Evaporation and Movement Characteristics of Single Liquid Nitrogen Droplet in High-Speed Gas Flow

doi:10.7652/xjtuxb201706023

您当前的位置：

首页 >

文章列表页 >

Evaporation and Movement Characteristics of Single Liquid Nitrogen Droplet in High-Speed Gas Flow

更新时间：2025-07-09

- Evaporation and Movement Characteristics of Single Liquid Nitrogen Droplet in High-Speed Gas Flow
- Vol. 51, Issue 6, Pages: 147-152(2017)
- 作者机构：
  
  西安交通大学能源与动力工程学院,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.7652/xjtuxb201706023
  CLC： TK121
- Online First：10 June 2017，
  
  Published：2017
- 稿件说明：
移动端阅览
Evaporation and Movement Characteristics of Single Liquid Nitrogen Droplet in High-Speed Gas Flow[J]. 2017, 51(6): 147-152.
DOI：

Evaporation and Movement Characteristics of Single Liquid Nitrogen Droplet in High-Speed Gas Flow[J]. 2017, 51(6): 147-152. DOI： 10.7652/xjtuxb201706023.

摘要

为了研究低温风洞中液氮喷雾降温蒸发特性

从而从微观上把握整个喷雾过程

以经典蒸发模型为基础

建立了适用于高速气流下的单液滴蒸发模型

计算了高速气流下单个液氮液滴的蒸发过程

得到其蒸发过程中液滴直径、速度、蒸发速率等参数的变化规律

并比较了环境温度、环境压力、气流速度等不同因素对各参数的影响。结果表明:环境温度对液滴蒸发速率影响较大

在100～300 K环境温度下

每升高100 K

2 m的距离内液滴相对蒸发量大约增加18%

而对液滴运动速度则基本没有影响; 气流速度越大

对流换热越强

液滴等时间蒸发速率越大

但由于蒸发距离一定

高速气流情况下的实际蒸发量减少

在上述条件下

10～30 m/s的速度范围内

相对蒸发量在5%～6%; 大粒径液滴具有大的绝对蒸发量

而小粒径液滴的相对蒸发量则较大; 随着环境压力的增大

蒸发速率会随之增加。

Abstract

An evaporation model of single moving liquid nitrogen droplet in high-speed gas flow is developed based on the classical evaporation model to reveal the evaporation of whole liquid nitrogen spray. The droplet evaporation rate

diameter and velocity are obtained in the evaporation process by adjusting ambient temperature

ambient pressure and gas flow velocity. The results show that for those parameters

the ambient temperature has greater influence on the droplet evaporation rate

which grows with temperature. Within the falling distance of two meters

with the ambient temperature riseing by every 100 K in the range from 100 to 300 K

the relative evaporation increases about 18%. The higher the gas flow speed reaches

the higher the droplet evaporation rate gets at equal time due to the stronger convection heat transfer

but the evaporation capacity decreases because of limited evaporation distance. Under above conditions

the relative evaporation is 5%～6% within the flow speed range of 10～30 m/s. Bigger droplet has bigger absolute evaporation capacity but smaller relative evaporation capacity

and the droplet evaporation rate rises with the ambient pressure.

关键词

Keywords

references

KILGORE R. Evolution and development of cryogenic wind tunnels [C]∥43rd AIAA Aerospace Sciences Meeting and Exhibit. New York, USA: AIAA, 2005: 457.

SPALDING D B. The combustion of liquid fuels [C]∥Fourth Symposium(International)on Combustions. Baltimore, Maryland, USA: Williams and Wilkins, 1953: 847-864.

YUEN M. Numerical study of droplet evaporation in a high-temperature stream [J]. Journal of Heat Transfer, 1983, 105(2): 389-397.

DOMBROVSKY, LSAZHIN S. A parabolic temperature profile model for heating of droplets [J]. Journal of Heat Transfer, 2003, 125(3): 535-537.

ABRAMZON B, SAZHIN S. Convective vaporization of a fuel droplet with thermal radiation absorption [J]. Fuel, 2006, 85(1): 32-46.

辛娟娟, 周致富, 辛慧, 等. 单个液滴蒸发模型中不同质量传递公式的有效性分析 [J]. 化工学报, 2012, 63(6): 1704-1708.

XIN Juanjuan, ZHOU Zhifu, XIN Hui, et al. Validation analysis of different mass transfer formula in single droplet evaporation model [J]. Journal of Chemical Industry and Engineering, 2012, 63(6): 1704-1708.

周致富, 辛慧, 陈斌, 等. 激光手术喷雾冷却中单个液滴蒸发特性 [J]. 中国激光, 2008, 35(6): 952-956.

ZHOU Zhifu, XIN Hui, CHEN Bin, et al. Evaporation characteristics of a single droplet in laser treatment of port wine stain in conjunction with cryogen spray cool ing [J]. Chinese Journal of Lasers, 2008, 35(6): 952-956.

丁继贤, 孙凤贤, 姜任秋. 对流条件下环境压力对液滴蒸发的影响研究 [J]. 哈尔滨工程大学学报, 2007, 28(10): 1104-1108.

DING Jixian, SUN Fengxian, JIANG Renqiu. Effects of ambient pressure on fuel droplet evaporation in a convective environments [J]. Journal of Harbin Engineering University, 2007, 28(10): 1104-1108.

SAZHIN S S, ABDELGHAFFAR W A, SAZHINA E M, et al. Models for droplet transient heating: effects on droplet evaporation, ignition, and break-up [J]. International Journal of Thermal Sciences, 2005, 44(7): 610-622.

马力, 仇性启, 王健, 等. 单液滴蒸发影响因素实验研究 [J]. 现代化工, 2013, 33(1): 103-106.

MA Li, QIU Xingqi, WANG Jian, et al. Experimental research on single droplet evaporation factors [J]. Modern Chemical Industry, 2013, 33(1): 103-106.

AWONORIN S. Evaporation rates of freely falling liquid nitrogen droplets in air [J]. Heat Transfer Engineering, 1989, 10(1): 26-36.

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Study on the Influence Mechanism of Ambient Temperature and Pressure on Single Droplet Evaporation Characteristics of HFE7100 Refrigerant

Cryogenic Cold Shield System in Space with Surface Temperature Distribution

Experimental Study on Heat Transfer Performance of Phase Change Spray Cooling with R134a

Effects of Expansion Angle Crater Film Hole on the Film Cooling Characteristics of a Double-Wall Structure

Bi-Level Multi-Obj ective Optimization of a Wind-Solar Coupled Hydrogen Production System Based on the Synergy of Hybrid Electrolyzer Arrays

Related Author

YIN Jing

LIU Yi

Leslie K.NORVIHOHO

CHEN Bin

ZHOU Zhifu

张周卫 1

厉彦忠 1

Related Institution

State Key Laboratory of Multipbase Flow in Power Engineering, Xi'an Jiaotong University

西安交通大学能源与动力工程学院

兰州物理研究所真空低温技术与物理国家重点实验室

State Key Laboratory of Multiphase Flow in Power Engineering, Xi'an Jiaotong University

⁰