Experimental Research on the Ground Thermodynamic Vent System

doi:10.7652/xjtuxb201707002

您当前的位置：

首页 >

文章列表页 >

Experimental Research on the Ground Thermodynamic Vent System

更新时间：2025-07-09

- Experimental Research on the Ground Thermodynamic Vent System
- Vol. 51, Issue 7, Pages: 8-15(2017)
- 作者机构：
  
  西安交通大学能源与动力工程学院,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb201707002
  CLC： V511
- Online First：10 July 2017，
  
  Published：2017
- 稿件说明：
移动端阅览
Experimental Research on the Ground Thermodynamic Vent System[J]. 2017, 51(7): 8-15.
DOI：

Experimental Research on the Ground Thermodynamic Vent System[J]. 2017, 51(7): 8-15. DOI： 10.7652/xjtuxb201707002.

摘要

为深入研究热力学排气的控压性能以及消除外部漏热的能力

通过搭建地面热力学排气测试平台

采用R123为实验工质

在外部漏热为800 W、初始液位为0.595 m的条件下

开展了箱体增压、混合喷射降压以及节流制冷3种不同工作模式下的实验研究

分析了不同阶段箱体压力以及箱内流体温度变化。结果表明:在漏热增压阶段

箱体压增速率为60.583 kPa/h; 在混合降压阶段

增大循环流量对降低气相温度是有益的; 在循环流量为150 L/h、节流比为11.73%～13.33%的工况下

热力学排气系统工作8次

共排气20.536 kg

最大制冷量为1 362 W; 与直接排气方式相比

工作运行2 h

热力学排气可节省41%的排气损失。该结果可为进一步开展低温实验提供技术参考与借鉴。

Abstract

To conduct in-depth study on the performance of tank pressure control and the ability of heat leakage removing

an experimental rig was built to research the performance of thermodynamic vent system(TVS)with the simulant fluid of R123. The experimental research under three operation modes of tank pressurization

mixing injection depressurization and throttling refrigeration were conducted at the heat load of 800 W and the initial liquid height of 0.595 m. The tank pressure variation and fluid temperature change were analyzed during different operation modes. The results showed that

subjected to the external heat leak

the tank pressure rising rate was about 60.583 kPa/h during the tank pressurization phase; while in the mixing injection phase

increasing the circulation volume flow was beneficial to the reduction of vapor temperature. With the circulation volume flow of 150 L/h and the throttling rate of 11.73%～13.33%

the total venting gas was 20.536 kg for 8 throttling operation cycles. The maximum refrigeration capacity of one throttling operation cycle was 1 362 W. Compared with the direct venting gas approach

TVS has saved 41% exhaust loss for 2 hours' operation. The valuable conclusion could provide a technical reference for a further experiment on the cryogenic fluid thermodynamic vent system.

关键词

Keywords

references

FLACHBART R, HASTINGS L, MARTIN J. Testing of a spray bar zero gravity cryogenic vent system for upper stages [C]∥Proceedings of 35th Joint Propulsion Conference and Exhibit. Reston, VA, USA: AIAA, 1999: 1-10.

HEDAYAT A, BAILEY J W, HASTINGS L J, et al. Test data analysis of a spray bar zero-gravity liquid hydrogen vent system for upper stages [J]. AIP Conference Proceedings, 2004, 710(1): 1171-1178.

VANDRESAR N T. Liquid oxygen thermodynamic vent system testing with helium pressurization: NASA/TP-2014-216633 [R]. Washington, DC, USA: National Aeronautics and Space Administration, 2014: 1-39.

FLACHBART R H, HASTINGS L J, HEDAYAT A, et al. Testing of a spray-bar thermodynamic vent system in liquid nitrogen [J]. AIP Conference Proceedings, 2006, 823(1): 240-247.

FLACHBART R H, HASTINGS L J, HEDAYAT A, et al. Thermodynamic vent system performance testing with subcooled liquid methane and gaseous helium pressurant [J]. Cryogenics, 2008, 48(5): 217-222.

KARTUZOVA O V, KASSEMI M, MODER J P, et al. Self-pressurization and spray cooling simulations of the multipurpose hydrogen test bed ground-based experiment [C]∥Proceedings of 50th AIAA/ASME/SAE/ASEE Joint Propulsion Conference. Reston, VA, USA: AIAA, 2014: 1-19.

KASSEMI M, KARTUZOVA O. Effect of interfacial turbulence and accommodation coefficient on CFD predictions of pressurization and pressure control in cryogenic storage tank [J]. Cryogenics, 2016, 74: 138-153.

MAJUMDAR A, VALENZUELA J, LECLAIR A, et al. Numerical modeling of self-pressurization and pressure control by a thermodynamic vent system in a cryogenic tank [J]. Cryogenics, 2016, 74: 113-122.

MER S, THIBAULT J P, CORRE C. Active insulation technique applied to the experimental analysis of a thermodynamic control system for cryogenic propellant storage [J]. Journal of Thermal Science and Engineering Applications, 2016, 8(2): 021024.

胡伟峰, 申麟, 彭小波, 等. 低温推进剂长时间在轨的蒸发量控制关键技术分析 [J]. 低温工程, 2011(3): 59-66.

HU Weifeng, SHEN Lin, PENG Xiaobo, et al. Key technology analysis of boil-off control study on cryogenic propellant long-term application on orbit [J]. Cryogenics, 2011(3): 59-66.

李鹏, 孙培杰, 包轶颖, 等. 低温推进剂长期在轨储存技术研究概述 [J]. 载人航天, 2012, 18(1): 30-36.

LI Peng, SUN Peijie, BAO Yiying, et al. Research on long-term storage technology of cryogenic propellant in orbit [J]. Manned Spaceflight, 2012, 18(1): 30-36.

刘展, 厉彦忠, 王磊, 等. 低温推进剂长期在轨压力管理技术研究进展 [J]. 宇航学报, 2014, 35(3): 254-261.

LIU Zhan, LI Yanzhong, WANG Lei, et al. Progress of study on long-term in-orbit pressure management technique for cryogenic propellant [J]. Journal of Astronautics, 2014, 35(3): 254-261.

马原, 厉彦忠, 王磊, 等. 低温燃料贮箱热力学排气系统优化分析与性能研究 [J]. 低温与超导, 2014(7): 10-15.

MA Yuan, LI Yanzhong, WANG Lei, et al. Optimized analysis and performance study on thermodynamic vent system in cryogenic fuel tank [J]. Cryogenics Superconductivity, 2014(7): 10-15.

LIU Z, LI Y, ZHOU K. Thermal analysis of double-pipe heat exchanger in thermodynamic vent system [J]. Energy Conversion and Management, 2016, 126: 837-849.

陈忠灿, 黄永华, 汪彬, 等. 热负荷对R141b热力学排气系统自增压特性及排气损失的影响 [J]. 化工学报, 2016, 67(10): 4047-4054.

CHEN Zhongcan, HUANG Yonghua, WANG Bin, et al. Effect on self-pressurization characteristics and mass loss of thermodynamic vent system for refrigerant R141b by heat load [J]. CIESC Journal, 2016, 67(10): 4047-4054.

杨世铭, 陶文铨. 传热学 [M]. 第4版. 北京: 高等教育出版社, 2006: 268-270.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Digital Particle Image Velocimetry Measurement of Inner Flow Field in Cooling Chamber of Frost-Free Refrigerator

Experimental Research on Operating Characteristics of a New-Type Thermocompressor

Integrated and Joint Design Optimization of Centrifugal Compressor Impeller and Casing Treatment at Multiple Working Points

Numerical Simulation of the Energy Conversion Process in Thermoacoustic Engines with Different Stack Materials

Windage Loss and Flow Characteristics in Impeller Back Gaps of sCO2 Radial Inflow Turbines

Related Author

孟祥兆

俞炳丰

吴小华 1

杨俊玲 2

越云凯 1

杨鲁伟 2

Related Institution

Beijing Institute of Petrochemical Technology

Technical Institute of Physics and Chemistry, Chinese Academy of Sciences

⁰