Effects of Hydrogen-Rich Reformed Gas on the Combustion Reaction Process in a Natural Gas Engine

doi:10.7652/xjtuxb202109017

您当前的位置：

首页 >

文章列表页 >

Effects of Hydrogen-Rich Reformed Gas on the Combustion Reaction Process in a Natural Gas Engine

更新时间：2025-07-09

- Effects of Hydrogen-Rich Reformed Gas on the Combustion Reaction Process in a Natural Gas Engine
- Vol. 55, Issue 9, Pages: 152-160(2021)
- 作者机构：
  
  武汉理工大学能源与动力工程学院,武汉,430063
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb202109017
  CLC： TK46
- Online First：10 September 2021，
  
  Published：2021
- 稿件说明：
移动端阅览
Effects of Hydrogen-Rich Reformed Gas on the Combustion Reaction Process in a Natural Gas Engine[J]. 2021, 55(9): 152-160.
DOI：

Effects of Hydrogen-Rich Reformed Gas on the Combustion Reaction Process in a Natural Gas Engine[J]. 2021, 55(9): 152-160. DOI： 10.7652/xjtuxb202109017.

摘要

为研究基于废气重整再循环(REGR)技术的天然气发动机燃烧排放调控机制

开展了富氢重整气添加对点燃式天然气发动机缸内燃烧过程影响的数值模拟研究。结果表明

添加富氢重整气与增大过量空气系数对天然气发动机的燃烧过程的影响规律相反。增大重整气添加率可使燃料着火时刻提前1.42°

燃烧持续期缩短; 增大过量空气系数则会使缸内平均压力峰值和放热率峰值降低

着火时刻滞后2.24°。REGR率增加到16%时可使总碳氢化合物排放降低26.98%

排放降低62.52%

但会导致发动机功率降低9.52%。基于此

从化学动力学角度进一步解析REGR率对天然气发动机缸内燃料燃烧反应过程与污染物生成演化过程的影响。结果表明

随REGR率增大

OH自由基参与CH

消耗反应占比增大

从而加快基元反应速率

使燃烧相位提前

并使未燃HC排放降低。

Abstract

To investigate the regulation mechanism of reformed exhaust gas recirculation(REGR)technology on the combustion and emission of natural gas engines

a numerical simulation study on the combustion process of the spark-ignition natural gas engine was conducted. The results show that the effects of hydrogen-rich reformed gas addition on the combustion process of natural gas engines are inverse to that of increasing excess air coefficient. Specifically

the ignition time of fuel advances by 1.42° and the combustion duration is shortened with the increase of the reformed gas addition rate(REGR rate). However

with the increase of excess air coefficient

the in-cylinder pressure and the heat release rate both decrease

and also

the ignition time is delayed by 2.24°. When REGR rate increases by 16%

the total hydrocarbon(THC)and NO

emission are reduced by 26.98% and 62.52%

respectively; but the engine power will be reduced by 9.52%. Thereout

the influences of REGR rate on the fuel combustion process and pollutant formation process of liquefied natural gas engines were further analyzed from the perspective of chemical kinetics. It shows that the proportion of OH radical participating in CH

consumption reaction increases with the REGR rate. Consequently

the combustion phase is advanced by accelerating the elementary reaction rate

and the unburned HC emission is reduced as well.

关键词

Keywords

references

AYDIN M. Natural gas consumption and economic growth nexus for top 10 natural gas-consuming countries: a granger causality analysis in the frequency domain [J]. Energy, 2018, 165: 179-18.

黄丫. 缸内直喷CNG发动机稀薄燃烧特性的研究 [D]. 长春: 吉林大学, 2015.

贾朋朋. LNG发动机废气重整制氢反应器数值模拟研究 [D]. 武汉: 武汉理工大学, 2018.

黄彬, 胡二江, 黄佐华, 等. 火花点火天然气掺氢发动机结合EGR时的循环变动规律 [J]. 内燃机学报, 2011, 29(1): 16-22.

HUANG Bin, HU Erjiang, HUANG Zuohua, et al. Cycle-by-cycle variations of a spark ignition engine fueled with natural gas-hydrogen blends combined with EGR [J]. Transactions of CSICE, 2011, 29(1): 16-22.

陈浩, 刘兵, 王金华, 等. 火花点火发动机燃用天然气掺氢混合燃料循环变动研究 [J]. 内燃机学报, 2009, 27(1): 18-24.

CHEN Hao, LIU Bing, WANG Jinhua, et al. Study of cycle-by-cycle variations of a spark ignition engine fueled with natural gas/hydrogen blends [J]. Transactions of CSICE, 2009, 27(1): 18-24.

YAP D, PEUCHERET S M, MEGARITIS A, et al. Natural gas HCCI engine operation with exhaust gas fuel reforming [J]. International Journal of Hydrogen Energy, 2006, 31(5): 587-595.

钟绍华, 蒋芬, MIROSLA W W. 天然气闭环燃料重整的均质压燃(HCCI)试验研究 [J]. 内燃机工程, 2008(2): 1-5.

ZHONG Shaohua, JIANG Fen, MIROSLA W W. Experimental research on natural gas HCCI with closed-loop fuel reforming [J]. Chinese Internal Combustion Engine Engineering, 2008(2): 1-5.

毛立通, 张尊华, 梁俊杰, 等. REGR成分对船用LNG发动机燃烧与排放特性的影响模拟 [J]. 中国航海, 2018, 41(3): 21-25.

MAO Litong, ZHANG Zunhua, LIANG Junjie, et al. Simulation on effects of REGR composition on combustion and emission characteristics of marine LNG engine [J]. Navigation of China, 2018, 41(3): 21-25.

LONG Yanxiang, LI Gesheng, ZHANG Zunhua, et al. Effects of reformed exhaust gas recirculation on the HC and CO emissions of a spark-ignition engine fueled with LNG [J]. International Journal of Hydrogen Energy, 2018, 43(45): 21070-21078.

HU Erjiang, HUANG Zuohua, HE Jiajia, et al. Experimental and numerical study on laminar burning characteristics of premixed methane-hydrogen-air flames [J]. International Journal of Hydrogen Energy, 2009, 34(11): 4876-4888.

WANG Jinhua, HUANG Zuohua, TANG Chenglong, et al. Numerical study of the effect of hydrogen addition on methane-air mixtures combustion [J]. International Journal of Hydrogen Energy, 2009, 34(2): 1084-1096.

LI Yu, LI Hailin, GUO Hongsheng, et al. A numerical study on the chemical kinetics process during auto-ignition of n-heptane in a direct injection compression ignition engine [J]. Applied Energy, 2018, 212: 909-918.

LIU Xinlei, WANG Hu, YAO Mingfa. Investigation of the chemical kinetics process of diesel combustion in a compression ignition engine using the large eddy simulation approach [J]. Fuel, 2020, 270: 117544.

TANG Qinglong, LIU Xinlei, LIU Haifeng, et al. Investigation on the dual-fuel active-thermal atmosphere combustion strategy based on optical diagnostics and numerical simulations [J]. Fuel, 2020, 276: 118023.

DAVID G G, RAYMOND L S, HARRY K M, et al. Cantera: an object-oriented software toolkit for chemical kinetics, thermodynamics, and transport processes [EB/OL].[2020-12-01]. https:∥www.cantera.org.

LIU Xinlei, KOKJOHN S, LI Yu, et al. A numerical investigation of the combustion kinetics of reactivity controlled compression ignition(RCCI)combustion in an optical engine [J]. Fuel, 2019, 241: 753-766.

HAN Z, REITZ R D. Turbulence modeling of internal combustion engines using RNG k-ε models [J]. Combustion Science and Technology, 1995, 106: 267-95.

SENECAL P K, POMRANING E, RICHARDS K J, et al. Multi-dimensional modeling of direct-injection diesel spray liquid length and flame lift-off length using CFD and parallel detailed chemistry [J]. SAE Technical Paper, 2003, 112: 1331-1351.

SMITH G P, GOLDEN D M, FRENKLACH M, et al. Gri-mech 3.0 [EB/OL]. [2020-12-01]. http:∥www.me.berkeley.edu/gri_mech.

WANG Hu, YAO Mingfa, YUE Zongyu, et al. A reduced toluene reference fuel chemical kinetic mechanism for combustion and polycyclic-aromatic hydrocarbon predictions [J]. Combustion and Flame, 2015, 162(6): 2390-2404.

HAMEDI M R, TSOLAKIS A, LAU C S. Biogas upgrading for on-board hydrogen production: reforming process CFD modelling [J]. International Journal of Hydrogen Energy, 2014, 39(24): 12532-12540.

SHUDO T, SHIMA Y, FUJII T. Production of dimethyl ether and hydrogen by methanol reforming for an HCCI engine system with waste heat recovery: continuous control of fuel ignitability and utilization of exhaust gas heat [J]. International Journal of Hydrogen Energy, 2009, 34(18): 7638-7647.

KUMARJ T S, SHARMA T K, MURTHY K M, et al. Effect of reformed EGR on the performance and emissions of a diesel engine: a numerical study [J]. Alexandria Engineering Journal, 2018, 57(2): 517-525.

姜磊, 李兴虎, 王宇, 等. 天然气/氢气混合燃料发动机的稀燃极限和排放特性试验研究 [J]. 汽车工程, 2008(3): 197-201.

JIANG Lei, LI Xinghu, WANG Yu, et al. An experimental study on lean burn limits and emission characteristics of an engine fuelled with CNG/hydrogen blends [J]. Automotive Engineering, 2008(3): 197-201.

王忠诚, 许乐平, 周培林, 等. 大型低速共轨电喷船用柴油机排放特性分析 [J]. 上海海事大学学报, 2015, 36(2): 70-73.

WANG Zhongcheng, XU Leping, ZHOU Peilin, et al. Emission characteristic analysis of large-scale low-speed common-rail marine diesel engines with electronic fuel injection [J]. Journal of Shanghai Maritime University, 2015, 36(2): 70-73.

龙焱祥, 王忠俊. 替代率对船用LNG/柴油双燃料发动机性能的影响 [J]. 内燃机, 2016(2): 44-47.

LONG Yanxiang, WANG Zhongjun. Effort of replacement ratio on the performance of LNG/diesel dual-fuel engine [J]. Internal Combustion Engines, 2016(2): 44-47.

赵睿, 许乐平, 冯是全, 等. 燃料掺氢对船用天然气发动机燃烧和排放的影响 [J]. 推进技术, 2020, 41(11): 2549-2557.

ZHAO Rui, XU Leping, FENG Shiquan, et al. Effects of hydrogen addition in fuel of marine LNG fueled engines on combustion and emissions [J]. Journal of Propulsion Technology, 2020, 41(11): 2549-2557.

朱浩月, ASSANIS D, 黄震. 低温燃烧模式生物柴油发动机CO和HC的排放 [J]. 内燃机学报, 2014, 32(1): 1-5.

ZHU Haoyue, ASSANIS D, HUANG Zhen. CO and HC emissions of biodiesel in low temperature combustion mode [J]. Transactions of CSICE, 2014, 32(1): 1-5.

WANG Du, JI Changwei, WANG Shuofeng, et al. Further understanding the premixed methane/hydrogen/air combustion by global reaction pathway analysis and sensitivity analysis [J]. Fuel, 2020, 259: 116190.

RAHNAMA P, PAYKANI A, BORDBARV, et al. A numerical study of the effects of reformer gas composition on the combustion and emission characteristics of a natural gas/diesel RCCI engine enriched with reformer gas [J]. Fuel, 2017, 209: 742-753.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Numerical Simulation of Combustion Process in a Spark-Ignition Engine Fuelled with Natural Gas-Hydrogen Blends Combined with Exhaust Gas Recirculation

Effect of Adding Oxygenated Fuel on Particles Emissions of Pilot-Ignited Natural Gas Engine

Low-Speed Performance Improvement of Natural Gas Engine by Asynchronous Intake Timing and Turbocharger Matching

Influence of Injection Strategy on Combustion and Emissions of Multi-point Injection Natural Gas Engine

Multi-Scale Analysis of Combustion Instability in Natural Gas Engine

Related Author

刘兵

黄佐华

王婕

曾科 1

刘亦夫 1

郑瑜 1

宁小康 1

Related Institution

State Key Laboratory of Multiphase Flow in Power Engineering, Xi'an Jiaotong University

School of Energy and Power Engineering, Xi'an Jiaotong University

Powertrain Research Institute, Gealy Automotive Co. Ltd.

College of Power and Energy Engineering, Harbin Engineering University

School of Mechanical and Power Engineering, Zhengzhou University

⁰