摩擦学学报, 2016, 36(4): 397-405.

CHEN Yuan, PENG Xudong, LI Jiyun, et al. The influence of structure parameters of spiral groove on dynamic characteristics of dry gas seal [J]. Tribology, 2016, 36(4): 397-405.

CHEN Yuan, SHANG Hao, LI Xiaolu, et al. The influence of 3-DOF film thickness disturbance on transient performance of typical spiral groove dry gas seals [J]. Industrial Lubrication and Tribology, 2022, 74(1): 45-55.

MILLER B A, GREEN I. Numerical techniques for computing rotordynamic properties of mechanical gas face seals [J]. Journal of Tribology, 2002, 124(4): 755-761.

刘向锋, 徐辰, 黄伟峰. 基于半解析法的极端工况干气密封动态特性研究与参数设计 [J]. 清华大学学报(自然科学版), 2014, 54(2): 223-228.

LIU Xiangfeng, XU Chen, HUANG Weifeng. Analysis and parametric design of the dynamics of a dry gas seal for extreme operating conditions using a semi-analytical method [J]. Journal of Tsinghua University(Science and Technology), 2014, 54(2): 223-228.

MILLER B A, GREEN I. Numerical formulation for the dynamic analysis of spiral-grooved gas face seals [J]. Journal of Tribology, 2001, 123(2): 395-403.

沈登海, 刘小明, 王泽平, 等. 管道天然气离心压缩机干气密封国产化研制 [J]. 石油化工设备技术, 2020, 41(2): 39-46.

SHEN Denghai, LIU Xiaoming, WANG Zeping, et al. Domestic development of dry gas seal for pipeline natural gas centrifugal compressor [J]. Petrochemical Equipment Technology, 2020, 41(2): 39-46.

王鹏, 杨放, 孙东亮, 等. 基于预估校正思想的离心压缩机性能换算 [J]. 科学通报, 2018, 63(5): 571-578.

WANG Peng, YANG Fang, SUN Dongliang, et al. Performance conversion of centrifugal compressors based on predictor corrector method [J]. Chinese Science Bulletin, 2018, 63(5): 571-578.

李志刚, 李军, 丰镇平. 袋型阻尼密封转子动力特性的多频单向涡动预测模型 [J]. 西安交通大学学报, 2012, 46(5): 13-18.

LI Zhigang, LI Jun, FENG Zhenping. Multiple frequencies one-dimensional prediction model of rotordynamic characteristics for pocket damper seals [J]. Journal of Xi'an Jiaotong University, 2012, 46(5): 13-18.

陈源. 高速螺旋槽干气密封动态性能理论与实验研究 [D]. 杭州: 浙江工业大学, 2018.

LIU Yuchuan, SHEN Xinmin, XU Wanfu. Numerical analysis of dynamic coefficients for gas film face seals [J]. Journal of Tribology, 2002, 124(4): 743-754.

张树强, 蔡纪宁, 李双喜, 等. 周向波度气体密封的动态特性 [J]. 润滑与密封, 2011, 36(12): 55-59.

ZHANG Shuqiang, CAI Jining, LI Shuangxi, et al. Dynamic characteristics of circumferential waviness gas seal [J]. Lubrication Engineering, 2011, 36(12): 55-59.

LI Zhigang, LI Jun, YAN Xin. Multiple frequencies elliptical whirling orbit model and transient RANS solution approach to rotordynamic coefficients of annual gas seals prediction [J]. Journal of Vibration and Acoustics, 2013, 135(3): 031005.

BRUNETIÈRE N, TOURNERIE B, FRÊNE J. Influence of fluid flow regime on performances of non-contacting liquid face seals [J]. Journal of Tribology, 2002, 124(3): 515-523.

YU Yunluo, PU Guang, JIANG Tianchu, et al. Optimization of herringbone grooved thrust air bearings for maximum load capacity [J]. Journal of Tribology, 2021, 143(12): 121805.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Numerical Analysis for Impact of Spacing Ring Nonparallelism on Bearing Performance

Study on the Dynamic Characteristics of Water-Lubricated Rubber Journal Bearing Considering Journal Misalignment

Study on Startup Characteristics of Dry Gas Seal with Hydrogen-Blended Natural Gas

Study on the Thermodynamic Properties in the Anomalous Region of Supercritical Water

Windage Loss and Flow Characteristics in Impeller Back Gaps of sCO2 Radial Inflow Turbines

Related Author

张浩 1

张进华 1

朱永生 2

邱志惠 1

王耀玮 3

刘洋洋 1

王亚兵 1

祝长生 2

Related Institution

State Key Laboratory for Manufacturing Systems Engineering, Xi'an Jiaotong University

Key Laboratory of Education Ministry for Modern Design and Rotor-Bearing System, Xi’an Jiaotong University

Xi'an Thermal Power Research Institute Co., Ltd.

⁰