Effects of Pipe Fittings on the Acoustic Transfer-Radiation Characteristic through Pipelines

doi:10.7652/xjtuxb202201009

您当前的位置：

首页 >

文章列表页 >

Effects of Pipe Fittings on the Acoustic Transfer-Radiation Characteristic through Pipelines

更新时间：2025-05-08

- Effects of Pipe Fittings on the Acoustic Transfer-Radiation Characteristic through Pipelines
- Vol. 56, Issue 1, Pages: 79-84(2022)
- 作者机构：
  
  中国舰船研究设计中心船舶振动噪声重点实验室,武汉,430064
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb202201009
  CLC： TB535
- Online First：10 January 2022，
  
  Published：2022
- 稿件说明：
移动端阅览
Effects of Pipe Fittings on the Acoustic Transfer-Radiation Characteristic through Pipelines[J]. 2022, 56(1): 79-84.
DOI：

Effects of Pipe Fittings on the Acoustic Transfer-Radiation Characteristic through Pipelines[J]. 2022, 56(1): 79-84. DOI： 10.7652/xjtuxb202201009.

摘要

为控制海水冷却系统通海口产生的辐射噪声

考虑管路及管路附件的弹性影响

建立了简化的通海系统流噪声传递-辐射的仿真模型; 从避免管路流噪声传递损失的角度

提出了基于总传递损失的管路系统声传递-辐射特性的评价方法; 借助商业软件计算了不同管路附件影响下的管路声传递-辐射的总传递损失

给出了管路附件对管路声学总传递损失的影响规律。计算结果表明

与无管路附件的直管路相比

换热器可以使总传递损失提高94.9 dB

挠性接管可提高33 dB

截止止回阀可提高28.5 dB

相比之下

滤器、变径管、弯头对总传递损失的提升均小于10 dB

蝶阀仅可提高1.5 dB。通过研究发现

管路附件可以提高对通海系统辐射噪声的控制效果。实际的海水冷却系统的管路附件集中在系统出口管路

使得出口管路附件多于进口管路

导致进口管路辐射噪声控制不足。增加进口管路上的管路附件可提高系统辐射噪声的控制效果。

Abstract

To control the radiation noise at the open end of pipe for a seawater cooling system

a simplified numerical model is established for the acoustic transfer-radiation of hydrodynamic noise throughout pipelines in the seawater cooling system in consideration of elasticity of pipe and pipe fittings. From the perspective of hydrodynamic noise transmission loss through pipes and pipe fittings

an evaluation methodology for the acoustic transfer-radiation characteristic through pipelines is proposed based on the total acoustic transmission loss. The total acoustic transmission loss of a pipe system with different pipe fittings is calculated using a commercial software of computational acoustics

and the effect of pipe fittings on acoustic transfer-radiation characteristic is revealed. Computation results show that the total transmission loss is increased by about 94.9 dB by the heat exchanger

33 dB by the flexible tube

and 28.5 dB by the stop check valve

compared with a straight pipe. However

the increment of total transmission loss is below 10 dB by colander

elbow and adapter bonnet

and is only 1.5 dB by butterfly valve. It can be concluded that pipe fittings tend to promote the total transmission loss. Outlet pipe of an actual cooling system usually contains a heat exchanger and more fittings than the inlet pipe

however

the radiation noise of the system in the inlet pipe is not properly controlled. So it is suggested that more pipe fittings be mounted into the inlet pipe to control the radiation noise.

关键词

Keywords

references

方超, 蔡标华, 马士虎, 等. 基于BEM/FEM的船舶注水系统管路噪声分离预报 [J]. 噪声与振动控制, 2018, 38(5): 89-93.

FANG Chao, CAI Biaohua, MA Shihu, et al. Noise separation prediction of water injection pipeline systems of warships based on BEM/FEM [J]. Noise and Vibration Control, 2018, 38(5): 89-93.

刘厚林, 丁剑, 王勇, 等. 基于大涡模拟的离心泵水动力噪声数值模拟 [J]. 机械工程学报, 2013, 49(18): 177-183.

LIU Houlin, DING Jian, WANG Yong, et al. Numerical simulation of hydrodynamic noise in centrifugal pump based on LES [J]. Journal of Mechanical Engineering, 2013, 49(18): 177-183.

季振林. 消声器声学理论与设计 [M]. 北京: 科学出版社, 2015: 33-45.

DONG R, CHU S, KATZ J. Effect of modification to tongue and impeller geometry on unsteady flow, pressure fluctuations, and noise in a centrifugal pump [J]. Journal of Turbomachinery, 1997, 119(3): 506-515.

CHU S, DONG R, KATZ J. Relationship between unsteady flow, pressure fluctuations, and noise in a centrifugal pump: part A Use of PDV data to compute the pressure field [J]. Journal of Fluids Engineering, 1995, 117(1): 24-29.

SI Qiaorui, ALI A, YUAN Jianping, et al. Flow-induced noises in a centrifugal pump: a review [J]. Science of Advanced Materials, 2019, 11(7): 909-924.

CHU S, DONG R, KATZ J. Relationship between unsteady flow, pressure fluctuations, and noise in a centrifugal pump: part B Effects of blade-tongue interactions [J]. Journal of Fluids Engineering, 1995, 117(1): 30-35.

WANG Yuqin, DING Zewen. Influence of blade number on flow-induced noise of centrifugal pump based on CFD/CA [J]. Vacuum, 2020, 172: 109058.

GAO Ming, DONG Peixin, LEI Shenghui, et al. Computational study of the noise radiation in a centrifugal pump when flow rate changes [J]. Energies, 2017, 10(2): 221.

TANG X M, TOKSÖZ M N, CHENG C H. Elastic wave radiation and diffraction of a piston source [J]. The Journal of the Acoustical Society of America, 1990, 87(5): 1894-1902.

DOUGLAS MAST T, YU Feng. Simplified expansions for radiation from a baffled circular piston [J]. The Journal of the Acoustical Society of America, 2005, 118(6): 3457-3464.

LAPIN A D. Radiation impedance of a piston in a waveguide [J]. Acoustical Physics, 2000, 46(3): 367-369.

CHOY Y S, HUANG Lixi. Experimental studies of a drumlike silencer [J]. The Journal of the Acoustical Society of America, 2002, 112(5): 2026-2035.

HUANG Lixi. Modal analysis of a drumlike silencer [J]. The Journal of the Acoustical Society of America, 2002, 112(5): 2014-2025.

YU Xiang, TONG Yuhui, PAN Jie, et al. Sub-chamber optimization for silencer design [J]. Journal of Sound and Vibration, 2015, 351: 57-67.

CHOY Y S, HUANG Lixi. Effect of flow on the drumlike silencer [J]. The Journal of the Acoustical Society of America, 2005, 118(5): 3077-3085.

PARRONDO J, PÉREZ J, BARRIO R, et al. A simple acoustic model to characterize the internal low frequency sound field in centrifugal pumps [J]. Applied Acoustics, 2011, 72(1): 59-64.

SULLIVAN J W. A method for modeling perforated tube muffler components: I Theory [J]. The Journal of the Acoustical Society of America, 1979, 66(3): 772-778.

MUNJAL M L. Analysis of a flush-tube three-pass perforated element muffler by means of transfer matrices [J]. International Journal of Acoustics and Vibration, 1997, 2(2): 63-68.

JI Zhenlin, FAN Yiliang. MAP: a simulative program for acoustic prediction and analysis of duct muffling systems [C]∥Proceedings of the SAE 2015 Noise and Vibration Conference and Exhibition. Warrendale, PA, USA: SAE, 2015: 2015-01-2317.

EASWARAN V, MUNJAL M L. Plane wave analysis of conical and exponential pipes with incompressible mean flow [J]. Journal of Sound and Vibration, 1992, 152(1): 73-93.

RZENTKOWSKI G, ZBROJA S. Experimental characterization of centrifugal pumps as an acoustic source at the blade-passing frequency [J]. Journal of Fluids and Structures, 2000, 14(4): 529-558.

SELAMET A, EASWARAN V. Modified Herschel-Quincke tube: attenuation and resonance for n-duct configuration [J]. The Journal of the Acoustical Society of America, 1997, 102(1): 164-169.

孙玉东, 钟荣, 王锁泉, 等. 基于双端口声源特性测试方法的离心泵水动力噪声试验研究 [J]. 船舶力学, 2016, 20(S1): 198-205.

SUN Yudong, ZHONG Rong, WANG Suoquan, et al. Experimental research on hydrodynamic noise of centrifugal pumps based on two-port source characteristic test method [J]. Journal of Ship Mechanics, 2016, 20(S1): 198-205.

何祚镛. 水下噪声及其控制技术进展和展望 [J]. 应用声学, 2002, 21(1): 26-34.

HE Zuoyong. Review of some aspects of underwater noise including its control techniques and Its prospect [J]. Applied Acoustics, 2002, 21(1): 26-34.

-------

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Mechanism and Optimal Control Strategy for Hysteresis in Rapid Dehumidification Response of Indirect Thermal Systems in Electric Vehicles

Numerical Simulation of Heat-Moisture Barrier Performance of a Horizontal Air Curtain in Cold Storage

Numerical Simulation of the Energy Conversion Process in Thermoacoustic Engines with Different Stack Materials

Effects of Steam Addition on the Swirl Combustion and Emission Characteristics of Cracked Ammonia

Study on the Thermodynamic Properties in the Anomalous Region of Supercritical Water

Related Author

No data

Related Institution

No data

⁰