Evaluation of Flow Stability and Uniformity in Double Elbow Pipe with Circular Cross Section

doi:10.7652/xjtuxb202106013

您当前的位置：

首页 >

文章列表页 >

Evaluation of Flow Stability and Uniformity in Double Elbow Pipe with Circular Cross Section

更新时间：2025-07-09

- Evaluation of Flow Stability and Uniformity in Double Elbow Pipe with Circular Cross Section
- Vol. 55, Issue 6, Pages: 102-112(2021)
- 作者机构：
  
  1. 西安交通大学叶轮机械研究所,西安,710049
  2. 西安交通大学陕西省叶轮机械及动力装备工程实验室,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb202106013
  CLC： TK313
- Online First：10 June 2021，
  
  Published：2021
- 稿件说明：
移动端阅览
Evaluation of Flow Stability and Uniformity in Double Elbow Pipe with Circular Cross Section[J]. 2021, 55(6): 102-112.
DOI：

Evaluation of Flow Stability and Uniformity in Double Elbow Pipe with Circular Cross Section[J]. 2021, 55(6): 102-112. DOI： 10.7652/xjtuxb202106013.

摘要

针对圆形截面双扭管的工业输水管道中存在流动稳定性和均匀性较差的问题

基于能量梯度理论

采用数值方法

着重研究了雷诺数在6×10

～1.2×10

范围时

0°、90°和180° 3种角度双扭管布置方式对圆形截面双扭管内部流动稳定性和均匀性的影响规律。结果表明:相同雷诺数条件下

下游直管段12D范围内

180°双扭管的速度均匀性最好

0°双扭管次之

90°双扭管最差

压力均匀性的变化则刚好相反; 90°双扭管在下游弯管处

流体所受合力在周向和径向存在较大分量

导致次流较强

其旋涡角在3种双扭管中最大; 在本文计算的下游45D处

90°双扭管的旋涡角仍在10°左右

因而要达到流量计安装要求

还需要更长的直管段; 在雷诺数6×10

～1.2×10

范围内

随着雷诺数增大

双扭管内部流动稳定性降低

压力均匀性降低

但是相对应的速度均匀性提升。

Abstract

For the poor flow stability and uniformity problem of double elbow pipes with circular cross section in industrial water pipeline

based on the energy gradient theory

a numerical simulation method is used to study the influencing rules of three different arrangement modes of the double elbow pipe at angles 0°

90° and 180° on the flow stability and uniformity when Reynolds number ranges from 6×10

to 1.2×10

. The results show that under the same Reynolds number condition

the velocity uniformity of 180° double elbow pipe is the best among the three arrangement schemes within 12D downstream length

followed by 0° double elbow pipe

and 90° double elbow pipe is the wors

while the results of the pressure uniformity are just the opposite. The resultant force at the downstream bend of 90° double elbow pipe has larger components in circumferential and radial directions

resulting in strong secondary flow

while its swirling angle is the largest among the three arrangements. At the downstream 45D location of double elbow pipe with 90°

the swirling angle is about 10°

so a longer straight distance is needed to meet the requirements of flowmeter installation. When the Reynolds number is in the range of 6×10

to 1.2×10

the stability of flow and the pressure uniformity decrease with the increase of Reynolds number

but the corresponding velocity uniformity increases.

关键词

Keywords

references

MATTINGLY G E, YEH T T. Summary report of NIST's industry-government consortium research program on flowmeter installation effects with emphasis on the research period [R/OL].(1994-09-01)[2020-10-01]. http:∥nvlpubs.nist.gov/nistpubs/Legacy/TN/nbstechnica/note1408.pdf.

苏宝焕, 吕薇, 齐国利, 等. 上游弯管对工业锅炉水流量测量准确性的影响 [J]. 哈尔滨理工大学学报, 2018, 23(6): 18-23.

SU Baohuan, LÜ Wei, QI Guoli, et al. Influence of upstream pip bends on the water flow measurement accuracy of industrial boiler [J]. Journal of Harbin University of Science and Technology, 2018, 23(6): 18-23.

SUDO K, SUMIDA M, HIBARA H. Experimental investigation on turbulent flow in a circular-sectioned 90-degree bend [J]. Experiments in Fluids, 1998, 25(1): 42-49.

ERDAL A. A numerical investigation of different parameters that affect the performance of a flow conditioner [J]. Flow Measurement Instrumentation, 1998, 8(2): 93-102.

张巧玲, 曹佳豪, 杨振东, 等. 基于Zanker型流动调整器的平面双弯头流场特性研究 [J]. 西安理工大学学报, 2018, 34(3): 78-83.

ZHANG Qiaoling, CAO Jiahao, YANG Zhendong, et al. Study of flow field characteristics of plane double elbow based on Zanker perforated flow regulator [J]. Journal of Xi'an University of Technology, 2018, 34(3): 78-83.

李涛, 李安桂. 通风管道90°弯管Z型组合局部阻力相邻影响系数的实验与数值模拟 [J]. 流体机械, 2006, 34(8): 9-14.

LI Tao, LI Angui. Numerical and experimental study of ratio of net closed coupled uncoupled of 90° ells in Z-shape [J]. Fluid Machinery, 2006, 34(8): 9-14.

LARIBI B, WAUTERS P, AICHOUNI M. Experimental study of aerodynamic behavior downstream of three flow conditioners [C]∥ASME 2002 Joint U. S. -European Fluids Engineering Division Conference. New York, USA: ASME, 2002: 115-119.

李彦梅, 徐英, 张立伟, 等. 上游双弯头对内锥流量计性能的影响 [J]. 仪器仪表学报, 2009, 30(11): 2417-2422.

LI Yanmei, XU Ying, ZHANG Liwei, et al. Effects of upstream double pipe elbows on the performance of cone flowmeter [J]. Chinese Journal of Scientific Instrument, 2009, 30(11): 2417-2422.

赵丹. 超声流量计探头伸缩位置及流量数值积分方法优化研究 [D]. 天津: 天津大学, 2012: 1-70.

刘琦, 霍思彤, 唐露瑶. DANIEL超声流量计在双弯头下游流场内的适应性研究 [J]. 油气田地面工程, 2018, 37(6): 59-61.

LIU Qi, HUO Sitong, TANG Luyao. Adaptability study on the DANIEL ultrasonic flowmeter in the double elbow down-stream flow field [J]. Oil-Gasfield Surface Engineering, 2018, 37(6): 59-61.

王瑞欣, 郭亚军, 屈鑫鑫, 等. 基于PIV技术流动调整器性能试验研究 [J]. 推进技术, 2019, 40(12): 2708-2714.

WANG Ruixin, GUO Yajun, QU Xinxin, et al. Experimental study on performance of flow conditioners based on PIV measurements technology [J]. Journal of Propulsion Technology, 2019, 40(12): 2708-2714.

LAWS E M. Flow conditioning: a new development [J]. Flow Measurement Instrumentation, 1990, 1(3): 165-170.

屈鑫鑫. 带流动调整器圆形截面管道内流场分布特性研究 [D]. 西安: 西安建筑科技大学, 2017: 32-44.

王慧锋, 李莉, 吴中相. 同平面双弯头条件下A+K流量计前直管段长度的实验研究 [J]. 华东理工大学学报(自然科学版), 2013, 39(4): 477-481.

WANG Huifeng, LI Li, WU Zhongxiang. Experimental research on straight pipe length of A+K flowmeter when double elbows on the same plane are installed in the upstream [J]. Journal of East China University of Science and Technology(Natural Science Edition), 2013, 39(4): 477-481.

陈利琼, 谢虹雅, 孙靖云, 等. 基于CFD的气体超声流量计计量准确性研究 [J]. 中国测试, 2019, 45(7): 87-91.

CHEN Liqiong, XIE Hongya, SUN Jingyun, et al. Research on the measurement accuracy of gas ultrasonic flowmeter based on CFD [J]. China Measurement and Testing Technology, 2019, 45(7): 87-91.

贺益英, 赵懿珺, 孙淑卿, 等. 输水管线中弯管局部阻力的相邻影响 [J]. 水利学报, 2004, 35(2): 17-20.

HE Yiying, ZHAO Yijun, SUN Shuqing, et al. Interaction of local loss between bends in pipe line [J]. Journal of Hydraulic Engineering, 2004, 35(2): 17-20.

贺益英, 赵懿珺, 孙淑卿, 等. 弯管局部阻力系数的试验研究 [J]. 水利学报, 2003, 34(11): 54-58.

HE Yiying, ZHAO Yijun, SUN Shuqing, et al. Experimental study on local loss coefficient of bend in pipeline [J]. Journal of Hydraulic Engineering, 2003, 34(11): 54-58.

赵懿珺, 贺益英. 直角Z形组合双弯管流动特性的研究 [J]. 水利学报, 2006, 37(7): 778-783.

ZHAO Yijun, HE Yiying. Experimental study on local loss coefficient of bend in pipeline [J]. Journal of Hydraulic Engineering, 2006, 37(7): 778-783.

DOU Huashu. Mechanism of flow instability and transition to turbulence [J]. International Journal of Non-Linear Mechanics, 2006, 41(4): 512-517.

DOU Huashu. Physics of flow instability and turbulent transition in shear flows [J]. Physics, 2006(6): 1411-1425.

DOU Huashu, KHOO B C, YEO K S. Instability of Taylor-Couette flow between concentric rotating cylinders [J]. International Journal of Thermal Science, 2008, 47: 1422-1435.

HUNT J, WRAY A, MOIN P. Eddies, stream, and convergence zones in turbulent flows: CTR-S88 [R]. Stanford, California, USA: Proceeding of the Summer Program. Stanford University. Center for Turbulent Research, 1988: 193-208.

WELTENS H, BRESSLER H, TERRES F, et al. Optimization of catalytic converter gas flow distribution by CFD prediction [J]. SAE Technical Paper, 1993: 930780.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

A Hybrid-Topology Overlay Network for Supporting Large-Scale Application-Level Multicast

Dynamics in the Evolution of Spherical Micro-Bubble in Water and Its Control

Effect of Control Delay on Dynamic Characteristics of Negative Stiffness Duffing System

Model for Cable-in-Conduit Conductor(CICC) Design Considering Strain Effect

Dynamic Backup Multipath Routing for Improving Route Stability in Mobile Ad Hoc Networks

Related Author

2 董巍 1

刘晓 1

郑庆华 1

姜山 1

屈云海 2

康伟 1

Related Institution

Ministry of Education Key Lab for Intelligent Networks and Network Security, Xi'an Jiaotong University

Department of Computer Science and Technology, Xi'an Jiaotong University

School of Energy and Power Engineering, Xi'an Jiaotong University

Institute of Mechatronics and Information System, Xi'an Jiaotong University

School of Information Science and Engineering, Henan University of Technology

⁰