Study on the Low-Temperature Air Loop Simulation System Based on Liquid Nitrogen Spray Technology

doi:10.7652/xjtuxb201905015

您当前的位置：

首页 >

文章列表页 >

Study on the Low-Temperature Air Loop Simulation System Based on Liquid Nitrogen Spray Technology

更新时间：2025-07-09

- Study on the Low-Temperature Air Loop Simulation System Based on Liquid Nitrogen Spray Technology
- Vol. 53, Issue 5, Pages: 109-114(2019)
- 作者机构：
  
  河南理工大学机械与动力工程学院,河南,焦作,454000
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb201905015
  CLC： TB69
- Online First：10 May 2019，
  
  Published：2019
- 稿件说明：
移动端阅览
Study on the Low-Temperature Air Loop Simulation System Based on Liquid Nitrogen Spray Technology[J]. 2019, 53(5): 109-114.
DOI：

Study on the Low-Temperature Air Loop Simulation System Based on Liquid Nitrogen Spray Technology[J]. 2019, 53(5): 109-114. DOI： 10.7652/xjtuxb201905015.

摘要

为进行座舱盖高空低温环境飞行疲劳试验考核

设计并搭建了采用液氮喷雾技术的小型环路结构低温环境模拟测试试验台

开展了风速以及喷射流量对系统降温速率影响的特性研究。试验测试了在液氮喷雾流量为37.2、42.4和49.3 kg/h

系统风速为2.21、4.53和6.77 m/s时

工作段温度从21 ℃降至-30 ℃时各测试面的降温特性

验证了运用液氮喷雾技术快速降温的可行性。结果表明:在相同喷雾流量下

风速越大

环路的降温速率越慢

测试面的温度均匀性越好; 在相同风速下

喷雾流量越大

降温速率越快

测试面的温度均匀性越差。液氮喷雾降温能够满足座舱盖疲劳测试的低温环境要求

工作段温度场均匀性良好。本文研究可为低温环境模拟系统和大空间液氮喷雾冷却系统的设计提供参考。

Abstract

To examine the canopy fatigue during low-temperature flights

a small air loop canopy fatigue test-rig using liquid nitrogen spray cooling technology was designed and developed to investigate the effects of air speed and spray flow rate on the cooling rate of the system. In the experiment

as the liquid nitrogen spray flow rates were 37.2

42.4 and 49.3 kg/h and the air speeds were 2.21

4.53 and 6.77 m/s

the cooling performance of each test section was tested when the system temperature decreased from 21 ℃ to -30 ℃. The results show that the high flow rate enables the cooling rate to slow down and enhances the temperature uniformity under the same injection pressure and mass flow rate. As the flow rate is constant

with the cooling rate increasing

the temperature non-uniformity of each test face is obvious when the mass flow rate increases. The liquid nitrogen system can provide a low-temperature environment and a uniformed temperature field for simulation of canopy fatigue test. The present work could be a guidance for the design of low-temperature environment simulation and large-space liquid nitrogen cooling systems.

关键词

Keywords

references

刘珊. 座舱盖高低温疲劳试验台换热数值模拟及热经济分析 [D]. 西安: 西北工业大学, 2001: 2-3.

马广顺, 马振库, 赵云峰. 大型低温环境试验室制冷系统设计 [J]. 装备环境工程, 2013(2): 96-98.

MA Guangshun, MA Zhenku, ZHAO Yunfeng. Design of refrigeration system for large environmental test chamber [J]. Equipment Environmental Engineering, 2013(2): 96-98.

王珊珊, 黄永华, 张良俊, 等. 氦气氛高低温环境模拟系统及初调实验 [J]. 低温工程, 2012(5): 28-33.

WANG Shanshan, HUANG Yonghua, ZHANG Liangjun, et al. Design and preliminary experimental study on a high and low temperature system with helium gas in chamber [J]. Cryogenics, 2012(5): 28-33.

李兆坚. 某大型低温环境室制冷系统设计 [J]. 暖通空调, 2009, 39(2): 119-121.

LI Zhaojian. Refrigeration system design of a large-scale low temperature climatic chamber [J]. Journal of HV AC, 2009, 39(2): 119-121.

李峰, 张开平. 基于PLC的低温环境试验室控制系统 [J]. 自动化仪表, 2006, 27(9): 54-56.

LI Feng, ZHANG Kaiping. PLC based control system for cryogenic environmental test [J]. Process Automation Instrumentation, 2006, 27(9): 54-56.

赵雁纪. 空气制冷与蒸气压缩制冷在气候环境模拟试验中应用的经济性分析 [J]. 低温工程, 2000(3): 42-47.

ZHAO Yanji. Economic benefits of the air cycle refrigeration and the vapor compression refrigeration in the climatic environmental simulation test [J]. Cryogenics, 2000(3): 42-47.

黄龙, 蒋彦龙, 王瑜, 等. 以乙醇溶液为冷却工质的开式喷雾冷却系统实验研究 [J]. 低温工程, 2017(3): 28-33.

HUANG Long, JIANG Yanlong, WANG Yu, et al. Experiment study on spray cooling of an open system with ethanol as coolant [J]. Cryogenics, 2017(3): 28-33.

ASHWOOD A C. Fluid property effects on spray cooling: an experimental and numerical study [D]. Madison, Wisconsin, USA: University of Wisconsin-Madison, 2006: 5-9.

MONTAZERI H, BLOCKEN B, HENSEN J L M. CFD analysis of the impact of physical parameters on evaporative cooling by a mist spray system [J]. Applied Thermal Engineering, 2015, 75: 608-622.

MONTAZERI H, BLOCKEN B, HENSEN J L M. Evaporative cooling by water spray systems: CFD simulation, experimental validation and sensitivity analysis [J]. Building Environment, 2015, 83: 129-141.

SADAFIMH, JAHN I, HOOMAN K. Cooling performance of solid containing water for spray assisted dry cooling towers [J]. Energy Conversion Management, 2015, 91: 158-167.

SADAFI M H, GONZÁLEZ R S, VETRANOM R, et al. An investigation on spray cooling using saline water with experimental verification [J]. Energy Conversion Management, 2016, 108: 336-347.

ALKHEDHAIR A, GURGENCI H, JAHN I, et al. Numerical simulation of water spray for pre-cooling of inlet air in natural draft dry cooling towers [J]. Applied Thermal Engineering, 2013, 61(2): 416-424.

屠欣丞. 细水雾大空间局域环境调节的研究 [D]. 江苏镇江: 江苏大学, 2009: 24-64.

BARROW H, POPEC W. Droplet evaporation with reference to the effectiveness of water-mist cooling [J]. Applied Energy, 2007, 84(4): 404-412.

王小芝. 崇明隧道运营累积温升及喷雾降温可行性研究 [D]. 上海: 同济大学, 2007: 36-71.

YANG X J, HAN Q Y, PANG J W, et al. Progress of heat-hazard treatment in deep mines [J]. International Journal of Mining Science and Technology, 2011, 21(2): 295-299.

KATSOULAS N, BAILLE A, KITTAS C. Effect of misting on transpiration and conductances of a greenhouse rose canopy [J]. Agricultural Forest Meteorology, 2001, 106(3): 233-247.

HUANG C, YE D, ZHAO H, et al. The research and application of spray cooling technology in Shanghai Expo [J]. Applied Thermal Engineering, 2011, 31(17/18): 3726-3735.

赖欢, 陈振华, 高荣, 等. 大型高速低温风洞冷量回收的方法研究 [J]. 西安交通大学学报, 2016, 50(6): 136-142.

LAI Huan, CHEN Zhenhua, GAO Rong, et al. Cold energy recycle from cryogenic wind tunnel exhaust system [J]. Journal of Xi'an Jiaotong University, 2016, 50(6): 136-142.

阮一逍, 薛绒, 赖欢, 等. 单液氮液滴在气流中的蒸发运动特性研究 [J]. 西安交通大学学报, 2017, 51(6): 147-152.

RUAN Yixiao, XUE Rong, LAI Huan, et al. Evaporation and movement characteristics of singer liquid nitrogen droplet in high-speed gas flow [J]. Journal of Xi'an Jiaotong University, 2017, 51(6): 147-152.

RUAN Y, CHEN L, LIU X, et al. Numerical study of evaporation and motion characteristics of liquid nitrogen droplet in high-speed gas flow [J]. IOP Conference Series: Materials Science and Engineering, 2017, 278(1): 012130.

FEY U, EGAMI Y, IIJIMA Y, et al. Transition detection by temperature sensitive paint at cryogenic temperatures in the European Transonic Wind Tunnel(ETW)[C]∥International Congress on Instrumentation in Aerospace Simulation Facilities. Piscataway, NJ, USA: IEEE, 2003: 77-88.

廖达雄, 刘晓波. 低温风洞新形式——换热引射式低温风洞 [J]. 实验流体力学, 2009(3): 108-112.

LIAO Daxiong, LIU Xiaobo. A new type of cryogenic tunnel-injection cryogenic tunnel with heat exchanger [J]. Journal of Experiments in Fluid Mechanics, 2009(3): 108-112.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Cold Energy Recycle from Cryogenic Wind Tunnel Exhaust System

Simulation of Breakup Characteristics of Liquid Nitrogen Droplets in Cryogenic Wind Tunnel

Electrothermal Coupling Research on the Evolutionary Law of Anti-Corona Performance for High-Altitude Air-Cooled Generators

Turbulent Kinetic Energy Dissipation Mechanism of Supercritical Carbon Dioxide Leakage Flow in a Scallop Bionic Seal Cavity

Effects of Steam Addition on the Swirl Combustion and Emission Characteristics of Cracked Ammonia

Related Author

赖欢 1

陈振华 2

高荣 2

陈万华 2

刘秀芳 1

侯予 1

MIAO Qingshuo

Related Institution

School of Energy and Power Engineering, Xi'an Jiaotong University

Facility Design and Instrumentation Institute, China Aerodynamics Research and Development Center

⁰