Effects of Inlet Parameters on Spontaneous Condensation of Water Steam in a Laval No--le

doi:10.7652/xjtuxb202010014

您当前的位置：

首页 >

文章列表页 >

Effects of Inlet Parameters on Spontaneous Condensation of Water Steam in a Laval No--le

更新时间：2025-07-09

- Effects of Inlet Parameters on Spontaneous Condensation of Water Steam in a Laval No--le
- Vol. 54, Issue 10, Pages: 116-123(2020)
- 作者机构：
  
  1. 西安交通大学叶轮机械研究所,西安,710049
  2. 西安交通大学陕西省叶轮机械及动力装备工程实验室,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb202010014
  CLC： TK211
- Online First：10 October 2020，
  
  Published：2020
- 稿件说明：
移动端阅览
Effects of Inlet Parameters on Spontaneous Condensation of Water Steam in a Laval No--le[J]. 2020, 54(10): 116-123.
DOI：

Effects of Inlet Parameters on Spontaneous Condensation of Water Steam in a Laval No--le[J]. 2020, 54(10): 116-123. DOI： 10.7652/xjtuxb202010014.

摘要

针对不同进汽参数条件下水蒸气从过热区膨胀进入湿蒸汽区的自发凝结规律问题

采用数值模拟方法研究其流过拉伐尔喷管时在非平衡和平衡条件下的凝结特性

分析了进汽参数对水蒸气非平衡凝结过程的过冷度、液滴数、湿度、压比以及马赫数的影响

比较了其平衡凝结和非平衡凝结特性的差异。结果表明:当进汽压力较低时

水蒸气非平衡凝结过冷度较大

压力和马赫数的突跃现象显著; 随着进汽压力提高

非平衡凝结造成的参数突跃变化减小

出口湿度逐渐增大

当p/p

为0.8时

出口湿度超过了20%。通过比较水蒸气的平衡凝结和非平衡凝结特性

发现喷管进汽压力较低时

水蒸气非平衡凝结与平衡凝结计算结果的差异显著

Wilson点在平衡态中湿度达到8.40%; 而当进汽压力接近临界压力时

平衡凝结的计算结果基本接近非平衡凝结的结果

Wilson点在平衡态中的湿度仅为1.98%。

Abstract

In view of the spontaneous condensation laws of water steam expanding from the superheated -one into the wet steam -one under different inlet parameters

a numerical simulation method is adopted to study the condensation characteristics of water steam flowing through a Laval no--le under non-equilibrium and equilibrium conditions. Effects of inlet steam parameters on the supercooling

droplet number

humidity

pressure ratio and Mach number of the water vapor in the non-equilibrium condensation process are analy-ed. And then the differences between the equilibrium condensation characteristics and non-equilibrium condensation characteristics are contrasted. Results show that the supercooling of non-equilibrium condensation is greater

and the changes in pressure and Mach number are more significant when the inlet pressure is lower. With the increase of the inlet pressure

the changes in pressure and Mach number are reduced gradually

and the outlet humidity increases and exceeds 20% whe

关键词

Keywords

references

MOORE M J, SIEVERDING C H. Two-phase steam flow in turbines and separators [M]. New York, USA: Hemisphere Publishing Corporation, 1976: 75-80.

周涛, 张明, 张蕾, 等. 中国核电汽轮机的参数及其发展趋势研究 [J]. 中国电业(技术版), 2012(2): 43-47.

ZHOU Tao, ZHANG Ming, ZHANG Lei, et al. Study on the nuclear turbine parameters and development tendency [J]. China Electric Power(Technology Edition), 2012(2): 43-47.

BAKHTAR F, TOCHAI M T M. An investigation of two-dimensional flows of nucleating and wet steam by the time-marching method [J]. International Journal of Heat and Fluid Flow, 1980, 2(1): 5-18.

GYARMATHY G, BURKHARD H P, LESCH F, et al. Spontaneous condensation of steam at high pressure: first experiment result [C]∥Proceedings of IMechE Conference on Heat and Fluid in Steam and Gas Turbine Plant. London, UK: IMechE, 1973: 182-186.

苏民德, 俞接成, 卫德强. Laval喷管内湿蒸汽凝结流动的三维数值模拟 [J]. 热能动力工程, 2015, 30(3): 401-406, 493-494.

SU Minde, YU Jiecheng, WEI Deqiang. Three-dimensional numerical simulation of wet steam condensation flow inside a Laval nozzle [J]. Journal of Engineering for Thermal Energy and Power, 2015, 30(3): 401-406, 493-494.

杨建道, 游玮, 李亮, 等. 核电汽轮机低压缸中平衡和非平衡凝结流动的对比研究 [J]. 热力透平, 2013, 42(1): 9-14.

YANG Jiandao, YOU Wei, LI Liang, et al. Comparative research on equilibrium and non-equilibrium condensation flow in low pressure cylinder of nuclear turbines [J]. Thermal Turbine, 2013, 42(1): 9-14.

余兴刚, 谢诞梅, 王纯, 等. 汽轮机叶片表面粗糙度对自发凝结级性能影响的数值研究 [J]. 中国电机工程学报, 2015, 35(21): 5533-5541.

YU Xinggang, XIE Danmei, WANG Chun, et al. Numerical investigation of the effect of blade roughness on the performance of steam turbine nucleating stage [J]. Proceedings of the CSEE, 2015, 35(21): 5533-5541.

王纯, 谢诞梅, 李曦滨, 等. 1 000 MW机组汽轮机末级叶片除湿缝结构设计与优化 [J]. 热力发电, 2015, 44(8): 43-48.

WANG Chun, XIE Danmei, LI Xibin, et al. Optimization design of dehumidification structure of the last stage blade in a steam turbine [J]. Thermal Power Generation, 2015, 44(8): 43-48.

孙皖, 马斌, 牛璐, 等. 低温透平膨胀机内平衡凝结两相流动的数值模拟 [J]. 西安交通大学学报, 2013, 47(7): 36-39.

SUN Wan, MA Bin, NIU Lu, et al. Numerical simulation of equilibrium condensation two-phase flow in cryogenic turboexpander [J]. Journal of Xi'an Jiaotong University, 2013, 47(7): 36-39.

孙皖, 牛璐, 步珊珊, 等. 低温透平膨胀机内非平衡自发凝结两相流动的数值研究 [J]. 西安交通大学学报, 2018, 52(2): 125-129, 135.

SUN Wan, NIU Lu, BU Shanshan, et al. Numerical simulation of non-equilibrium condensation two-phase flow in cryogenic turboexpander [J]. Journal of Xi'an Jiaotong University, 2018, 52(2): 125-129, 135.

李瑜, 李亮, 钟刚云, 等. 末级透平对低压缸气动和凝结特性的影响 [J]. 西安交通大学学报, 2012, 46(7): 16-20, 86.

LI Yu, LI Liang, ZHONG Gangyun, et al. Influence of last stage turbine on aerodynamic performance and condensation characteristic of low pressure cylinder [J]. Journal of Xi'an Jiaotong University, 2012, 46(7): 16-20, 86.

李彬, 杨自春, 曹跃云, 等. 进汽参数对汽轮机叶栅通道内自发凝结影响的数值分析 [J]. 工程热物理学报, 2019, 40(11): 2502-2509.

LI Bin, YANG Zichun, CAO Yueyun, et al. Numerical investigation of the effect of the inlet steam parameters on the spontaneous condensation performance of steam turbine cascade [J]. Journal of Engineering Thermophysics, 2019, 40(11): 2502-2509.

孙皖, 牛璐, 赖天伟, 等. 氮气在缩放喷管中非平衡自发凝结的数值研究 [J]. 西安交通大学学报, 2015, 49(4): 130-133, 148.

SUN Wan, NIU Lu, LAI Tianwei, et al. Numerical research on nitrogen spontaneous condensation in converging-diverging nozzle [J]. Journal of Xi'an Jiaotong University, 2015, 49(4): 130-133, 148.

DENG Qinghua, JIANG Yu, HU Zhifeng, et al. Condensation and expansion characteristics of water steam and carbon dioxide in a Laval nozzle [J]. Energy, 2019, 175: 694-703.

FURUSAWA T, MIYAZAWA H, MORIGUCHI S, et al. Numerical method for simulating high pressure CO2 flows with nonequilibrium condensation [C]∥Proceedings of ASME Conference on ASME Turbo Expo 2018. New York, USA: ASME, 2018: 75592.

SNOECK J. Calculation of mixed flows with condensation in one dimensional nozzles [C]∥Aero-Thermodynamics of Steam Turbines. New York, USA: ASME, 1981: 11-18.

GUHA A, YOUNG J B. The effect of flow unsteadiness on the homogeneous nucleation of water droplets in steam turbines [J]. Philosophical Transactions of the Royal Society A, 1994, 349(1691): 445-472.

MOSES C A, STEIN G D. On the growth of steam droplets formed in a Laval nozzle using both static and light scattering measurements [J]. Journal of Fluids Engineering, 1971, 100(3): 1-25.

李亮, 李国君, 丰镇平. 湿蒸汽两相流动的数值方法及其在喷管中的应用 [J]. 西安交通大学学报, 2001, 35(11): 1131-1138.

LI Liang, LI Gguojun, FENG Zhenping. Numerical method for wet steam two-phase flows and its application in 2D nozzle [J]. Journal of Xi'an Jiaotong University, 2001, 35(11): 1131-1138.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Numerical Simulation of Equilibrium Condensation Two-Phase Flow in Cryogenic Turboexpander

Electrothermal Coupling Research on the Evolutionary Law of Anti-Corona Performance for High-Altitude Air-Cooled Generators

Numerical Simulation of the Energy Conversion Process in Thermoacoustic Engines with Different Stack Materials

Influence of Structural Parameters on the Summer Operational Characteristics of a Three-Tower-in-One Indirect Air-Cooling System

Sensitivity Analysis of Foil Geometrical Parameters for the Third-Generation CO2 Gas Foil Bearings Based on Design of Experiments Method

Related Author

孙皖 1

马斌 1

牛璐 1

侯予 1

Related Institution

School of Energy and Power Engineering, Xi'an Jiaotong University

⁰