Study on the Effects of Concave Volute Tongues on Aerodynamic Performance and Noise of a Multi-Blade Centrifugal Fan

doi:10.7652/xjtuxb201712019

您当前的位置：

首页 >

文章列表页 >

Study on the Effects of Concave Volute Tongues on Aerodynamic Performance and Noise of a Multi-Blade Centrifugal Fan

更新时间：2025-07-09

- Study on the Effects of Concave Volute Tongues on Aerodynamic Performance and Noise of a Multi-Blade Centrifugal Fan
- Vol. 51, Issue 12, Pages: 128-135(2017)
- 作者机构：
  
  西安交通大学能源与动力工程学院,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb201712019
  CLC： TB17
- Online First：10 December 2017，
  
  Published：2017
- 稿件说明：
移动端阅览
Study on the Effects of Concave Volute Tongues on Aerodynamic Performance and Noise of a Multi-Blade Centrifugal Fan[J]. 2017, 51(12): 128-135.
DOI：

Study on the Effects of Concave Volute Tongues on Aerodynamic Performance and Noise of a Multi-Blade Centrifugal Fan[J]. 2017, 51(12): 128-135. DOI： 10.7652/xjtuxb201712019.

摘要

针对吸油烟机用多翼离心风机设计了内凹弧形、内凹槽形2种内凹式蜗舌

采用实验测量和数值模拟方法研究了内凹式蜗舌对多翼离心风机气动性能和噪声的影响。与传统的原型蜗舌相比

采用内凹式蜗舌在风机出口压力和运行效率基本保持不变的情况下

叶轮出口气流对蜗舌的冲击强度减小

蜗舌处流场的逆压梯度降低

使得风机气动噪声下降。实验结果表明:与原风机相比

带有内凹弧形蜗舌和内凹槽形蜗舌的多翼离心风机的噪声分别下降了1.4 dB和1.7 dB; 同时

由于内凹式蜗舌能够抑制流动分离

使风机出口处的有效流通面积增大

蜗舌附近区域的旋涡强度及其影响区域减小

从而增加了多翼离心风机的流量。

Abstract

Two types of volute tongue are designed for a multi-blade centrifugal fan used in range hoods. One is an inner concave arc volute tongue and the other is an inner concave grooved volute tongue. The effects of the inner concave volute tongues on both the aerodynamic performance and the noise of the multi-blade centrifugal fan are studied by using the measurement and numerical simulation methods. Compared with the traditional tongue

the impact of the air flow discharged by the impeller on the surface of the volute tongue is weakened and the inverse pressure gradient of the flow field near the volute tongue is reduced when the inner concave arc and the inner concave grooved volute tongues are used. Under the condition that the total pressure and operating efficiency of the multi-blade centrifugal fan keep constant

the aerodynamic noise is reduced. Experimental results show that the sound pressure level of the multi-blade centrifugal fans with the inner concave arc volute tongue and the inner concave grooved volute tongue goes down by 1.4 dB and 1.7 dB

respectively. At the same time

the effective flow area at the fan outlet increases because the flow separation occurred near the volute tongue is suppressed. The vortex intensity and the corresponding influence area are reduced. These results show that the flow rate of the multi-blade centrifugal fan with the concave volute tongues effectively increases.

关键词

Keywords

references

赵婷, 赵忖, 任刚, 等. 倾斜蜗舌对离心风机降噪影响的试验研究 [J]. 流体机械, 2012, 40(3): 1-7.

ZHAO Ting, ZHAO Cun, REN Gang, et al. Experimental study on the effect of inclined volute tongue on the noise reduction of centrifugal fan [J]. Fluid Machinery, 2012, 40(3): 1-7.

ZHOU S, WANG J. Prediction and reduction of aerodynamic noise of the multiblade centrifugal fan [J]. Advances in Mechanical Engineering, 2014, 2014: 1-10.

孙少明, 任露泉, 梅涛, 等. 仿生降噪蜗舌试验研究与数值模拟分析 [J]. 振动与冲击, 2009, 28(5): 32-34.

SUN Shaoming, REN Luquan, MEI Tao, et al. Practice and simulation analysis for reducing the centrifugal fan noise with bionics volute tongue [J]. Journal of Vibration and Shock, 2009, 28(5): 32-34.

毛义军, 祁大同, 刘秋洪. 基于非定常流场的离心风机气动噪声分析 [J]. 西安交通大学学报, 2005, 39(9): 989-993.

MAO Yijun, QI Datong, LIU Qiuhong. Analysis of the aeroacoustics in centrifugal fan based on numerical simulation of unsteady viscous flow [J]. Journal of Xi'an Jiaotong University, 2005, 39(9): 989-993.

LI Du, YANG Ce, ZHOU Mi, et al. Simulation of volute tongue of small-size centrifugal compressor [J]. Journal of Beijing Institute of Technology, 2011, 20(4): 496-501.

张师帅, 罗亮, 秦松江. 蜗舌间隙对空调用贯流风机性能及噪声的影响 [J]. 制冷与空调, 2008, 22(2): 6-9.

ZHANG Shishuai, LUO Liang, QIN Songjiang. Influence of volute throat gap on the performance and aeroacoustic noise of cross-flow fan used by air-conditioning [J]. Refrigeration Air Conditioning, 2008, 22(2): 6-9.

门艳忠, 卢铁光, 蒋恩臣. 4ZTL-1800联收机风机倾斜蜗舌降噪的试验与分析 [J]. 东北农业大学学报, 2005, 36(1): 91-94.

MEN Yanzhong, LU Tieguang, JIANG Enchen. Experiment and analysis on reducing noise of the 4ZTL-1800 combine gain machine fan incline tongue [J]. Journal of Northeast Agricultural University, 2005, 36(1): 91-94.

YOUNSI M, BAKIR F, KOUIDRI S, et al. Numerical and experimental study of unsteady flow in a centrifugal fan [J]. Proceedings of the Institution of Mechanical Engineers: Part A Journal of Power and Energy, 2007, 221(7): 1025-1036.

付双成, 刘雪东, 邹鑫, 等. 倾斜蜗舌对多翼离心风机流场及噪声的影响 [J]. 噪声与振动控制, 2013, 33(3): 87-89.

FU Shuangcheng, LIU Xuedong, ZOU Xin, et al. Numerical simulation of the influence of inclined volute tongue on flow field and noise of multi-blade centrifugal fans [J]. Noise and Vibration Control, 2013, 33(3): 87-89.

李栋, 顾建明. 阶梯蜗舌蜗壳降噪的分析和实现 [J]. 风机技术, 2005(3): 3-5.

LI Dong, GU Jianming. Analysis and realization of step-volute tongue scroll denoising [J]. Compressor, Blower Fan Technology, 2005(3): 3-5.

宫武旗, 吕伟领, 席光, 等. 前向多翼式离心风机蜗舌附近流场的PIV试验研究 [J]. 机械工程学报, 2005, 41(1): 166-171.

GONG Wuqi, LV Weiling, XI Guang, et al. Experiment study on the velocity field near the tongue of a forward curved multi-blades centrifugal fan [J]. Chinese Journal of Mechanical Engineering, 2005, 41(1): 166-171.

刘小民, 李烁. 仿鸮翼前缘蜗舌对多翼离心风机气动性能和噪声的影响 [J]. 西安交通大学学报, 2015, 49(1): 14-20.

LIU Xiaomin, LI Shuo. Effects of bionic volute tongue bioinspired by leading edge of owl wing on aerodynamic performance and noise of multi-blade centrifugal fan [J]. Journal of Xi'an Jiaotong University, 2015, 49(1): 14-20.

VELARDE-SUAREZ S, BALLESTEROS-TAJADURA R, SANTOLARIA-MORROS C, et al. Reduction of the aerodynamic tonal noise of a forward-curved centrifugal fan by modification of the volute tongue geometry [J]. Applied Acoustics, 2008, 69(3): 225-232.

刘小民, 赵嘉, 李典. 多翼离心风机性能的数值计算和实验测量 [J]. 风机技术, 2015(3): 11-17.

LIU Xiaomin, ZHAO Jia, LI Dian. Numerical simulation and experimental measurement of aerodynamic performance for a multi-blade centrifugal fan [J]. Compressor, Blower Fan Technology, 2015(3): 11-17.

FFOWCS WILLIAMS J E F, HAWKINGS D L. Sound generation by turbulence and surfaces in arbitrary motion [J]. Philosophical Transactions of the Royal Society of London: Series A Mathematical and Physical Sciences, 1969, 264(1151): 321-342.

MOON Y J, YONG C, NAM H S. Computation of unsteady viscous flow and aeroacoustic noise of cross flow fans [J]. Computers Fluids, 2003, 32(32): 995-1015.

LIU Q, QI D, MAO Y. Numerical calculation of centrifugal fan noise [J]. Proceedings of the Institution of Mechanical Engineers: Part C Journal of Mechanical Engineering Science, 2006, 220(8): 1167-1177.

韩忠华, 宋文萍, 乔志德. 基于FW-H方程的旋翼气动声学计算研究 [J]. 航空学报, 2003, 24(5): 400-404.

HAN Zhonghua, SONG Wenping, QIAO Zhide. Aeroacoustic calculation for helicopter rotor in hover and in forward flight based on FW-H equation [J]. Acta Aeronautica et Astronautica Sinica, 2003, 24(5): 400-404.

赵燕杰,谭俊飞,党飞龙,等.离心风机集流器的响应面优化设计.2015,49(11):49-54.[doi:10.7652/xjtuxb201511009]

刘小民,赵嘉,李典.单圆弧等厚叶片前后缘多元耦合仿生设计及降噪机理研究.2015,49(3):1-10.[doi:10.7652/xjtuxb 201503001]

刘小民,李烁.仿鸮翼前缘蜗舌对多翼离心风机气动性能和噪声的影响.2015,49(1):14-20.[doi:10.7652/xjtuxb201501 003]

温选锋,杨昕,祁大同,等.椭圆形进口集流器对多翼离心风机性能影响的实验研究.2011,45(11):45-51.[doi:10.7652/xjtuxb201111009]

周正,卢傅安,祁大同,等.一种离心风机蜗壳减振降噪的数值优化方法.2011,45(9):59-64.[doi:10.7652/xjtuxb201109 011]

顾媛媛,袁民建,毛义军,等.离心风机吸声蜗壳结构的数学物理模型及实验验证.2011,45(1):83-88.[doi:10.7652/xjtuxb201101017]

蔡建程,祁大同,卢傅安.离心风机基频气动偶极子噪声的数值研究.2009,43(11):66-70.[doi:10.7652/xjtuxb200911 014]

李景银,牛子宁,梁亚勋.可控减速法设计离心风机两元叶片的研究.2009,43(9):67-70.[doi:10.7652/xjtuxb200909015]

蔡建程,祁大同,唐囡.离心风机蜗壳振动声辐射的定量预测.2009,43(9):71-74.[doi:10.7652/xjtuxb200909016]

毛义军,祁大同,刘晓良.蜗壳散射对离心风机气动噪声传播的影响.2009,43(5):51-55.[doi:10.7652/xjtuxb200905011]

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Effects of Bionic Volute Tongue Bioinspired by Leading Edge of Owl Wing on Aerodynamic Performance and Noise of Multi-Blade Centrifugal Fan

Study on the Aerodynamic Performance of Multi-Blade Centrifugal Fan with Bionic Blades Inspired by Carangiform Fish

Influence of Bionic Front Grille Inspired by Long-Eared Owl Wing on Performance of Circulation Fan with Annular Impeller

Numerical Investigations on the Aerodynamic Performance of Turbine Stage with Nonaxisymmetric End Wall Profiling

Effect of Honeycomb Shroud Seals on Aerodynamic Performance of Turbine Stages

Related Author

刘小民

李烁

熊仲营

王梦豪

李典

王雷

WU Xianpeng

WEI Lai

Related Institution

GD Midea Environmental Electrical Appliance MFG Co., Ltd.

Institute of Turbomachinery, Xi'an Jiaotong University

Institute of Turbomachinery, Xi’an Jiaotong University

Guangdong Sunwill Precision Plastics Co., Ltd.

(School of Energy and Power Engineering, Xi'an Jiaotong University,,)

⁰