A Low Speed Piston Pump Directly Driven by Tidal Current Energy for Reverse Osmosis Desalination

doi:10.7652/xjtuxb202004004

您当前的位置：

首页 >

文章列表页 >

A Low Speed Piston Pump Directly Driven by Tidal Current Energy for Reverse Osmosis Desalination

更新时间：2025-07-09

- A Low Speed Piston Pump Directly Driven by Tidal Current Energy for Reverse Osmosis Desalination
- Vol. 54, Issue 4, Pages: 27-34(2020)
- 作者机构：
  
  1. 中国海洋大学工程学院,山东,青岛,266100
  2. 哈尔滨工程大学水下机器人技术国防重点实验室,哈尔滨,150001
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb202004004
  CLC： TH137
- Online First：10 April 2020，
  
  Published：2020
- 稿件说明：
移动端阅览
A Low Speed Piston Pump Directly Driven by Tidal Current Energy for Reverse Osmosis Desalination[J]. 2020, 54(4): 27-34.
DOI：

A Low Speed Piston Pump Directly Driven by Tidal Current Energy for Reverse Osmosis Desalination[J]. 2020, 54(4): 27-34. DOI： 10.7652/xjtuxb202004004.

摘要

针对潮流能直驱式反渗透海水淡化系统中

海水液压泵与水轮机转速不配比问题

提出了一种低转速、高容积效率的动外壳式多作用径向柱塞泵方案。该泵由动外壳、缸体、配流阀、柱塞组件、液体弹簧、管道轴和调压装置等组成。工作时

潮流能水轮机直接驱动外壳

多排错位轴对称的柱塞组件在液体弹簧的作用下紧贴外壳内壁

沿内壁多作用曲线相对缸体孔做往复运动

通过配流阀完成吸压海水。该泵利用单转多次作用方式

增加柱塞运动频率与速度

补偿低转速下因高压差产生的泄漏; 利用动外壳式代替动缸体式或动斜盘式

将泵直接置于水轮机内

简化了系统结构; 采用分组轴对称布置柱塞

消除了径向不平衡力; 采用液体弹簧复位

使得复位迅速

安全可靠。仿真结果表明:该泵排量为202.9 mL/r

额定转速为50 r/min

额定压力为8 MPa; 在额定工况下

当柱塞副单边间隙为10 μm时

输出流量约为9.8 L/min

容积效率为96.6%

流量脉动为1.92%; 配流阀启闭动作协调

单阀最大配流量为2.0 L/min; 在保证容积效率下

额定转速降低至已有水液压轴向柱塞泵产品的5%左右。该柱塞泵可应用于以潮流能直驱的反渗透海水淡化系统、发电系统等核心能量转换设备。

Abstract

A multiple-action radial piston pump scheme with a revolving outer ring featuring low speed and high volumetric efficiency is proposed to solve the problem of rotating speeds mismatch between the seawater hydraulic pump and the hydro-turbine in the reverse osmosis desalination system driven by tidal current energy. The pump is composed of a moving shell

a cylinder

a distributing valve

a plunger component

a liquid spring

a pipeline shaft

and a pressure regulator

etc. When the pump is working

the tidal current energy hydro-turbine drives the shell directly and the multi-row misaligned axisymmetric plunger component is closely attached to the inner wall of the shell under the action of the liquid spring

moves reciprocally along the multi-action curve of the inner wall relative to the cylinder hole

and completes seawater suction and compression through the distribution valve. The pump reali-es multiple actions within single rotation to raise the frequency and velocity of the pist

关键词

Keywords

references

王玉杰, 马俊涛. 关于海水淡化浓海水综合利用的研究 [J]. 盐科学与化工, 2019, 48(11): 9-10, 13.

WANG Yujie, MA Juntao. Study on comprehensive utilization of seawater desalination concentrated seawater [J]. Journal of Salt Science and Chemical Industry, 2019, 48(11): 9-10, 13.

KAVITHA J, RAJALAKSHMI M, PHANI A R, et al. Pretreatment processes for seawater reverse osmosis desalination systems: a review [J]. Journal of Water Process Engineering, 2019, 32: 100926.

IMBROGNO J, KEATING J J, KILDUFF J, et al. Critical aspects of RO desalination: a combination strategy [J]. Desalination, 2017, 401: 1-20.

ABDULLAH H A, LUCA F, NOREDDINE G, et al. Advanced coagulation using in-situ generated liquid ferrate, Fe(VI), for enhanced pretreatment in seawater RO desalination during algal blooms [J]. Science of the Total Environment, 2019, 685: 1193-1200.

SHAHABI S S, AZIZI N, VATANPOUR V, et al. Novel functionalized graphitic carbon nitride incorporated thin film nanocomposite membranes for high-performance reverse osmosis desalination [J]. Separation and Purification Technology, 2019, 235: 116134.

CALISE F, CAPPIELLO F L, VANOLI R, et al. Economic assessment of renewable energy systems integrating photovoltaic panels, seawater desalination and water storage [J]. Applied Energy, 2019, 253: 113575.

郑建波. 反渗透海水淡化高压给水系统运行优化研究 [D]. 江苏镇江: 江苏大学, 2017: 6-10.

邵天宝, 李露, 卜建伟, 等. 反渗透海水淡化高压系统设计及设备选型要点 [J]. 净水技术, 2019, 38(9): 131-134.

SHAO Tianbao, LI Lu, BU Jianwei, et al. Design and equipment selection of reverse osmosis desalination high pressure system [J]. Water Purification Technology, 2019, 38(9): 131-134.

MOOG. RKP pumps [EB/OL]. [2019-09-19]. https:∥www.moog.com/content/dam/moog/literature/ICD /Moog-Pu mps-RKP-Catalog-en.pdf.

GIANT. P/MP pumps [EB/OL]. [2019-09-19]. http:∥www.giantpumps.com/pump_categories/corrosion_resistant.

HAWE. RRG pumps [EB/OL]. [2019-09-19]. https:∥www.hawe.com/de-de/produkte/produktsuc he-nach-geraetearten/hydraulikpumpe/radialkolbenpu mpe/r/.

BEINLICH. TR/TRG pumps [EB/OL]. [2019-09-19].https:∥www. beinlich-pumps.com/en/radial-piston-pumps.html.

POCLAIN. HYDRAULICS pumps PL [EB/OL]. [2019-09-19]. https:∥www.poclain-hydraulics.com /zh/products/pumps.

LI Z Y, LIU Y S, HE X F, et al. The research development of water hydraulics at Huazhong university of science and technology [EB/OL]. [2019-09-19]. https:∥www.paper.edu.cn/releasepaper/content/2004-05-97.

刘银水, 吴德发, 李东林, 等. 海水液压技术在深海装备中的应用 [J]. 机械工程学报, 2014, 50(2): 28-35.

LIU Yinshui, WU Defa, LI Donglin, et al. Applications of seawater hydraulics in deep-sea equipment [J]. Journal of Mechanical Engineering, 2014, 50(2): 28-35.

ZHOU H, ZHAI J. Simulation and experiment study on the driving torque of the axial piston pump for seawater desalination [J]. Advanced Science Letters, 2012, 12(1): 78-83.

YIN F, NIE S, XIAO S, et al. Numerical and experimental study of cavitation performance in sea water hydraulic axial piston pump [J]. Proceedings of the Institution of Mechanical Engineers: Part I Journal of Systems and Control Engineering, 2016, 230(8): 716-735.

程帅兵, 陈兵, 张欢. 导流涵道对垂直轴水轮机性能影响的研究 [J]. 可再生能源, 2016, 34(11): 1706-1713.

CHENG Shuaibing, CHEN Bing, ZHANG Huan. Influence of duct on the performance of the vertical axis tidal turbine [J]. Renewable Energy Resources, 2016, 34(11): 1706-1713.

张鑫杰, 谌炎辉, 周知进. 轴向柱塞泵参数对其流量和压力脉动的影响 [J]. 机床与液压, 2018, 46(13): 125-129, 120.

ZHANG Xinjie, CHEN Yanhui, ZHOU Zhijin. Influence of axial piston pump parameters to flow and pressure pulsation [J]. Machine Tool Hydraulics, 2018, 46(13): 125-129, 120.

温诗铸. 摩擦学原理 [M]. 5版. 北京: 清华大学出版社, 2019: 134-144.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Diffusion Characteristics and Influencing Factors in Case of Hydrogen Leakage from Fuel Cell Vehicles Running in Tunnels

I/O Performance Modeling and Prediction Method for Large-Scale Parallel Applications Using Machine Learning

Mechanism and Optimal Control Strategy for Hysteresis in Rapid Dehumidification Response of Indirect Thermal Systems in Electric Vehicles

A Fast Calculation Method for Thermal Flow Fields in Transformer Windings Based on PI-DeepONet

Integrated and Joint Design Optimization of Centrifugal Compressor Impeller and Casing Treatment at Multiple Working Points

Related Author

No data

Related Institution

No data

⁰